Professional Documents
Culture Documents
Designing of 3D Model of Crank
Designing of 3D Model of Crank
Designing of 3D Model of Crank
2. Next, we sketched a circle of 20mm (2nd circle) at the center point of previous circle.
3. Furthermore, we trimmed our first circle of 120mm to half and another circle of 20mm is
drawn. Then a rectangle is drawn on the upper side of 1st circle which is also trimmed
using Trim Entities cmd. This process is shown in the picture below.
4. Now we’ve used Sketch Fillet cmd to draw fillets on the rectangle corner to shape it.
5. Then we’ve used Boss-Extrude cmd to extrude our 2D sketch to 3D Model. We extruded
it to 15mm.