Professional Documents
Culture Documents
Quiz No. 3
Quiz No. 3
Quiz No. 3
3
STUDENT NAME: ___________________________________ DATE: ______________
STUDENT NUMBER: _______________________________ SCORE: _____________
INSTRUCTIONS:
Use five (5) decimal places for your calculations but record your final answer/s in two (2) decimal places.
Each of your problem set solutions should be written on a new sheet of paper. The following rules will
apply in the grading of problem sets. Points will be deducted for each of the following items:
Note: No need to rewrite the problem. Just present your solutions. Use AISC section database if applicable.
Assume given loads as service load (unfactored) unless otherwise specified.
A built-up section was made using PL414x12mm thk plates as shown in the figure below. It is pinned at
both ends with additional support against weak axis at middle point. Assume A50 steel.
PL414x12
W16x67
L
Section
x-axis y-axis
Elevation
P a g e 1 of 3
Problem No. 2 (40 points)
Design all members in the truss shown below using only W14 steel sections considering the factored loads
Pu = 850kN. Assume k = 0.9 and use LRFD and A36. Ignore weights of truss members. The truss was
supported by a pin support at the left and a rocker support at the right. Maintain a DCR value of 0.80 to
0.90 and use the most economical section. Apply design of tension and compression members. Ignore
rupture and block shear failure for tension members. Use compact section only.
Pu
G
Pu Pu
1.8m
H F
Pu Pu
1.8m A E
B C D
3m 3m 3m 3m
P a g e 2 of 3
Problem No. 3 (30 points)
A 3.5m long column (W18x55) at the ground floor is pinned at the bottom and fixed against rotation but
free to translate at the top. Use ASD and A36 steel.
6m
6m
7.5m 7.5m
3m
3m
3.5m
7.5m 7.5m
(b) Elevation
P a g e 3 of 3