Professional Documents
Culture Documents
Ldf7811xx LG Dishwasher Repair Service Manual
Ldf7811xx LG Dishwasher Repair Service Manual
2005.5.11
9:31
AM
페이지2
001
HP
LaserJet
5000
Series
DISHWASHER
SERVICE MANUAL
NOTE
CONTENTS
1. CAUTION......................................................................................................................... 4
2. SPECIFICATIONS ........................................................................................................... 5
3. WIRING DIAGRAM........................................................................................................ 6
-3-
3828ED3001X
2005.5.11
9:31
AM
페이지4
001
HP
LaserJet
5000
Series
CAUTION !
-4-
3828ED3001X
2005.5.11
9:31
AM
페이지5
001
HP
LaserJet
5000
Series
2. SPECIFICATION
ITEM SPECIFICATION
-5-
3828ED3001X
2005.5.11
9:31
AM
페이지6
001
HP
LaserJet
5000
Series
3. WIRING DIAGRAM
-6-
3828ED3001X
2005.5.11
9:31
AM
페이지7
001
HP
LaserJet
5000
Series
Mixed
Air
to
Lower
Arm
Fine Mesh
-7-
3828ED3001X
2005.5.11
9:31
AM
페이지8
001
HP
LaserJet
5000
Series
PROGRAM
• Press the program that
corresponds to your
desired wash cycle.
INDICATOR
• Child lock: Lamp will turn on
when Child Lock setting is on.
• Rinse Aid: Refill with Rinse aid
when Lamp turns on.
This program is for very heavily soiled loads including pots, CANCEL
Soak pans and casserole dishes which may have dry food residue.
• To cancel a running
Power Scrub This program is for very heavily soiled loads program, open the door,
then press and hold the
Normal This program is for normally soiled everyday loads. Normal and Delicate
buttons for 3 seconds.
Delicate This program is for washing delicate items like glasses.
-8-
3828ED3001X
2005.5.11
9:31
AM
페이지9
001
HP
LaserJet
5000
Series
SPRAY
(INTENSITY) DELAY START POWER
• Repeated pressing of the • If you want to delay the start of • For operating, press this
Spray button will select a selected program, press the button first for power on.
Strong, Medium or Delay Start button. • After operating, the power
Soft. • Each press of Delay Start will automatically switches off
delay the start of the cycle by for safety and economy.
one hour. • In case of an unusual Power
• The delay start time can be surge or disturbance, the
adjusted from 1 to 24 hours in power may be automatically
one-hour increment. turned off for safety.
SANITARY/
CHILD LOCK EXTRA RINSE HALF LOAD
• Lock the control buttons • Repeated pressing of the • In case of a small load, use the
to prevent the settings Rinse button will select upper or lower rack only to save
from being changed. Sanitary, Extra Rinse energy.
• To lock/unlock, press or both. • Each press of the Half Load
Spray and Rinse • If you select the Sanitary button cycles between upper
buttons simultaneously function, the temperature rack only and lower rack only.
for 3 seconds with door of Heating Rinse can • If you don't press Half Load,
open. reach 161。 F (72℃). the dishwasher runs normally,
• When you select Extra i.e, operation of upper and
Rinse, an additional lower spray arm alternating
rinse cycle is added. periodically.
-9-
3828ED3001X
2005.5.11
9:31
AM
페이지10
001
HP
LaserJet
5000
Series
SPRAY
(INTENSITY)
• Repeated pressing of the
Spray button will select
Strong, Medium or
Soft.
Strong
Medium Sanitary Upper
Soft Extra Lower
Rinse
SANITARY/
CHILD LOCK EXTRA RINSE HALF LOAD
• Lock the control buttons • Repeated pressing of the • In case of a small load, use the
to prevent the settings Rinse button will select upper or lower rack only to save
from being changed. Sanitary, Extra Rinse energy.
• To lock/unlock, press or both. • Each press of the Half Load
Spray and Rinse buttons • If you select the Sanitary button cycles between upper
simultaneously for 3 function, the temperature rack only and lower rack only.
seconds. of Heating Rinse can • If you don't press Half Load,
reach 161。 F (72℃). the dishwasher runs normally,
• When you select Extra i.e, operation of upper and
Rinse, an additional lower spray arm alternating
rinse cycle is added. periodically.
- 10 -
3828ED3001X
2005.5.11
9:31
AM
페이지11
001
HP
LaserJet
5000
Series
PROCESSING
INDICATOR INDICATOR TIME LEFT
• Child lock: Lamp will turn • Current program • Before starting, the display window shows
on when Child Lock phase is indicated. the running time of the selected program.
setting is on. • After starting, the display window shows
• Rinse Aid: Refill with the remaining time.
Rinse aid when Lamp turns • If the dishwasher has a trouble, the trouble
on. type is displayed.
Delay Start
- 11 -
3828ED3001X
2005.5.11
9:31
AM
페이지12
001
HP
LaserJet
5000
Series
� Normal Water Level : 315 Supply water before operating the Test Mode.
� Pure Water : more than 229
- 12 -
3828ED3001X
2005.5.11
9:31
AM
페이지13
001
HP
LaserJet
5000
Series
5. PARTS NAME
5-1. LDF 7811/7810 Series
※ The appearance and specifications may be varied without notice according to localities.
- 13 -
3828ED3001X
2005.5.11
9:31
AM
페이지14
001
HP
LaserJet
5000
Series
※ The appearance and specifications may be varied without notice according to localities.
- 14 -
3828ED3001X
2005.5.11
9:31
AM
페이지15
001
HP
LaserJet
5000
Series
Rinse Only
Quick
Fine China
NORMAL
Power Scrub
Soak
Program
Drain
Pre Wash 1
Drain A
Stop
Water Supply
10
10
18
49
26
Wash
Stop
Drain
Wash
Drain
Pre Wash 2
Drain B
Wash
Drain
Water Supply
Drain
Water Supply
10
10
10
10
Wash
6 Stop
Drain
Wash
Wash
Drain
Drain B
Pre Wash 3
Wash
Drain
Water Supply
1
Drain
Water Supply
10
10
10
Wash
Stop
Drain
Wash
Drain
Program chart
Main Wash
Drain B
Wash
Drain
Water Supply
Drain
Water Supply
46
49
22
60
30
63
38
65
46
Wash
8
Stop
Drain
Wash
Drain
Drain B
Wash
Rinse 1
Drain
Water Supply
Drain
Water Supply
10
10
10
10
10
Rinse
6
Stop
30 8 30 3 30
Drain
Wash
Drain C
Drain
Rinse
Rinse 2
Water Supply
Drain
Water Supply
10
10
Rinse
Stop
Drain
Wash
Drain C
Heating Rinse
Drain
Water Supply
Drain
Water Supply
60
20
68
26
65
20
68
26
72
30
Heating A
Heating B
Stop
Drain
Stop
Drain D
Dry
Dry
Drain
20
30
30
30
30
Dry
Drain
- 15 -
3828ED3001X
2005.5.11
9:31
AM
페이지16
001
HP
LaserJet
5000
Series
7. HOW TO DISASSEMBLE
BEFORE DISASSEMBLING THE DISHWASHER ;
1) Remove the cord from electric outlet to avoid electric shock.
2) Close the Water Tap (faucet).
3) Remove all dishes and items in the dishwasher.
4) Remove the Lower Rack and the Upper Rack.
5) Remove the inlet hose and drain hose connetion to avoid the hose damages.
6) Prepare some towels to avoid floor wet by the water left in the dishwasher.
Lower Cover
Tub Felt
2. Cabinet and Tub Felt
1) Cabinet-R
Remove front 2 screws.
Remove rear 3 screws.
2) Cabinet-L
Remove front 2 screws.
Remove rear 3 screws.
3) Tub Felt
Cabinet-L
Cabinet-R
- 16 -
3828ED3001X
2005.5.11
9:31
AM
페이지17
001
HP
LaserJet
5000
Series
Controller
Front Display
- 17 -
3828ED3001X
2005.5.11
9:31
AM
페이지18
001
HP
LaserJet
5000
Series
Controller
- 18 -
3828ED3001X
2005.5.11
9:31
AM
페이지19
001
HP
LaserJet
5000
Series
3) Fan Assembly
Gasket Inner Cover Open the door.
Detergent Remove 4 screws and a earth screw for
Dispenser Door Bracket.
Fan Assembly
Remove the wire connetions.
Remove the Air Duct.
Turn the Inner Cover counterclockwise.
Flange
4) Detergent Dispenser
Air Duct
Close the door
Remove the wire connections.
Remove 6 screws with brackets.
Door Bracket Door Hinge
Push the Detergent slowly pulling up the
the Flange by Standard Screwdriver.
6) Door Liner
Open the door.
Pull the Door Liner and take it off from
the Hinge Supporter.
Hinge Supporter
- 19 -
3828ED3001X
2005.5.11
9:31
AM
페이지20
001
HP
LaserJet
5000
Series
4. Lower Frame
1) Press the holder hook as shown in figure.
2) Remove 4 screws.
Lower Frame
Lead Wire Holer
Drain Hose
Holder
Drain Hose
- 20 -
3828ED3001X
2005.5.11
9:31
AM
페이지21
001
HP
LaserJet
5000
Series
7. Base Cover
Cabinet Base
Base Cover 1) Remove 2 screws.
2) Pull the Base Cover out.
- 21 -
3828ED3001X
2005.5.11
9:31
AM
페이지22
001
HP
LaserJet
5000
Series
9. Cabinet Base
Cabinet Base 1) Remove 8 screws.
2) Lift it upward.
Gasket
Air Braker
Nut
Air Braker
Assembly
- 22 -
3828ED3001X
2005.5.11
9:31
AM
페이지23
001
HP
LaserJet
5000
Series
Hook
Sump
Assembly
Heater
Micro S/W
- 23 -
3828ED3001X
2005.5.11
9:31
AM
페이지24
001
HP
LaserJet
5000
Series
- 24 -
3828ED3001X
2005.5.11
9:31
AM
페이지25
001
HP
LaserJet
5000
Series
INLET ERROR The Water Supply Tap is closed. Take action on Water Supply
The Water Supply is shut off. device.
The Inlet Hose is kinked.
The Water Pressure is very low.
(below 10 psi)
displayed Inlet Valve is OK? Measure the electric resistance of
The filter of Inlet Valve is clogged Inlet Valve. (950-1300 )
Condition by impure water. Clean the filter of Inlet Valve.
Not reached to the nor- The Hall sensor is OK? Check the frequency of Inlet Water
mal water level in spite The Impeller of Air Guide is bound. by the Test Mode.
of 10 min. water supply Replace the Air Braker.
DRAIN ERROR The Drain Hose kinked or blocked. Remove the cause of kink or block.
Wiring connection is OK? Check the wiring connection.
The drain outlet of sump is Measure the electric resistance of
blocked. Drain Motor. (20-40 )
displayed The Drain Pump/Motor or circuit is Replace the Drain Motor or repair
troubled. the Circuit.
Condition
Not fully drained out in
spite of 5 min. drain
operation
LEAKAGE ERROR Water leakage in Hose connections. Replace the connections of Hose.
Water is leaked by damages. Check the point of damages and
The Motor Water Seal leakage of repair or replace the related parts.
Sump assembly. Read the Installation Instructions
displayed The height of Drain Hose connection (page 9) and fix it to the
(sink-Drain Hose) is not over 20″. recommended Height.
Condition Replace the Impeller of the
Impeller of the Washing Pump is
The excessive RPM of worn away. Washing Pump.
Washing Motor
happened during Wash
cycle due to water
leakage.
- 25 -
3828ED3001X
2005.5.11
9:31
AM
페이지26
001
HP
LaserJet
5000
Series
EXCESS ERROR
The Inlet Valve is troubled. Replace the Inlet Valve.
The Controller is troubled. Repair or replace the Controller.
displayed
Condition
Excessive water is sup-
plied than normal water
level.(Automatically drain
Pump operated.)
THERMAL ERROR
The Inlet Water Temperature is Check the temperature. (Test Mode)
very high. (over 194 ) If the temperature is displayed,
Wiring connection is OK? adjust the Inlet Water
displayed
The Thermistor is OK? Temperature to 120 .
Condition If the temperature is not
The resistance of ther-
mistor not normally out put. displayed,
check the wiring connection.
check the electric resistance
of Thermistor.
(11~14k at 77 )
Replace the PCB.
MOTOR ERROR
Wiring connection is OK? Check the wiring connection.
The Impeller of Washing Pump is Replace the cause of restriction.
locked. Replace the Washing Motor.
displayed
The rotor of Washing Motor is Replace the PCB.
Condition locked.
The Motor is working The Blade is locked.
abnormally.
- 26 -
3828ED3001X
2005.5.11
9:31
AM
페이지27
001
HP
LaserJet
5000
Series
YES
The Fuse or NO
Circuit Breaker • Replace the Fuse or Circuit Breaker of house.
of house is O.K?
YES
YES
C h e c k t h e C o n t r o l l e r. ( P o w e r C i r c u i t )
- 27 -
3828ED3001X
2005.5.11
9:31
AM
페이지28
001
HP
LaserJet
5000
Series
YES
YES
YES
- 28 -
3828ED3001X
2005.5.11
9:31
AM
페이지29
001
HP
LaserJet
5000
Series
YES
After washing, are there still
White deposits or streaks on Reduce the amount of Rinse-Aid
the dishes? (for Streak)
NO
YES
- 29 -
3828ED3001X
2005.5.11
9:31
AM
페이지30
001
HP
LaserJet
5000
Series
- 30 -
3828ED3001X
2005.5.11
9:31
AM
페이지31
001
HP
LaserJet
5000
Series
9. INSTALLATION INSTRUCTION
■ Ensure the floor under the dishwasher is at the same level as the rest of the room to
allow for any service requirements.
- 31 -
3828ED3001X
2005.5.11
9:31
AM
페이지32
001
HP
LaserJet
5000
Series
WARNING!
For personal safety, remove house fuse or open circuit breaker before
installation. Do not use an extension cord or adapter plug with this dishwasher.
Electrical and grounding connections must comply with the national electrical
code/provincial and municipal code and/or other local codes.
1. This appliance must be operated with correct voltage as shown in this manual and on the
rating plate, and connected to an individual, properly grounded branch circuit, protected
by time delay fuse. Wiring must be 3 wires including ground.
2. The wiring or cord should be in an accessible location adjacent to, and not behind the
dishwasher and within 4 ft. (1.2m) of the dishwasher side.
3. The wiring or cord must be grounded properly, if in doubt, have it checked by a qualified
electrician. No other appliance shall be connected to the same outlet by a double adapter
or similar plug.
4. The wiring or cord must be oriented as shown in Figure A below.
5. Check the dishwasher for any damage before trying to install it.
6. Make sure water line and Electrical line are oriented in the bottom channels as shown in
the figure below.
If you find any damage to the dishwasher, Please contact your dealer or builder
immediately.
Electrical Cable
Figure A
Water Supply
Tube
- 32 -
3828ED3001X
2005.5.11
9:31
AM
페이지33
001
HP
LaserJet
5000
Series
1. This dishwasher may be connected to either hot or cold water. If the water can not be
℉ (65℃), the dishwasher must be connected to cold water.
maintained below 149℉
2. When connecting the dishwasher water line, sealing tape or compound should be used to
avoid leaks.
3. When connecting the dishwasher water line, the house supply should be shut off.
4. The Water Supply Tube must be oriented as shown in Figure A on page 6.
1. Adjust the legs to the required height to fit properly under the countertop as shown below.
2. Check the level of dishwasher by using level.
Leveling foot
- 33 -
3828ED3001X
2005.5.11
9:31
AM
페이지34
001
HP
LaserJet
5000
Series
Lower Cover
Electrical Cable
Drain Hose
- 34 -
3828ED3001X
2005.5.11
9:31
AM
페이지35
001
HP
LaserJet
5000
Series
1. If the end of the drain hose does not fit to the drain line, use an adapter (not supplied) that
must be resistant to heat and detergent and may be obtained from a plumbing shop.
2. There are 2 typical connections as shown in Figures C & D.
① There may be other options than shown here for connection the drain hose. The drain
connection must meet local plumbing regulations.
② The S trap spigot must be drilled out cleanly and free of obstruction to its maximum
internal diameter, if used for drainage.
③ To prevent syphoning, one of the following instruction methods must be followed:
Dishwasher
Sink 1/2″ 3/4″ 1″
(13mm) (19mm) (25mm)
Drain Hose
In case Figure C
Min. 20″(508mm)
Min. 30″(770mm)
Max. 40″(1000mm) Drain Requirements
Min. 20″(508mm)
Min. 30″(770mm)
Max. 40″(1000mm)
- 35 -
3828ED3001X
2005.5.11
9:32
AM
페이지36
001
HP
LaserJet
5000
Series
- 36 -
3828ED3001X
2005.5.11
9:32
AM
페이지37
001
HP
LaserJet
5000
Series
- 37 -
3828ED3001X
2005.5.11
9:32
AM
페이지38
001
HP
LaserJet
5000
Series
LDF7810 Series
LDF7811 Series
LDS5811 Series
ACCESSORIES
- 38 -
3828ED3001X
2005.5.11
9:32
AM
페이지39
001
HP
LaserJet
5000
Series
EXPLODED VIEW
- 39 -
3828ED3001X
2005.5.11
9:32
AM
페이지40
001
HP
LaserJet
5000
Series
M086
F040
F060
F045
F050
F022
M090
F011 F171
F014
F013 F117
F144
F132
F110
F143
M005 F117
M006
F011
F210
- 40 -
3828ED3001X
2005.5.11
9:32
AM
페이지41
001
HP
LaserJet
5000
Series
A150
F192
A158
A156 F004
A159 A080
F005
A070
A155
A101 A060
A158
A102 A151 A073
A103 A157
A074
A140 A144 A149
A147
A147
A050 F191
A148
A142
A141
A110
- 41 -
3828ED3001X
2005.5.11
9:32
AM
페이지42
001
HP
LaserJet
5000
Series
K201 K215
K207
K216
K253
K209
K260
K252
K203
K208
K251
K254
K230 K252
K208
K260
K262
K251
K212
K203
K216
- 42 -
3828ED3001X
2005.5.11
9:32
AM
페이지43
001
HP
LaserJet
5000
Series
K230
K006
K002
K005
K010
F174
K124
F142
K141
K010
A120
- 43 -
3828ED3001X
2005.5.11
9:32
AM
페이지44
001
HP
LaserJet
5000
Series
M038
M037
- 44 -
3828ED3001X
2005.5.11
9:32
AM
페이지45
001
HP
LaserJet
5000
Series
- 45 -
3828ED3001X
2005.5.11
9:32
AM
페이지46
001
HP
LaserJet
5000
Series
- 46 -
3828ED3001X
2005.5.11
9:32
AM
페이지47
001
HP
LaserJet
5000
Series
- 47 -
3828ED3001X
2005.5.11
9:32
AM
페이지48
001
HP
LaserJet
5000
Series
- 48 -
3828ED3001X
2005.5.11
9:32
AM
페이지49
001
HP
LaserJet
5000
Series
- 49 -
3828ED3001X
2005.5.11
9:32
AM
페이지50
001
HP
LaserJet
5000
Series
- 50 -
3828ED3001X
2005.5.11
9:32
AM
페이지51
001
HP
LaserJet
5000
Series
- 51 -
3828ED3001X
2005.5.11
9:32
AM
페이지52
001
HP
LaserJet
5000
Series
- 52 -
3828ED3001X
2005.5.11
9:32
AM
페이지53
001
HP
LaserJet
5000
Series
- 53 -
3828ED3001X
2005.5.11
9:32
AM
페이지54
001
HP
LaserJet
5000
Series
- 54 -
3828ED3001X
2005.5.11
9:32
AM
페이지55
001
HP
LaserJet
5000
Series
- 55 -
3828ED3001X
2005.5.11
9:31
AM
페이지1
001
HP
LaserJet
5000
Series
P/No. : 3828ED3001X