Professional Documents
Culture Documents
Reaesrch Project Guidelines
Reaesrch Project Guidelines
Reaesrch Project Guidelines
Objective
2. As per the syllabi of B.Com(H) (Paper code B.Com-312), students of Semester VI are
required to write a project report comprising of 6 credits. The project report has two
components, viz.
(a) External : Project Viva (50 Marks), where viva on written report
would be undertaken by an external examiner.
3. It is partly responsibility of the student to find a relevant topic for his/her project. The
topic is to be decided in consultation with the guide allotted to the student. Topic once fixed
cannot be changed. The project work would be based on primary data or secondary data or both.
Each student is required to carry out the work and submit the report individually. ANY
PREVIOUS WORK OR BORROWED REPORT WILL BE SUMMARILY REJECTED
AND IN ALL CASES OF REJECTION THE WORK IS TO BE REPEATED AFRESH.
Proposal
4. The project proposal should be about one/two page long and must be submitted in writing
to the respective guide. The format of the proposal is attached as Appendix A.
1
Final Report
5. The Guidelines for methodology to be adopted for conducting the project are attached as
Appendix-B. The format for compilation of project report is attached as Appendix-C. Project
reports are to be compiled as per laid down guidelines.
Schedule
6. The schedule, various milestones and evaluation methodology is given in the table below.
The schedule is to be adhered to by all the students:
To be Completed Marks
Activity
by Date Allotted
14 April, 2023
th
Briefing about the project guidelines to the students.
Submission of Project Proposal to the respective guide &
21st April, 2023 5
finalisation of Title, Objectives, Scope & Methodology.
8th May, 2023 Chapter-1 & 2 (Introduction and Review of Literature) 5
Submission of Chapter-3 (RM) and Questionnaire (after
18th May, 2023 5
prior discussion with Project Guide)
31st May, 2023 Data Analysis & Interpretation (Chapter-4) and Chapter-5. 5
Submission of Final Report (one hard copy in spiral
5th June, 2023 5
binding) to the respective guide.
13th June, 2023 Internal Presentation and Viva to the Internal Board of
25
(Tentative) Examiners.
As per the
announcement of External Viva before the External Examiner. 50
GGSIPU
Total Marks 100
The list of faculty guides assigned to the students has been issued separately and displayed on
Notice Board
2
Appendix-A
(Refer Para 4)
PROJECT PROPOSAL
Each student is to submit a written project proposal to their respective guide. The project
proposal must comprise the following aspects:
1. Title of the Project: Title should be meaningful and should convey the broad aspects
that will be covered in the body and the scope of the project.
3. Objectives of the Study: Explain the objectives and the scope of the project along with
functional area that will be covered in the study.
4. Methodology:
5. Tools: Explain the statistical tools and software tools e.g. SPSS/MS Excel or any other
that you propose to use in the project.
3
Appendix-B
(Refer Para 5)
The methodology for carrying out the project is given in the following paragraphs. Each student
is to compile his/her study in five chapters as detailed below:
Chapter-I: Introduction
Profile Organisation/Company: Briefly explain the nature of the organisation and its business.
It should include type of industry & business in which the company is operating, its vision &
mission, geographical & functional area of operation, size of organisation & its structure,
turnover, market share & position of the company in the industry, product range, present
leadership, strengths & weaknesses, if any.
Theoretical Framework: A brief theoretical description of concepts, tools and techniques used
in project along with definition of key words and formulae etc. should be included.
A literature review is an account of what has been published on a topic by accredited scholars
and researchers. Literature review is a text written by someone to consider the critical points of
current knowledge including substantive findings, as well as theoretical and methodological
contributions to a particular topic. Often, it is part of the introduction to an essay, research report,
or thesis. In writing the literature review, the purpose is to convey the knowledge and ideas that
have been established on a topic, and what their strengths and weaknesses are. As a piece of
writing, the literature review must be defined by a guiding concept (e.g., your research objective,
the problem or issue you are discussing).
At least 5-8 research papers should be reviewed and defined in the report. A sample of review of
a research paper is given below:
Sharma (2014) says “Corporate Social Responsibility (CSR) is a form of corporate self
regulation conjoined with business model and strategies. It focuses on companies being
responsible for their actions and encourages a positive impact through its activities on the
environment, consumers, employees, communities, shareholders and stakeholders. The corporate
sector has realized that they have to think beyond profitability and start being responsible for all
who make their survival possible in the society. And this is only possible if they think wisely and
actively about CSR.
4
Chapter-III: Methodology
Objectives of Study: It should be pragmatic and consistent with the title of the study and
achievable during the course of study within the prescribed schedule. Students are advised to
develop the objectives in consultation with their respective guides. The objectives must start with
action oriented verbs. A sample of objectives is given below as example:
Scope of Study: The scope of study should clearly mention the activities that are actually
performed in the study. It should include the period of study, the functional area (HR,
Finance and Marketing) and volume of work carried out in the study. With reference to
above objectives, the scope of study could be as follows (note this is suggestive and not
exhaustive):
“(a) To throw light on the concept and development of CSR. For this purpose
secondary data from the published sources are collected.
(b) To find out how CSR initiatives are being taken by ITC and HUL Companies.
For this purpose the geographical area selected is Delhi region. Data is collected through
a questionnaire that is attached as Appendix A.”
(a) Primary Data Collection Sources: The project should be based on primary data. For
data collection, a questionnaire must be prepared and it has to be made part of the project
report. The questionnaire should be consistent with the objectives and the scope of the
study and duly vetted by the respective guide. The questionnaire should be designed in a
simple language so that the targeted population must understand and able to respond
effectively.
(b) Secondary Data Collection Sources: If in case of any secondary data, proper references of
sources of data must be compiled and mentioned against each data used in the study.
Universe/Population: The universe consists of all survey elements that qualify for inclusion in
the research study. The precise definition of the universe for a particular study is set by the
research question/objectives, which specifies who or what is of interest. The universe may be
individuals, groups of people, organizations, or even objects. For example, research about voting
in an upcoming election would have a universe comprising all voters.
The students should define the universe/population selected for conducting the study.
Sampling Unit: It is a unit from where a respondent is selected. The students should explain
(in few words) about the respondents from whom the primary data was collected.
5
Sample Size: The characteristics of whole population are difficult to study in most of the
researches. In order to best analyse the results, sample is taken from the population which best
describes the characteristics of the population. A sample is a sub group of the population selected
for the study and best describes the population.
The sample size of a survey most typically refers to the number of units/respondents that
were chosen from which data was gathered. The sample size selected for the study should be
mentioned in the report. The justification for selecting the sample size (total number of
respondents) should also be explained.
Sampling Technique: A sampling technique is the name of the technique or identification of the
specific process by which the entities/ respondents of the sample have been selected. There are
basically two type of sampling methods- probability sampling methods and non- probability
sampling methods which are further divided into different types.
The Sampling technique should be selected according to the problem under study. The
justification for selecting particular sampling technique should also be explained.
Tools Used for Data Analysis: In this part the students should explain the concepts, tools and
techniques used for data analysis. The rational and justification for using a particular tool and
technique should be explained. For example if a student uses Standard Deviation as a statistical
tool, he should explain the concept of Standard Deviation and its relevance to the study along
with its formula.
Raw data (primary or secondary) collected must be reduced to standard formats such as tables,
charts, graphs, diagrams etc and is to be presented in this chapter. The tool for data presentation
should be suitably selected so that interpretation and inferences could be drawn easily and
become self explanatory. Proper titles, legends, scales, source (s) etc must be mentioned along
with each diagram.
In this chapter, students are required to present the data in the form of tables & graphs/charts and
inferences have to be drawn through data analysis. Students should apply established theoretical
concepts, tools and techniques (discussed in Chapter-I) to the data presented and draw
inferences. Students are required to discuss rationale and logic for drawing inferences. For each
inference, proper linkages are to be established with the data analysed in this chapter. Wherever,
calculations are to be carried out, it must be provided before drawing any inference. The
inferences are to be presented in narrative form from each data set along with any limitation (s)
due to data insufficiency, if any.
(a) Findings of the Study: These are to be presented and supported by facts & figures in
narrative form and be culled out from the Chapter-IV. The sequence of the results must
be consistent with the objectives of the study mentioned in Chapter-III. Also, mention
the achievement of objectives or otherwise.
6
(b) Limitations: The limitations could be mentioned in terms of data insufficiency, time &
expertise constraints etc.
(c) Suggestions: Suggestion based on the main findings of the study should be incorporated.
(d) Conclusion: The concluding paragraph should summarize and conclude the study in
brief.
(e) Scope for further Study: Any scope for extension of the study to new geographical
areas, segments, time with larger data, is to be mentioned under this heading.
Appendix/Appendices
7
Appendix-C
(Refer Para 5)
Format
1. The final report should be written and compiled in the following the sequence:
Title Page
Certificate
Assignment Directive
4. Each student shall be issued an Assignment Directive duly signed by their project guide
and coordinator which shall form part of the dissertation.
Acknowledgements
5. In the “Acknowledgements” page, the writer recognises his indebtedness for guidance
and assistance by the faculty guide and any other member (s). Courtesy demands that he/she also
recognizes specific contributions by other persons or institutions such as libraries and research
foundations. Acknowledgements should be expressed simply, tastefully, and tactfully duly
signed above the name.
8
Executive Summary
8. The guidelines for writing the Project Report (methodology) are detailed in Appendix-B.
Following aspects must be adhered to:
(a) Page Size: Good quality white A4 size executive bond paper should be used for
typing and duplication.
(d) Page Numbers: All text pages starting from Body of the Project Report should
be numbered at the bottom center of the pages.
(i) Font Size: 12, Times New Roman, Double Spacing, Single Side Writing.
(ii) Paragraphs Heading Font Size: 12, Times New Roman.
(iii) Page/Title Font Size: 14
(g) Table and Figure Number: Table and figure numbers are to be written at the
bottom of the table/ figure as given below:
9
(h) Binding & Color Code of the Report:
Bibliography
9. Secondary sources should be duly acknowledged. When accessing online sources, care
should be taken to mention the entire link, and not merely the website, in addition to date of
access.
Appendices
10. The appendices are to be attached at the end of the report and to be numbered as
Appendix-A, Appendix-B etc. right justified at the top of the page. Below the word
Appendix write in parenthesis “Refer Para No__”. The Para number should be the number in the
body of text where the reference of appendix is given. An appendix may have annexure (s). The
annexure, if any, are to be attached immediately after the said appendix. The annexure are to be
numbered as Annexure-I, Annexure-II etc.
10
Annexure-I
on
To
Nurturing Excellence
11
Annexure-II
Certificate
(Name of the organisation or of the Institute). The matter embodied in this project work has
not been submitted earlier for the award of any degree or diploma to the best of my
Countersigned
Director/Project Coordinator
12
Annexure-III
CONTENTS
LIST OF TABLES
Table No Title Page No
1 Number of Employees in Organisation ABC
2
LIST OF FIGURES
Figure No Title Page No
1 CSR initiatives taken by companies
2
LILIST OF SYMBOLS
S No Symbol Nomenclature & Meaning
1 Sigma (Summation)
2 @ At the rate
LISLIST OF ABBREVIATIONS
13
14