Professional Documents
Culture Documents
MEPCO Assistant Engineer Operations Test Questions
MEPCO Assistant Engineer Operations Test Questions
Oscillators
a. Positive feedback
b. Negative feedback
d. An LC tank circuit
d. Positive feedback
a. At low frequencies
b. At high frequencies
5. A coupling circuit is a
a. Lag circuit
b. Lead circuit
c. Lead-lag circuit
d. Resonant circuit
a. Positive feedback
b. Negative feedback
d. An LC tank circuit
a. 0
b. 1
c. Low
d. High
a. Notch filter
b. Twin-T oscillator
c. Phase shifter
d. Wheatstone bridge
a. One resistor
b. Two resistors
c. Three resistors
d. One capacitor
b
11. The phase-shift oscillator usually has
c. A lead-lag circuit
d. A twin-T filter
12. For oscillations to start in a circuit, the loop gain must be greater than 1 when the phase shift around the loop is
a. 90 degrees
b. 180 degrees
c. 270 degrees
d. 360 degrees
a. Armstrong
b. Clapp
C. Colpitts
d. Hartley
d. Means B is small
a. Decreases
c. Increases
d. Becomes erratic
a. Capacitive coupling
b. Transformer coupling
c. Resistive coupling
d. Power coupling
a. Negative feedback
b. Two inductors
c. A tungsten lamp
d. A tickler coil
a. One resistor
b. Two resistors
c. Three resistors
d. One capacitor
19. Of the following, the one with the most stable frequency is the
a. Armstrong
b. Clapp
c. Colpitts
d. Hartley
a. Quartz
b. Rochelle salts
c. Tourmaline
a. Low Q
b. High Q
c. Small inductance
d. Large resistance
c. Equal
d. Low frequencies
a. Armstrong
b. Clapp
c. Colpitts
d. Quartz crystal
24. A monostable 555 timer has the following number of stable states:
a. 0
b. 1
c. 2
d. 3
25. An astable 555 timer has the following number of stable states:
a. 0
b. 1
c. 2
d. 3
26. The pulse width out of a one-shot multivibrator increases when the
c. UTP decreases
b. triangular
c. rectangular
d. elliptical
a. Pulse width
b. Period
c. Duty cycle
d. Space
a. Pulse width
b. Period
c. Duty cycle
d. Space
30. When a PLL is locked on the input frequency, the VCO frequency
a. Is less than f0
b. Is greater than f0
c. Equals f0
d. Equals fin
a. Capture range
b. Lock range
c. Free-running frequency
d. Phase difference