a)
ET 545
B.Tech. DEGREE EXAMINATION, APRIL 2011.
Fourth Semester
Electrical and Electronics Engineering
PULSE AND DIGITAL CIRCUITS
Time : Three hours Maximum : 75 marks
~
op Yan»
PART A — (10 x 2 = 20 marks)
Answer ALL questions.
All questions carry equal marks.
Add the BCD numbers 00011001 and 00010100.
What is a demultiplexer?
Distinguish between synchronous and
asynchronous counter.
Write the features of static RAM.
Draw the state diagram of a D type Flip-Flop.
What is the significance of state assignment?
What is meant by linear wave shaping circuit?
Write the significance of clipping circuits.
What is Schmitt trigger circuit?
Write the condition on R for turn ON and OFF of
UJT sawtooth oscillator.iy,
12,
18.
14,
PART B—(5 x 11 = 55 marks)
Answer ALL the questions, ONE from each Unit.
Each question carry equal marks.
UNITI
(a) Implement a 4 bit binary multiplier usin )
shift method. 5)
(b). Design a 4 to 1 demultiplexer using AND
gate and verify the truth table. (6)
Or
Minimize the four variable logic function using
K-map.
f(A, B,C, D)=(4+B+0+D)-(A+C+D)-
(4+B+C+D)-(B+C).(B+C)-
(4+B):(B+D).
UNIT IT
Design a 3 bit binary Up/Down counter with )
direction tontrol. Use JK flip-flops.
Or
Draw the block diagram of ROM and explain its
operation. Also discuss the various types of ROM.
2 ET 545
15.
16.
17.
18.
19.
20.
UNIT HL
Design a serial binary adder using D flipflop.
Or
Describe the steps involved in design » of
asynchronous sequential circuit by considering an
example.
UNIT IV
Explain the behaviour of a passive integrator for
a square wave input and show the output
waveforms.
Or
Explain the various types of clamping: circuits
with cireuit diagram and waveform.
UNIT V
Draw the circuit diagram of a monostable
multivibrator. Explain its working with relevant
waveforms.
Or
Draw the circuit diagram of a UJT relaxation
oscillator. Sketch the output waveforms ead
explain the circuit operation.
3 ET 545