This document provides a 23-item checklist for inspecting emergency showers and eye washes. Key items include: (1) showers must include eyewashes, (2) equipment must be corrosion resistant, (3) only potable or certified water can be used, and (4) water supply must provide adequate flow for 15 minutes. Locations must be accessible within 10 seconds without stairs/ladders and a minimum distance from hazards and electrical equipment. Signage in Arabic and English is also required.
This document provides a 23-item checklist for inspecting emergency showers and eye washes. Key items include: (1) showers must include eyewashes, (2) equipment must be corrosion resistant, (3) only potable or certified water can be used, and (4) water supply must provide adequate flow for 15 minutes. Locations must be accessible within 10 seconds without stairs/ladders and a minimum distance from hazards and electrical equipment. Signage in Arabic and English is also required.
This document provides a 23-item checklist for inspecting emergency showers and eye washes. Key items include: (1) showers must include eyewashes, (2) equipment must be corrosion resistant, (3) only potable or certified water can be used, and (4) water supply must provide adequate flow for 15 minutes. Locations must be accessible within 10 seconds without stairs/ladders and a minimum distance from hazards and electrical equipment. Signage in Arabic and English is also required.
This document provides a 23-item checklist for inspecting emergency showers and eye washes. Key items include: (1) showers must include eyewashes, (2) equipment must be corrosion resistant, (3) only potable or certified water can be used, and (4) water supply must provide adequate flow for 15 minutes. Locations must be accessible within 10 seconds without stairs/ladders and a minimum distance from hazards and electrical equipment. Signage in Arabic and English is also required.
Southern Area Well Completion Operations Department
Operational Excellence & Compliance Group
Emergency Shower and Eye Wash Checklist Division: Week#: # ITEMS Remarks 1 Emergency shower installation include eyewash 2 Eyewashes and showers are resistant to corrosion. 3 Potable water or water certified by Saudi Aramco is used 4 Systems is flushed for at least three minutes 5 Water supply is capable of providing flow for at least 15 minutes. 6 Water supply systems is continuously available for use 7 Eyewash nozzles is protected with covers for protection 8 Eye wash cover is easy to remove 9 Delivered water temperature shall not be more than 38°C 10 Delivered water temperature shall not be less than 15°C 11 Emergency shower and eye wash is accessible within 10 seconds 12 Distance is no closer than 3 m nor further than 15 m from hazard 13 Outside of the most likely spray paths such as sample and drain points. 14 On the same floor level as the hazard. 15 In a location accessible without the use of stairs, a ladder or a door. 16 Upwind, based on the prevailing wind, of the hazard where practical 17 At least 3 m (10 ft.) from electrical equipment and power outlets 18 Block valves in the water supply system is car-sealed open No permanent or temporary connections are made to the water supply for 19 other purposes Eye wash is equipped with strainer in the water supply to prevent solid 20 particles from entering the eyes. Vertical background area nominally 1 m wide by 2 m high painted with 21 either alternating green and white stripes approximately 152 mm wide or a solid green color The appropriate sign with words, in Arabic and English are mounted in a 22 clearly visible location near the emergency shower and eyewash 23 Eyewashes and showers are provided with drainage Legend: (In good condition) X (With deficiency)