Professional Documents
Culture Documents
SOAL IOH NOKIA 1-81 Soal Baru
SOAL IOH NOKIA 1-81 Soal Baru
2). Issues with 4G MIMO mode control can cause by following statement, except:
4). In the 3GPP evolved release 10, transmission modes are support to:
2. 1db
3. 2.db
4. 4db
2. PDCCH occupies the REs not used by PCFICH and PHICH and Reference Signals within the rst 1, 2
or 3symbols of each TTI
8). When is the best ming to get measurement of UL RSSI Interference that possible indicate
internalhardware problem?
1. 128 QAM UL
2. 256 QAM UL
3. 256 QAM DL
4. 64 QAM DL
2. Tx2relocaon mer
3. X2 issue
4. 2 MIB + 9 SIB
12). Which event that The non-contenon based random access are applicable to ?
1. All Event
2. RRC re-establishment
4. Inial Access
13). Reference Signal occupies how many resource element is 2 transmit antennas?
1. 16
2. 32
3. 8
4. 24
2. TA list ensures that the locaon of UE is available to the MME at all instants of me
4. Increase latency
17). Handover are essensal procedure for UE moving from cell to cell. What are the 4G Handover
Event?
19). Is there any relaon between low 2G CSSR and high capacity ?
20). Which of the following that you will not do if you nd 2G TBF Downlink Success Rate is not pass
thetarget baseline ?
4. Downlt from 4 to 10
3. Frequency synchronizaon
24). When throughput test shows low throughput value for TCP, but UDP throughput is high, what
couldbe the cause?
3. upgrade BW to 20 Mhz
4. change dlMimoMode to 43
26). what is below is not correct condion that cell reselecon will trigger in 4G inter-frequency?
27). what is below is not correct condion that cell reselecon will trigger in 4G intra frequency?
29). Which of the following parameter mush have the same seng for Pcell and Scell when CA
isacvated?
3. 2), 3) and 4)
4. 1), 3) and 4)
1. Transfer of an ongoing call/data session from a cell to another without call interrupon
3. Transfer of an ongoing call/data session from a cell to another, but requires connecon release
priorto the transfer the ongoing call
4. Procedure dedicated for call transfer from LTE to GSM; it requires connecon release
1. PUSCH
2. PDCCH
3. PDSCH
32). 4G Coverage Based Handover will be only performed under what condion?
1. RSRP at serving cell > threshold3 and RSRP at target < threshold3a
2. RSRP at serving cell > threshold3 and RSRP at target > threshold3a
4. RSRP at serving cell < threshold3 and RSRP at target > threshold3a
4. Avoiding PDCCH transmission on DL CCs that are close in frequency to UL CCs to avoid desensing
thereceiver.
35). How many carrier per pipe maximum for AHHB Nokia AirScale RRH 4T4R ?
1. Up to 16
2. Up to 8
3. Up to 12
4 Up to 4
36). In 4G Intrafreq handover, in what condion UE will not measure or report any neighbor cells RSRP ?
2. If RSRP of serving cell is greater than threshold1, only serving cell is measured
1. 4db
2. In typical TDD deployments, the number of CCs and the bandwidth of each CC in UL an DL is the same.
3. d.CCs originang from the same eNB need not provide the some coverage
4.The number of DL/UL CCs that can be congured epends on the DL/UL aggregaon capability of the UE
38). What is the rst thing you do when you nd degradaon on KPI?
39). For Volte services, which QCI will be use as resources bearer ?
41). The CQI is dened as a table containing 16 entries with modulaon and coding schemes
(MCSs).Which one is correct for represenng the modulaon ?
43). What is the parameter you will change if you want to decide the absolute priority of the 4G
servingcell
1. cellReSelPrio (This is the priority of the own cell. It depends on the layering plan. The cell
reseleconpriority parameter denes the absolute priority of the serving layer. 0 means the lowest
priority. Equalpriories between RATs are not supported according to [3GPP 36.304].)
2. uCelResPrio (Depends on layering plan. LTE prio > 3G prio > GSM prio. Absolute priority of the
UTRAcarrier frequency. Equal priories between RATs are not supported according to [3GPP 36.304].
3. gcelResPrio (LTE prio > 3G prio > GSM prio. Its value depends on layering plan of the operator.
UsuallyGERAN would be the last resort coverage layer and low priority is used. Absolute priority of the
GERANcarrier frequency. Equal priories between RATs are not supported according to [3GPP 36.304].
4. eutCelResPrio (Depends on layering plan. Absolute priority of the EUTRA carrier frequency.
Equalpriories between RATs are not supported according to [3GPP 36.304].
44). There is 4 types on preamble, what is the signicant dierence between this 4 types ?
1. PRB Number
2. Reference Signal
2. S1 Release
3. PGW Selecon
4. Service request
47). Which of the folllowing is not correct about the reason of 4G ERAB Drop ?
2. PUSCH RLF
3. TA Expiry
48). Which network element of NOKIA's LTE soluon performs the E2E monitoring and
reporngfuncons?
3. PCS-5000
4. Netact
49). What parameter to dene the maximum numbers of preambles allowed in one preamble
rampingcycle ?
2. PRACHRequired ReceivedCI
3. PRACH_Preamble_retrans
4. UETxPowerMax PRACH
50). Which network element always triggers the user network authencaon process
1. S-GW
2. MME
3. P-GW
4. eNodeB
51). A new site is on air with condion low revenue sites. What will you NOT do ?
52). What is the bad impact on applying Closed Loop Power Control in 4G ?
3. No bad Impact
53). What is parameter cellreselprio do ?
54. Select the factor that does NOT improve the Spectral Eciency In Massive MIMO ?
1. Muluser gain
2. UL interference cancellaon
3. 3D beamforming
1. eNodeB2.
S-GW
3. HSS4. MME
57. Without this feature VOLTE call will drop when it leaves the LTE coverage ?
1. 12
2. 24
3. 48
4. 36
60. Which of the following opons does NOT improve the latency as part of the Radio
NetworkOpmizaon Procedures?
1. 5MHz
2. 2MHz
3. 10 MHz
4. 20 MHz
63. How does MIMO improve spectral eciency, network capacity and throughput
1. By using mulple uplink and downlink transmiers
2. By using mulple receiv and transmit antennas3. By using mulple eNB sites
66. What air interface technology has been dened for LTE uplink ?
1. SC_FDMA
2. WCDMA
3. GSMK
4. OFDMA
68. what is below is correct condion that cell re-selecon will trigger measurement in 4G intra-
frequency?
69. what is below is correct condion that cell reselecon will trigger in 4G inter-frequency?
70.You are in opmizing 1 new site, you see 2G TCH Blocking is not Pass the target KPI. What will
youdo ?
1. Disable the Halfrate so the cell can go full rate to accomade full service
3. X2 issue
72. What will you do if nd cell with high PRB Ulizaon ?
3. Downlt from 2 to 10
74. in Mapinfo you can map the enre site in region to get informaonvisually. What is the funcon
if highlighted yellow in picture ?1.To query selected data from table
75. Aer check MDT, you nd that low SNIR happen across the main street. What is the best will
youdo?
3. Uplt all cells that cover the main street to get best coverage
4. Downlt all cells that cover the main street to get best coverage
77. Which factors can NOT be a cause for bad KPI for HOSR ?
1. IMSI
2. X2 quality
3. Layer Priority
4. UL RSSI
1. RTWP
2. PRB Ulizaon
3. Intracell Handover
4. CQI
79. You are in opmizing 4G New Site, but you nd that the Packet Loss Rate is high. What will you
dorst?
80. You are opmizing 1 new site and 4G Payload suddenly increase and impact to your CSSR KPI,
whatwill you not do immediately?
81. From Drive Test Result, to check coverage of the cells, What plong will you used ?