Professional Documents
Culture Documents
CXC Large Excavator TEST Update 052012
CXC Large Excavator TEST Update 052012
Read each question carefully and select the appropriate answer. The pre/post test assessment has been
developed from the course content. It will be used to assess your knowledge both before and after the training
course. This will assess your knowledge of some of the key points of your learning experience. Rev. 05/2012
Answer Answer After
Questions: Options: Prior to
Course
Course
Completion
1. Which statement is correct in regards to the A. Physically the same with different
machine controllers A and B? software.
B. Physically the same with the same
software and different part numbers
C. Physically the same with the same part
numbers and same software.
D. Physically different with different part
numbers.
2. The ________ measures the DPD pressure A. Differential pressure switch
on each side of the DPF. B. Differential pressure sensor
C. Diesel Oxidation Catalyst
D. Mass air flow sensor
3. Where is the engine controller located? A. Mounted on the engine
B. Behind the cab
C. By the engine fire wall
D. In the cab behind the seat
4. Where is the machine controller (Controller A A. Mounted on the engine
and B) located? B. By the engine fire wall
C. In the cab behind the seat
D. Behind the cab
5. During Manual Regeneration, what two A. P1 flow control and boom
proportional solenoids get energized to apply B. Bucket close and P1 flow control
a hydraulic load on the engine to keep the C. Arm close and boom up
engine at optimum operating temperature? D. Boom up and bucket close
6. What can be done if the machine controllers A. Change the KPSS switch to release
fail and you need to move the machine to a B. Turn the “Limp Home Mode” switch on
safe place? C. Manually change the pump spools by
loosening the jam nuts and turning the
set screws all the way out until they
reach the stops.
D. Disconnect the machine controllers
7. Where is the Main Relief valve located on all A. On the pilot pump
of the CX_C large excavators? B. Between the two main hydraulic pumps
C. On the main control valve
D. Valve assembly just behind the cab
8. How can the flow for (P1) and (P2) pumps A. By changing the amperage of the P1 flow
flow oil quantities independently from one proportional control valve
another? B. By changing the amperage of the P2 flow
proportional control valve
C. By activating the power up solenoid
D. By activating or deactivating the shut off
valve
9. What switches on the monitor can be A. Auto Idle/Idle Stop and Wiper switches
pressed to lock the swing motor? for 3 seconds
B. Auto Idle/Idle Stop, Washer, and Travel
select switches for 3 seconds
C. Travel, Light, & Auto Idle/Idle Stop
switches together for 3 seconds
10. How many work modes do the CX_C large A. 2
excavators have? B. 3
C. 4
Name Score (%)
PRE/POST TEST ASSESSMENT (cont'd)