Professional Documents
Culture Documents
Optimization For CSFB Call Delay
Optimization For CSFB Call Delay
Optimization For CSFB Call Delay
www.huawei.com
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page1
Optimization1-Improvement in 3G-RAU
delay
for
Introduction :
CSFB
If the CSFB user contains IE “CSFB Indication” in RRC Connection Request, RNC will send the routing
area update message to the CN only after it receives a RADIO BEARER SETUP COMPLETE message or
after "Delayed Routing Area Update Timer for CSFB UEs" expires .
Network performance:
Activation:
SET URRCTRLSWITCH: ImprovementSwitch=CSFB_UE_DELAY_RAU_SWITCH-1;
Gain effect:
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page2
Optimization2-Improvement in 3G-Fast
Radio Bearer Setup for single CS RAB
Introduction :
The RB setup message does not include the activation time. The UE activates the new configuration
immediately after receiving the RB setup message.
Network performance:
None.
Activation:
ADD/MOD UCELLCONNALGOPARA:CellId=XXX,CellConnAlgoSwitch=SINGLE_CS_RAB_FAST_RB_SETUP_SWITCH-1;
Gain effect:
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page3
Optimization3-Improvement in 3G-RB
SETUP message Optimization
Introduction :
1. If the RRC SETUP REQ message has contained the IE "RB mapping info", the RRC RB SETUP
message does not need to contain the IE, which shortens the transmission delay of the RRC RB SETUP
message.
Network performance:
None.
Activation:
SET URRCTRLSWITCH:ImprovementSwitch=RB_SETUP_RLC_INFO_OPT_SWITCH-1
Gain effect:
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page4
Optimization4-Improvement in 4G-Protocol
Message
Introduction :
Optimization for idle CSFB
If this option is selected and the preferred CSFB policy for UEs in idle mode is redirection, the eNodeB no
longer activates security mode or performs RRC connection reconfiguration, but sends a redirection
message. And the CSFB delay will be shorten.
Network performance:
None.
Activation:
Gain :
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page5
Optimization5-Improvement in 4G-
Optimization default paging cycle
Introduction :
Set the default paging cycle to 320ms, and the paging delay for idle CSFB will be shorten
Network performance:
Activation:
MOD PCCHCFG: LocalCellID=xx,DefaultPagingCycle=rf32;.
Gain :
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page6
Thank you
www.huawei.com
Appendix
Early Alerting Optimization
There two alerting modes for the MO-CSFB UE: early alerting mode
and normal alerting mode
Early alerting mode: the MSC sends the alerting message to the MO UE, it doesn’t rely on whether the MT UE
sends the alerting message of the MSC. So the MO E2E CSFB latency doesn’t contain the MT CSFB setup latency;
Normal alerting mode: the MSC won’t send the alerting message to the MO UE until receive the alerting message
from the MT UE. So the MO E2E CSFB latency contains the MT CSFB setup latency.
CSFB Procedure
CM Service Request
Authentication and Security Mode Procedure
CSFB Procedure
RAB Setup Procedure
RRC Connection Procedure
Paging Response
Authentication and Security Mode Procedure
Call Confrim
RAB Setup Procedure
Alerting
Connect
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page8
Appendix
Early Alerting Optimization
According to the MSC configuration of HW MSC, the early alerting switch is OFF
According to the UE log of NorthEast region test, it seems that NorthEast region uses
early alerting mode. As is shown below:
According to the MT UE, although the MT UE successfully falls back to 3G, it doesn’t finish the call setup
procedure, e.g. it doesn’t send the alerting message to the MSC, the MT CSFB is failure;
But, the MO UE stills receives the alerting message. It means the MO alerting message doesn’t rely on the MT
alerting message.
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page9
Appendix
Or we suggest modifying the E2E CSFB setup latency calculation formula to eliminate
alerting mode difference. And the following picture shows the compare result with new and
old formula in the same test.
Copyright © 2010 Huawei Technologies Co., Ltd. All rights reserved. Page10