Professional Documents
Culture Documents
Fingerprint Access Wiring Schematic Diagram A
Fingerprint Access Wiring Schematic Diagram A
Fingerprint Access Wiring Schematic Diagram A
● Alarm 0 + RS485– ●
● Alarm 0 – Fire IN ●
doorbell
RS485 converter
Urgency button
power
+12V Power Power input +12V Power Power input
GND Earth wire GND Earth wire
evident alarm
Lock COM Lock common signal WG-IN 0 Wiegand in negative
The above instructions is electricity lock, using a special power supply access of the connection mode; Lock NC Normally close signal WG-IN 1 Wiegand in positive
Thanks to Convenient wire connection, simple operation, this product can directly substitute original inductive-card simple door control Lock NO Normally open signal GND Earth wire
machine, and don’t need any renovation;
Button Door open button WG-Out 0 Wiegand out negative
This product can be not only a independent simple door control machine, but also a fingerprint reader to access to door controller(through
GND Earth wire WG-Out 1 Wiegand out positive
WG26 protocol);
This product support three communication mode: U-disk, RS485, TCP/IP. The RJ45 port in machine back is TCP/IP communication port; D-Sensor Door magnet Alarm1 + Hidden alarm out positive
If there are some disaccord between this specification and the image pasted on door control machine, please refer to the newest wiring Bell+ Bell positive Alarm1 - Hidden alarm out negative
schematic diagram; Bell- Bell negative RS485A RS485 positive
The door control relay in the product is DC24V3A, and external alarm relay is DC24V1A, if the alarm is loaded directly by door control
Alarm0 + Evident alarm out positive RS485B RS485 negative
machine, please notice the label.
Alarm0 - Evident alarm out negative Fire In Input alarm