Professional Documents
Culture Documents
Set C Practical Problems Refresher
Set C Practical Problems Refresher
: ________
MASTER PLUMBING
Wednesday, May 18, 2022 06:00 p.m. – 10:00 p.m.
-------------------------------------------------------------------------
PRACTICAL PROBLEMS & EXPERIENCES SET C
INSTRUCTION: Select the correct answer for each of the following questions.
Mark only one answer for each item by shading the box corresponding to the
letter of your choice on the answer sheet provided. STRICTLY NO ERASURES
ALLOWED.
MULTIPLE CHOICE
Page 1 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 2
10. A wall-hung lavatory can rely on in-wall support using wood backing
or
a. A manufactured carrier
b. Long drywall screws
c. Adhesive caulking
d. A closet carrier
11. The rims of bowls used for handicap toilets and nonhandicap toilets
a. Are the same height from the floor
b. Are installed at different distances from a back wall
c. Connect differently to the drain
d. Are not the same from the floor
Page 2 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 3
15. A floor mounted toilet seals with the drainage system using closet
bolts and a
a. Tube of caulking
b. Tub of putty
c. Wax seal
d. None of the above
16. The two most common drain assembly are a pop-up and a
a. Pop-out
b. Grid strainer
c. Basket strainer
d. None of the above
17. The two fixtures that are installed in a separate room but on the
same wall are considered
a. Back-to-back
b. Side-by-side
c. Back-to-front
d. Front-to-back
Page 3 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 4
19. A fixture carrier and wood backing for fixtures are installed
a. During the rough-in phase of construction
b. During the trim (finish) phase of construction
c. By the fixture manufacturer
d. By the general contractor
21. A handheld shower hose that could be submerged in bath water must
a. Be no longer than 36”
b. Always have a backflow prevention device installed
c. Never have a backflow prevention device installed
d. Always be at least 5’ in length
22. The vertical distance from a faucet spout outlet to the flood level
rim of a fixture is called
a. Flow space
b. Aerator distance
c. Backflow gap
d. Air gap
Page 4 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 5
b. Pop-up
c. Waste and overflow
d. None of the above
28. A kitchen sink drain assembly connects with the p-trap or tubular
extension tailpiece
a. Threaded tailpiece
b. Flanged tailpiece
c. Rubber hose
d. None of the above
29. The point at which water would overflow onto the floor from a fixture
is known as the
a. Overflow height
b. Critical level
c. Flood-level rim
d. None of the above
Page 5 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 6
33. The spout of a lavatory faucet with a P.O. assembly is also the
housing for
a. A lift rod that connects to the plunger rod
b. Many types of soap dispensers
c. A backflow prevention device
d. None of the above
34. Handicap installations require that metallic pipe that could become
hot from water flow be
a. Replaced with plastic piping
b. Protected (covered)
c. Labeled to warn the user of hot water
d. None of the above
35. A lavatory with pop-up drain assembly connects to the drain using a
a. 1 ½” flanged tailpiece
b. 1 ¼” flanged tailpiece
c. 1 ½” threaded tailpiece
d. None of the above
Page 6 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 7
39. Urinals and commercial toilets that do not use a tank receive water
supply from
a. An angle stop
b. A straight stop
c. A dual stop
d. A flush valve (flushometer)
Page 7 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 8
46. Laundry sinks are available that install into a countertop, onto a
wall, and
a. Floor-mounted with legs
b. Both are always fiber glass
c. Have a very shallow bowls
d. None of the above
48. A slip joint style p-trap connects to the drainage system using a
a. Coupling
b. Trap adapter
c. Male and female adapter
d. None of the above
Page 8 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 9
c. 1”
d. 1 ¼”
Page 9 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 10
a. A cistern is used
b. The roof gutters are piped to a well
c. A special plumbing permit is required
d. None of the above
61. Connecting a city water supply system with piping from a private well
is
a. Common for irrigation systems
b. Known as a cross connection
c. Illegal
d. Both b and c
63. A water service pipe must be installed per local codes, but always
a. Below the frost level
b. Using galvanized steel pipe
c. Below a sewer when in the same trench
Page 10 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 11
66. Most codes dictate that a fixture cannot be supplied with more than
a. 100 pounds of pressure
b. 90 pounds of pressure
c. 80 pounds of pressure
d. None of the above
Page 11 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 12
76. Copper pipe must be supported with hangers that are copper plated or
Page 12 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 13
a. Rubber coated
b. Black steel
c. Galvanized steel
d. All of the above
77. One btu increase the water temperature of _________ by one degree
Fahrenheit.
a. One gallon
b. One pound
c. One quart
d. One bounce
81. A gravity septic tank system utilizes a septic tank, drain field,
perforated pipes, and
a. A distribution box known as D-box
b. Washed stone installed around perforated pipe
c. Both a and b
d. None of the above
Page 13 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 14
86. The center of a drain that serves a 12” rough toilet installed along
a wall with ½” drywall
a. Is roughed in at 12” from the wall stud
b. Is rare and only used in a commercial project
c. Is roughed in at 12 ½” from the wall stud
d. None of the above
Page 14 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 15
92. The two most common types of cleanout plugs have either raised area
(lug) or a
a. Plastic knockout area
b. Countersunk area
c. Series of screws
d. None of the above
94. The smallest diameter pipe that can be installed in a DWV system is
a. 2”
b. 1 ½”
c. 1”
d. None of the above
Page 15 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 16
96. The primary sizing method for an individual vent allows the pipe to
be half the diameter of the
a. Stack vent
b. Vent stack
c. Wet vent
d. None of the above
97. When two individual vents connect, and each serves a drain that
discharge into the same horizontal branch, they create a
a. Vent stack
b. Stack vent
c. Branch vent
d. None of the above
98. Sizing a waste stack must, at least, include the dfu load of each
branch interval and
a. The number of water closets that discharge into the stack
b. The minimum size of the stack vent
c. The dfu load of the building sewer
d. All of the above
Page 16 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 17
PRACTICAL PROBLEMS
ANSWER SHEET
https://marcusaustria.com/plumbing
Page 17 of 18
MCVA Plumbing Review Center
MASTER PLUMBER COACH
plumbing exam made easy
MASTER PLUMBING
Wednesday, May 18, 2022 6:00 p.m. – 10:00 p.m. Page 18
Page 18 of 18