Professional Documents
Culture Documents
DSP - Miscellaneous Signals
DSP - Miscellaneous Signals
23 Lectures 2 hours
Asif Hussain
More Detail
John Shea
More Detail
Juan Galvan
More Detail
There are other signals, which are a result of operation performed on them. Some common type of
signals are discussed below.
Conjugate Signals
Signals, which satisfies the condition x(t) = x ∗ (−t) are called conjugate signals.
If we compare both the derived equations 1 and 2, we can see that the real part is even, whereas
the imaginary part is odd. This is the condition for a signal to be a conjugate type.
signal
Example
Here, the real part being sin t is odd and the imaginary part being t
2
is even. So, this signal
Any function can be divided into two parts. One part being Conjugate symmetry and other part being
Where xcs(t) is conjugate symmetric signal and xcas(t) is conjugate anti symmetric signal
[x(t) + x ∗ (−t)]
xcs(t) =
2
And
[x(t) − x ∗ (−t)]
xcas(t) =
2
signal. Here, amplitude reversal and time shifting of the signal takes place by half time. For half
wave symmetric signal, average value will be zero but this is not the case when the situation is
reversed.
Consider a signal x t as shown in figure A above. The first step is to time shift the signal and
make it x[t − (
T
2
)] . So, the new signal is changed as shown in figure B. Next, we reverse the
amplitude of the signal, i.e. make it as shown in figure C. Since, this signal repeats
T
−x[t − ( )]
2
itself after half-time shifting and reversal of amplitude, it is a half wave symmetric signal.
Orthogonal Signal
Two signals x t and y t are said to be orthogonal if they satisfy the following two conditions.
∞
Condition 1 − ∫
−∞
x(t)y(t) = 0 [for non-periodic signal]
The signals, which contain odd harmonics (3rd, 5th, 7th ...etc.) and have different frequencies, are
mutually orthogonal to each other.
In trigonometric type signals, sine functions and cosine functions are also orthogonal to each other;
provided, they have same frequency and are in same phase. In the same manner DC
Directcurrentsignals and sinusoidal signals are also orthogonal to each other. If x t and y
t are two orthogonal signals and z(t) = x(t) + y(t) then the power and energy of z t can
be written as ;
Here, the signal comprises of a DC signal 3 and one sine function. So, by property this signal is
an orthogonal signal and the two sub-signals in it are mutually orthogonal to each other.