Professional Documents
Culture Documents
Quiz No. 1
Quiz No. 1
QUIZ NO. 1
INSTRUCTIONS:
1. Engineering drawing is a type of technical drawing that is used to convey information about an object.
2-3. Enumerate the two types of compasses. Friction joint compass and spring joint compass
5. protractor A drawing instrument that is made of celluloid and is used to construct and measure angles.
Hard Grade
Medium Grade
Soft Grade
9. Gaspard Monge He is an Engineer in the French Military, and he devised a system called
“Orthographic Projection”.
10. Dimensions are the size of the object that is captured in accepted units.
11. This represents what the item is made of. Material type
12. Geometrical Drawing is the art representation of geometrical objects such as rectangular, square etc.
on a paper.
13. T-square is used to draw horizontal lines. It consists of two parts. The long part is called “Blade”
while the short part is called “Head.” These two parts are fixed with
each other at 90° angle.
14. Using your ruler, make an isosceles trapezoid. Let the upper base be
4.30 cm., lower base be 6.80cm and height be 3.20cm. Find the
measurements of all interior angles.
15. Referring to item no. 14, what is the measurement of the non-parallel
sides?
16-19. Enumerate the 4 types of engineering drawing.
Geometrical Drawing
Mechanical Engineering Drawing
Electrical Engineering Drawing
Civil Engineering Drawing
20. From a certain point of reference, move 13.5 units to the South.
GOOD LUCK!