Professional Documents
Culture Documents
Sharp MX-4100N, MX-4101N, MX-5000N, MX-5001N (SERV - MAN14) Service Manual - FREE DOWNLOAD - Service Manual-Section 6-Simulations
Sharp MX-4100N, MX-4101N, MX-5000N, MX-5001N (SERV - MAN14) Service Manual - FREE DOWNLOAD - Service Manual-Section 6-Simulations
MX-4101N
MX-5000N
MX-5001N (serv.man14)
Pages: 127
Size: 1.88 MB
Type: PDF
Document: Service Manual
Brand: Sharp
Device: Copying Equipment /
Service Manual-Section 6-
Simulations
File: mx-4100n-mx-4101n-mx-
5000n-mx-5001n-
sm14.pdf
Date: 2018-11-20
1. General (Including basic operations)
The simulation mode has the following functions, to display the
machine operating status, identify the trouble position and causes
in an earlier stage, and make various setups and adjustments
speedily for improving the serviceability of the machine.
Various adjustments
1)
2) Setting of the specifications and functions
3) Canceling troubles
4) Operation check
5) Counters check, setting, clear
6) Machine operating conditions (operation hysteresis), data
check, clear.
A. Basic operation
(Note for the simulation mode)
Do not turn OFF the power switch on the operation panel when the
machine is in the simulation mode. If the power switch should be
turned OFF in the simulation mode, a malfunction may be resulted.
In this case, turn OFF/ON the main power source.
START (Copy mode)
Press the Program key.
Press the asterisk (*) key.
Press the clear key.
Press the Program key.
Standby for entry of Press the SYSTEM
SIM code. SETTINGS key
Enter the main code of
SIM with the 10-key.
The main code of SIM
is displayed.
NO
MX-4101N SIMULATION 6 – 1
Press the START button. Is it the same
YES
simulation main
code?
In the power OFF/ON type
Standby for entry of SIM YES
Is there a sub code ? <Exclusion type> simulation, OFF/ON
sub code
You have to exit message is
Press the SYSTEM
simulation mode displayed by the
SETTINGS key
NO before entering into SYSTEM
Enter SIM sub code with
this mode for self SETTINGS key.
the 10-key. YES
printing type.
Select the mode and the Do you want
NO
Press the START button. item with the scroll key to perform another
and the item key. simulation ?
The simulation mode
is canceled.
NO
If there is no item. YES Press the EXECUTE button
Operation check ?
and OK button.
NO Do you YES
Operation is made according
want to end the Press the clear all key.
to the selected mode and item.
simulation ?
YES Press the EXECUTE button
Operating conditions
check ? and OK button.
NO
The display is made according to
the selected some and the item.
2. List of simulation codes
2 MX-4101N SIMULATION 6 – 2
Used to check the operations of each fan motor and its control circuit. Others
3 Used to check the operations of the primary transport unit and the control circuit. Process (Transport)
6 Used to check the operation of the fusing separation. Fusing
7 1 Used to set the operating conditions of aging. Others
6 Used to set the operating intermittent aging cycle.
8 Used to display the warm-up time.
9 Color setting in the color copy test mode (Used to check the copy operation and the image quality for each
color).
2 Used to check and adjust the operation of the main charger grid voltage in each printer mode and the Process (Charging)
control circuit.
* When the middle speed is adjusted, the low speed are also adjusted simultaneously.