Professional Documents
Culture Documents
Cn8813 Lab1 Rip Eigrp
Cn8813 Lab1 Rip Eigrp
Cn8813 Lab1 Rip Eigrp
Configure Frame Relay and VLANs on the pnr7 and pns1 devices to achieve the
following network topology below. Note: pnr7 and pns1 configuration is provided with
the pod’s diagram online; you can copy and paste these configurations to the device
command line.
1
I) Routing with RIP
1. Use the table below to assign appropriate IP addresses to the routers in your pod.
4. Use “show ip protocol” command to verify that the RIP is configured correctly.
5. Display the current state of the routing table. The table should have entries for all
the subnets in your pod. Which subnets are discovered by the RIP?
6. Ping the routers across the Ethernet link. Can you successfully reach all the
routers?
4. Use “no ip classless” command to setup the classful routing. Setup a default route
from the subnets of 10.1.0.0 network to the subnets of 10.2.0.0 network. Can you
ping the subnets in the other network?
5. Use the command “ip classless” to enable classless routing. Can you ping the
subnets in the other network?
6. Disable RIP at all the interfaces of your router, remove all the default routes and
use “no ip classless” command to restore classful routing.
7. Configure EIGRP at all the routers in your pod. Use autonomous-system number
100.
2
8. After configuring EIGRP, ping the subnets in the other network. Are the pings
successful this time?
2. Use the “show ip eigrp neighbors” command to display the neighbor table.
3. Use the “show ip eigrp topology” command to display the content of the topology
table. This table shows you only successor and feasible successor routes. Answer
the following questions using the output:
3. Calculate the maximum possible bandwidth setting for s0 in PnR2 to satisfy the
following conditions:
• PnR2 chooses the route to the subnet 10.1.2.0/24 through subnet 10.1.3.0/24
as the successor route.
• PnR2 also chooses the alternate route to subnet 10.1.2.0/24 as the feasible
successor route.
V) EIGRP Summarization
1. Write a summarization statement for the subnets in at least one network. Choose
the summarization that has the shortest subnet id.
2. Use the route summarization statement above to configure PnR2 such that the
router only advertises the summarized route to its peer at subnet 172.16.1.0/24.
3
3. Show the routing tables on the routers of the other network. They should have the
summary routes.
VI) Convergence
1. Disable the Frame Relay link between the pnr2 and pnr3 routers. Enable e0
interface of the pnr3 router and verify VLAN configuration of the pns1 switch to
match the topology displayed below.
5. Display the routing table of PnR1 and make sure that you see all the subnets,
especially subnet 10.3.128.0/24.
6. Now shut down the e0 interface of PnR3, measure the time it takes for PnR1 to
learn a new route to subnet 10.3.128.0/24.