Professional Documents
Culture Documents
Casr 425
Casr 425
Casr 425
Course : D3 TPU 6 A
Nama :
No State of Questions
1 An aircraft engine manufacturer who is a Republic of Indonesia citizen, Indonesia may apply provisional type certificate for the aircraft for a
Class
2 Duration A Class I provisional type certificate is effective for …………………after the date of issue.
3 Duration A Class II provisional type certificate is effective for …………….after the date of issue
5 Maintain records of the completion of all inspections and tests required by section 21 for the products for at least ……………….years
8 Light sport, and provisional airworthiness certificates, special flight . permits, and experimental certificates are classified of…………..
11 eligible to perform DOA , and also design . and compliance relating to Type Cert and or Amendment is Class ……….
Page 1 of 3
12 eligible to perform DOA , and also design . and compliance relating to Supplemental Type Certificate is Class …………….
13 A major component e.g., wings, fuselages, empennage assemblies, landing gears, classified
14 The normal category is limited to airplanes that have a maximum certificated takeoff weight of ………………….pounds
15 The normal category, unless otherwise provided, a factor of safety of …………must be used.
16 The door when the internal locking mechanism is in the locked position must be openable from ……………..
17 for commuter category airplanes, This exit must have a rectangular opening of not less than 24 inches wide by …….. inches high
18 For an airplane with a total passenger seating capacity of 15 or fewer, an emergency exit, is required on ……….
19 The empennage structure must be designed to assure capability of continued safe after impact with an …………….pound bird
20 Cable Systems transport category airplane, No cable may be used in the aileron, elevator, or rudder systems smaller than …………..inch in
diameter
21 An unsafe condition when Evidence is found and this non compliance with the airworthiness reduces …………………required
22 Airworthiness directives issued by foreign airworthiness authorities will be adopted …………………….further technical investigation
23 issue an airworthiness directive based on When an unsafe condition exists and to correct that …………..condition
24 Actions required by airworthiness directives shall Specify inspections to be carried out; Resolve an unsafe and ……………………..must comply
with.
25 If there is a conflict between the service document and the airworthiness directive, …………………………..shall be followed
Page 2 of 3
Page 3 of 3