Professional Documents
Culture Documents
MS - SM 999
MS - SM 999
1. DESCRIPTION
ADXTM Brickwall Plaster (999) is specially formulated with high water retentivity and cohesive strength for
thick plastering/rendering on brick wall. The enhanced properties improve workability, prevent wet stage
crack and failures due to premature loss of moisture. Hardened Brickwall Plaster (999) surface can be
further smoothened with ADXTM Skim Coat – Base and Top Coat. Suitable for interior and exterior use.
3. SUBSTRATE PREPARATION
4. MIXING
1. Mix 1 part of ADXTM Brickwall Plaster (999) with 3~4 parts of graded sand (by volume).
2. Add approximately 24~32L of clean water and mix thoroughly until lump-free homogeneous mortar
paste. Optimum mortar consistency can be achieved between 3 to 10 minutes of mixing.
5. APPLICATION
1. Apply ADXTM Brickwall Plaster (999) onto the prepared surface with steel trowel at thickness of 10-
15mm per layer.
2. Thicker plaster/render to be applied in layers. Allow underneath layer to cure for at least 12hours or
dry before application of the subsequent layers for optimum performance. The subsequent layer
should not be thicker or stronger than the previous coat.
3. For optimum performance, apply Skim Coat Top 7 days after application of plaster/render.
IMPORTANT NOTICE
This method statement provides general recommendations only and is not intended to be interpreted as generic specification
for the application/installation of the listed products. Technical Data Sheet (TDS) should be read in conjunction with this
method statement. Each project differs in exposure/condition, therefore specific recommendations may vary from the
information contained above. Kindly contact ADX for recommendations for specific applications. Edition ADX1812. This
edition will become invalid when a new version is published.