Professional Documents
Culture Documents
10.b PAM (Sample & Hold)
10.b PAM (Sample & Hold)
Procedure:
Connect the circuit as shown in next figure
• Output of sine wave to modulation signal IN of PAM block.
• 8 KHz pulse output to pulse IN of PAM block.
• Keep the frequency selector switch in 1 KHz position.
Switch ‘On’ the Power Supply & Oscilloscope.
Observe the output of sample & hold circuit at TP4, together with Modulation signal
input TP (2) and Pulse input TP (1). This is Sample & Hold output.
[CH1(Y) – 2V; CH2(X) – 2V; Time base – 0.2mS]
1
ANALOG COMMUNICATION;4th SEM
Deptt. OF ETC,JIST Expt 10.b PAM
Vary the amplitude of input sine wave & its frequency by the frequency change over
switch to 2 KHz.
Also vary the input pulse's frequency by connecting the pulse input to different Square
wave frequencies available on-board viz. 16, 32, & 64 KHz.
Switch ‘On’ fault No. 1, 2 & 3, one by one & observe their effect on Pulse Amplitude
Modulation output, and try to explain reason behind them.