Professional Documents
Culture Documents
1875 Weekly Tech Quiz 126 28 12 19
1875 Weekly Tech Quiz 126 28 12 19
2019)
TEST YOURSELF
ELECTRICAL ENGINEERING
1. A network has 10 nodes and 17 branches. The number of different node pair voltage would be :
(a) 7 (b) 9 (c) 45 (d) 10
2. Which of the following theorems can be applied to any network-linear or nonlinear, active or
passive, time-variant or time-invariant?
(a) Thevenin theorem (b) Norton theorem
(c) Tellegen theorem (d) Superposition theorem
3. Across the surface of a charged conductor, the electric :
(a) Field is continuous (b) Potential is discontinuous
(c) Field is discontinuous (d) None of these
4. In a purely resistive circuit, the average power Pav is ________________ the peak power Pmax.
(a) Double (b) One-half of (c) One-fourth (d) Equal to
5. The bandwidth of a resonant circuit is given by :
R fr 2πR
Hz Hz Hz
(a) 2πL (b) Q (c) L (d) Both (a) and (b)
6. The principle of dynamically induced emf is utilised in :
(a) Transformer (b) Choke (c) Generator (d) Thermocouple
7. The voltmeter connected across a generator reads voltage same at no load and at full load (rated).
The generator is of the type :
(a) Shunt generator (b) Series generator
(c) Level compound (d) Short-shunt compound
8. In cross-field generators :
(a) The reversal of speed does not reverse the polarity of the output.
(b) Compensating winding is provided in order to increase the amplification factor
(c) The number of brush studs is double of that of poles.
(d) All of the above
9. Transformer action requires a :
(a) Constant magnetic flux (b) Increasing magnetic flux
(c) Alternating magnetic flux (d) Alternating electric flux
10. A distribution transformer is selected on the basis of :
(a) Voltage regulation (b) Efficiency (c) All day efficiency (d) None of these
11. The value of load angle for a synchronous motor depends mainly upon its :
(a) Excitation (b) Load (c) Speed (d) Supply voltage
12. At the instant of starting, the per unit slip of the 3-phase induction motor is :
(a) 0.05 (b) 0.1 (c) 1.0 (d) 0.5
13. An induction motor can run at synchronous speed if it is operated :
(a) On no-load
(b) On full load
(c) With emf injected in the rotor circuit
(d) On voltage higher than the rated voltage
14. A material with unequal, antiparallel atomic magnetic moments is called ______________ material.
(a) Ferrimagnetic (b) Ferromagnetic
(c) Antiferromagnetic (d) None of these
15. Electrical machines having power output rating up to about 750 W may be called the
_______________ size machines.
(a) Small (b) Medium (c) large (d)none of the above
ANSWER KEYS
1 c 6 c 11 b 16 d
2 c 7 c 12 c 17 b
3 c 8 d 13 c 18 b
4 b 9 c 14 a 19 c
5 d 10 c 15 a 20 b
MECHANICAL ENGINEERING
21. Pressure ratio in gas turbines is the ratio of
(a) Compressor pressure ratio
(b) Highest pressure to exhaust pressure
(c) Inlet pressure to exhaust pressure
(d) Pressures across the turbine
22. Corrosion resistance of steel is increased by addition of
(a) Chromium and nickel
(b) Sulphur, phosphorus, lead
(c) Vanadium, aluminium
(d) Tungsten, molybdenum, vanadium, chromium
23. A cycle consisting of _________ and two isothermal processes is known as Stirling cycle.
(a) Two isentropic
(b) One constant pressure, one constant volume
(c) Two constant volumes
(d) Two constant pressures
24. If a given force (or a given system of forces) acting on a body __________ the position of the body,
but keeps it in equilibrium, then its effect is to produce internal stress in the body.
(a) Change (b) Does not change
(c) Changes periodically (d) None of these
25. Which of the following statement is wrong?
(a) The heat transfer in liquid and gases takes place according to convection
(b) The amount of heat flow through a body is dependent upon the material of the body
(c) The thermal conductivity of solid metals increases with rise in temperature
(d) Logarithmic mean temperature difference is not equal to the arithmetic mean temperature
difference
ANSWER KEYS
21 b 26 d 31 a 36 c
22 a 27 a 32 d 37 d
23 c 28 b 33 b 38 b
24 b 29 c 34 d 39 b
25 c 30 b 35 c 40 b
ANSWER KEYS
41 b 46 a 51 c 56 d
42 d 47 b 52 c 57 c
43 b 48 c 53 a 58 b
44 a 49 c 54 a 59 b
45 a 50 b 55 a 60 c
CIVIL ENGINEERING
61. Under external loads the stress is developed in the body due to
(a) Heating (b) Deformation of particles
(c) Cooling of particles (d) None of the above
ANSWER KEYS
61 b 66 a 71 d 76 a
62 d 67 a 72 c 77 c
63 a 68 a 73 d 78 d
64 c 69 a 74 c 79 c
65 d 70 a 75 c 80 b
GENERAL AWARENESS
81. Permanent hardness of water may be removed by the addition of
(a) Alum (b) Sodium carbonate
(c) Lime (d) Potassium permanganate
82. Which synthetic fibre is known as artificial silk ?
(a) Cotton (b) Rayon (c) Terylene (d) Nylon
83. In which of the following processes, is Vanadium pentoxide used as a catalyst ?
(a) Contact process (b) Haber’s process (c) Solvay process (d) None of these
84. Radioactive substances can be produced readily in a/an
(a) Wilson cloud chamber (b) Atomic pile
(c) Electron gun (d) Transistor
85. The thyroid gland is situated near which of the following organs ?
(a) Liver (b) Spleen (c) Larynx (d) Kidney
86. Which of the following belongs to the family of fishes ?
(a) Silverfish (b) Starfish (c) Cuttlefish (d) Shark
87. BCG vaccination (Bacillus Calmette Gruerine) is injected to get immunity from
(a) Polio (b) Cholera (c) Small pox (d) Tuberculosis
88. In which of the following countries was Buddhism first propagated outside India ?
(a) Sri Lanka (b) Combodia (c) Thailand (d) China
89. The great Indian philosopher Sankara advocated
(a) Advaita (b) Dvaita (c) Vishistadvaita (d) None of these
90. Vikramasila University was founded by
(a) Chandragupta Maurya (b) Kanishka (c) Dharmpala (d) Pulakesin II
91. Which of the following writs is a bulwark of personal freedom ?
(a) Mandamus (b) Habeas Corpus (c) Quo Warranto (d) Certiorari
92. Which Judge of the Supreme Court was unsuccessfully sought to be impeached ?
(a) Justice H.R. Khanna (b) Justice A.N. Grover
(c) Justice M. Hidayatullah (d) Justice Ramaswami
93. The formation of linguistic states in India started with
(a) Haryana (b) Maharashtra (c) Andhra Pradesh (d) Kerala
ANSWER KEYS
81 b 86 d 91 b 96 d
82 b 87 d 92 d 97 b
83 a 88 a 93 c 98 c
84 b 89 a 94 a 99 b
85 c 90 c 95 d 100 d