Professional Documents
Culture Documents
Magnetic Screen
Magnetic Screen
Hot oil and hot components can cause personal injury. Do not
allow hot oil or hot components to contact the skin.
NOTICE
Care must be taken to ensure that fluids are contained during
performance of inspection, maintenance, testing, adjusting, and
repair of the product. Be prepared to collect the fluid with
suitable containers before opening any compartment or
disassembling any component containing fluids.
Illustration 1 g03448357
(1) Drain plug
1. Remove drain plug (1) from the bottom rear of the transmission. Allow the oil to drain into a suitable container.
2. After the oil has drained from the transmission case, clean the drain plug and install the drain plug. Torque the drain plug to 35 ± 10 N·m
(26 ± 7 lb ft).
Illustration 2 g03448557
5. Inspect suction screen (3) and magnetic filter (4) for large particles of debris. An excessive amount of debris may be an indication of possible
failure. Discolored oil or oil with an odor requires a careful analysis of S·O·S results. If large particles are found, consult your Caterpillar dealer
for further analysis and additional guidance.
NOTICE
Do not drop or rap the magnets against any hard objects. The
magnets are brittle. Replace broken magnets or damaged
screens.
6. Wash the suction screen and the magnetic filter in clean, nonflammable solvent. Clean the magnets with a cloth or a stiff bristle brush.
7. Install the magnetic filter, the screen, and the access plate. Tighten the access plate to 28 ± 7 N·m (21 ± 5 lb ft).
Illustration 4 g03448583
(5) Filler tube
8. Fill the transmission to the full mark on the dipstick at filler tube (5) with the recommended oil and volumes. Refer to Operation and
Maintenance Manual, "Capacities (Refill)" for the appropriate oil volumes.
9. The vehicle must be on level ground and the transmission must be in neutral. Start the engine and operate at LOW IDLE. Check the oil filter
and the suction screen for leaks.
10. Observe the oil level when the oil is warm and the transmission is in the NEUTRAL position. Make sure that the parking brake is engaged.
PIP-10604153
2021/10/23
00:13:30+07:00
i05458913
© 2021 Caterpillar Inc.
Caterpillar:
Confidential Green