Professional Documents
Culture Documents
DCC 2600
DCC 2600
Safeguards 18. D
o not clean carafe or heating plate
with cleansers, steel wool pads, or other
When using electrical appliances, basic safety abrasive materials.
precautions should always be followed to
19. WARNING: TO REDUCE THE
reduce the risk of fire, electric shock and/or
RISK OF FIRE OR ELECTRIC SHOCK, DO
injury to persons, including the following:
NOT REMOVE THE BASE PANEL. NO
1. READ ALL INSTRUCTIONS. USER SERVICEABLE PARTS ARE
INSIDE. REPAIR SHOULD BE DONE
2. D
o not touch hot surfaces. Use handles
ONLY BY AUTHORIZED PERSONNEL.
and knobs.
20. D
o not place cloth or otherwise restrict
3. T
o protect against electric shock, do not
airflow beneath coffeemaker.
place cord, plug, or base unit in water or
other liquids. se only the Cuisinart® Gold Tone
21. U
Commercial Style Filter or standard
4. T
his appliance should not be used by or
basket paper filter with this unit.
near children or individuals with certain
OTHER GOLD TONE PERMANENT
disabilities.
FILTERS MAY CAUSE THE
5. A
lways unplug from outlet when not in use COFFEEMAKER TO OVERFLOW.
and before cleaning. Allow to cool before
putting on or taking off parts and before
cleaning the appliance. SAVE THESE
6. D
o not operate any appliance with a
damaged cord or plug or after the
INSTRUCTIONS
appliance malfunctions or has been
dropped or damaged in any manner.
Return appliance to the nearest Cuisinart
Repair Center for examination, repair,
and electrical or mechanical adjustment. FOR HOUSEHOLD
7. T
he use of accessory attachments
not recommended by Cuisinart may
cause injuries.
USE ONLY
8. Do not use outdoors.
9. D
o not let cord hang over edge of table or
counter, or touch hot surface.
10. D
o not place on or near a hot gas or
electric burner, or in a heated oven.
11. A
lways fill water reservoir first, then plug
cord into the wall outlet. To disconnect,
push the Off button, then remove plug from
wall outlet.
12. D
o not use appliance for other than
intended use.
13. S
nap lid securely onto carafe before
serving any beverages.
14. S
calding may occur if the lid is removed
during the brewing cycle.
15. T
he glass carafe is designed for use with
these appliances only. It must never be
used on the range top.
16. D
o not set a hot carafe on a wet or
cold surface.
WARNING: RISK Of FIRE NOTICE
OR ELECTRIC SHOCK This appliance has a polarized plug (one
blade is wider than the other). To reduce
The lightning flash with arrowhead
the risk of electric shock, this plug will fit
symbol within an equilateral
into a polarized outlet only one way. If the
triangle is intended to alert the
plug does not fit fully into the outlet, reverse
user to the presence of uninsulated
the plug. If it still does not fit, contact a
dangerous voltage within the
qualified electrician. Do not modify the
product’s enclosure that may be
plug in any way.
of sufficient magnitude to
constitute a risk of fire or electric
shock to persons.
OPERATING NOTICE
Clogging and backing up of water and/or
The exclamation point within an
coffee in the filter basket can occur under
equilateral triangle is intended to
any or a combination of any of the following
alert the user to the presence of
conditions: The use of too finely ground
important operating and
coffee, using two or more paper filters,
maintenance (servicing)
using the gold tone filter in conjunction with
instructions in the literature
a paper filter or not properly cleaning coffee
accompanying the appliance.
grounds from the gold tone filter, or allowing
coffee grounds to spill over the filter.
SPECIAL CORD SET
Caution: Never open the filter basket during
INSTRUCTIONS the brewing cycle, even if no water is
A short power-supply cord is provided to draining from the filter basket, since
reduce the risks resulting from becoming extremely hot water/coffee can spill out
entangled in or tripping over a longer cord. from the filter basket and cause injury. If
Longer extension cords are available and water/coffee is not draining from the filter
may be used if care is exercised in their basket during the brewing cycle, unplug the
use. unit and wait 10 minutes before opening
If a long extension cord is used, the marked and checking the filter basket.
electrical rating of the extension cord must
be at least as great as the electrical rating
of the appliance, and the longer cord
should be arranged so that it will not drape
over the countertop or tabletop where it can
be pulled on by children or tripped over.
WARNING
RISK OF FIRE OR ELECTRIC SHOCK
DO NOT OPEN
CONTENTS
THE QUEST
Important Safeguards . . . . . . . . . . . . . . . . . . . 2
FOR THE PERFECT
Important Unpacking Instructions . . . . . . . . . . 4 CUP OF COFFEE
The Quest for the Perfect Cup of Coffee . . . . 4 Element 1: Water
Features and Benefits . . . . . . . . . . . . . . . . . . . 5 Coffee is 98% water. The quality of that
water is as important as the quality of
Control Panel . . . . . . . . . . . . . . . . . . . . . . . . . . 6 your coffee. If water doesn’t taste good
from the tap, it won’t taste good in your
Programming Your Coffeemaker . . . . . . . . . . . 7
coffee. Cuisinart includes a charcoal
Before Brewing your First Pot . . . . . . . . . . . . . 7 water filter to remove chlorine, bad
tastes and odors, for the purest coffee
Charcoal Water Filter . . . . . . . . . . . . . . . . . . . . 8 flavor, every time you brew.
FEATURES AND BENEFITS
9. Carafe
1. Reservoir Cover The easy-pour, no-drip 14-cup carafe has
Flips back for easy filling. an ergonomic handle and brewed coffee
2. Water Reservoir with Water Level markings for two to fourteen cups.
Indicator Window 10. Adjustable Heater Plate
3. Showerhead Allows you to keep brewed coffee at
Distributes water evenly over coffee, desired temperature. Scratch-resistant with
reducing temperature loss as water black, nonstick coating.
passes through grounds. 11. Ready Tone
4. Charcoal Water Filter Signals the end of the brew cycle
Charcoal water filter eliminates chlorine, with five beeps.
calcium and bad tastes and odors from tap 12. Cord Storage
water.
13. Power Loss Back-up System
5. Filter Basket One-minute protection in case a breaker
Holds a #4 paper filter or a permanent filter. trips, the unit is unplugged, or the power
6. Filter Basket Holder fails. It holds all programmed informa-
tion, including time of day, auto on time
7. Control Panel
and auto off time.
See detailed illustration, page 6.
14. Measuring Scoop
8. Brew Pause
Stops flow of coffee from basket when
carafe is removed from the heater plate, so
a cup can be poured in mid-brew.
10
Getting to know your Control Panel
Detailed programming and use instructions are on pages 7 and 8.
PROGRAMMING YOUR BEFORE BREWING YOUR
COFFEEMAKER FIRST POT OF COFFEE
Setting the Clock During the manufacturing process, dust
When the coffeemaker is plugged in, can get trapped in your coffeemaker. We
12:00 will appear until you set the time. recommend flushing out the system
before brewing your first pot of coffee.
urn the Function Knob to CLOCK
T Simply fill the reservoir and power on the
Hold down the Hour or Minute button until unit. (See steps #2 and #6 in MAKING
the clock begins flashing. Press either COFFEE instructions, below). DO NOT
button to select the desired time. Hold ADD COFFEE!
buttons down to scroll through the digits, or Once you’ve done that, brew a pot of real
press and release to advance one digit at a coffee and get ready to enjoy Cuisinart at
time. When scrolling, the numbers will its best!
advance slowly and then speed up. When
the number displayed approaches the
desired time, press and release to advance MAKING COFFEE
one digit at a time. Be sure the PM Follow instructions in “Before Brewing
indicator is on if a PM time is desired. Your First Pot of Coffee” above.
2. T
urn the Function knob to AUTO ON 3. Set preferences
LCD will display the current time. a. Push the 1-4 cup button if you are
brewing fewer than 5 cups.
3. Press and release ON/OFF button b. Press Regular or Bold button to select
A green light indicates that coffeemaker flavor strength.*
is in AUTO ON mode. A red light will
come on when brew cycle begins. Both c. Turn the Carafe Temperature dial to
lights will go off when Keep Warm cycle low(L), medium(M), or high(H) and heater
ends. plate will keep coffee at the temperature
you select.*
N
OTE: To start brew time at the same *Features will remain at selected settings
time the next day, simply make sure the until you change them.
Function Knob is on AUTO ON and press
and release ON/OFF button once more. 4. Add the ground coffee
Green AUTO ON light will go on. Remove the filter basket by grasping the
handle and lifting straight up, and then
SETTING THE AUTO OFF TIME place it on the countertop. Insert a #4
paper filter or permanent filter. Be sure
T
urn the Function Knob to AUTO OFF that the paper filter is completely open
Follow directions under SETTING THE and fully inserted in the basket. It may
CLOCK (above) to program your help to fold and flatten the seams of a
coffeemaker to shut off from 0 to 4 hours paper filter beforehand. Add 1 level
after brew cycle is finished. scoop of ground coffee per cup. Adjust
the amount according to taste.
NOTE: The maximum capacity for
ground coffee is 17 tablespoons for
this coffeemaker. Exceeding this amount CHARCOAL WATER FILTER
may cause overflow if the coffee is too Your coffeemaker comes with a
finely ground. charcoal water filter that eliminates
chlorine, bad tastes and odors from
Replace the filter basket in the filter bas- tap water.
ket holder and press firmly on cover to
be sure it closes securely. Inserting the Water Filter
5. Before brewing coffee • Remove the filter from polybag and
Make sure the glass carafe is in soak it, fully immersed, in cold tap
position on the heating plate and the water for 15 minutes.
top cover is closed. Plug the cord • Lift the water filter holder out of the
into an electrical outlet. water reservoir (see diagram, page 5).
CLEANING AND flavor of your coffee. To clean, fill the water
reservoir to capacity with a mixture of ¹⁄³
MAINTENANCE white vinegar and ²⁄³ water. Press the Clean
Always turn coffeemaker off and remove button. When the self clean light glows, turn
the plug from the electrical outlet before the coffeemaker on by pressing the on/off
cleaning. button. The Clean light will shine steadily.
Lift up the reservoir cover. Remove and The coffeemaker is now in clean mode. One
discard the paper filter and ground coffee. cycle should be sufficient to adequately
The filter basket can be washed in warm, clean the coffeemaker. When the cycle is
soapy water and rinsed thoroughly, or completed and the five beeps sound, the
cleaned in the upper rack of the dishwasher. coffeemaker will shut off. Turn the
Dry all parts after use. coffeemaker on to see if the Clean light
continues to flash. If it does, turn it off and
Do not put any water in the unit
then repeat the cleaning procedure with a
once the filter basket has been removed.
fresh solution of vinegar and water.
Wipe the area under the filter basket
with a damp cloth. If the Clean light no longer flashes, turn the
coffeemaker off and then run one cycle of
Remove the carafe from the heating plate.
fresh cold water through the unit before
Discard any remaining coffee. The carafe
using the unit again to brew coffee.
and lid can be washed in warm, soapy water
and rinsed thoroughly, or placed in a Notes on the Clean Function
dishwasher. The carafe and carafe lid should Pressing the Clean button cancels all other
be placed on the upper rack only. settings. If it is pressed accidentally, press it
again to return the coffeemaker to all its
Do not use any scouring agents or harsh
previous settings. Pressing On/Off will also
cleansers on any part of the coffeemaker.
exit the clean mode and turn the
Never immerse base unit in water or other coffeemaker off.
liquid. To clean base, simply wipe with a
clean, damp cloth and dry before storing.
Fingerprints and other blemishes on the
housing can be washed off with soap and
water or a nonabrasive cleaning solution.
Wipe heating plate with a clean, damp cloth.
Never use rough, abrasive materials or
cleansers to clean the resting plate. Do not
dry the inside of the water reservoir with a
cloth, as lint may remain.
Decalcification
Decalcification refers to the removal of
calcium deposits which form over time on
the metal parts of the coffeemaker.
For best performance from your Brew
Central® Coffeemaker, decalcify the base unit
from time to time. The frequency depends
upon the hardness of your tap water and
how often you use the coffeemaker. The
flashing Clean light will indicate when you
should clean your coffeemaker.
If the Clean light begins to flash when the
coffeemaker is turned on, it is telling you that
the calcium buildup is interfering with the
functioning of your coffeemaker and the
WARRANTY This warranty expressly excludes any defects or
damages caused by accessories, replacement
parts, or repair service other than those that have
LIMITED THREE-YEAR been authorized by Cuisinart.
WARRANTY This warranty does not cover any damage caused
This warranty is available to consumers only. by accident, misuse, shipment or other ordinary
You are a consumer if you own a Cuisinart® Brew household use.
Central 14-Cup Programmable Coffeemaker that This warranty excludes all incidental or
was purchased at retail for personal, family or consequential damages. Some states do not allow
household use. Except as otherwise required under the exclusion or limitation of these damages, so
applicable law, this warranty is not available to they may not apply to you.
retailers or other commercial purchasers or owners.
CALIFORNIA RESIDENTS ONLY:
We warrant that your Cuisinart® Brew Central 14-
Cup Programmable Coffeemaker will be free of California law provides that for In-Warranty Service,
defects in materials and workmanship under California residents have the option of returning a
normal home use for 3 years from the date of nonconforming product (A) to the store where it
original purchase. was purchased or (B) to another retail store which
sells Cuisinart products of the same type.
We suggest you complete and return the enclosed
product registration card promptly to facilitate The retail store shall then, at its discretion, either
verification of the date of original purchase. repair the product, refer the consumer to an
However, return of the product registration card independent repair facility, replace the product, or
does not eliminate the need for the consumer to refund the purchase price less the amount directly
maintain the original proof of purchase in order to attributable to the consumer’s prior usage of the
obtain the warranty benefits. In the event that you product. If the above two options do not result in
do not have proof of purchase date, the purchase the appropriate relief to the consumer, the
date for purposes of this warranty will be the date consumer may then take the product to an
of manufacture. independent repair facility if service or repair can
be economically accomplished. Cuisinart and not
If your Cuisinart® Brew Central 14-Cup the consumer will be responsible for the
Programmable Coffeemaker should prove to be reasonable cost of such service, repair,
defective within the warranty period, we will repair replacement, or refund for nonconforming products
it, or if we think necessary, replace it. To obtain under warranty.
warranty service, simply call our toll-free number 1-
800-726-0190 for additional information from our California residents may also, according to their
Customer Service Representatives, or send the preference, return nonconforming products directly
defective product to Customer Service at Cuisinart, to Cuisinart for repair, or if necessary, replacement,
150 Milford Road, East Windsor, NJ 08520. by calling our Consumer Service Center toll-free at
1-800-726-0190.
To facilitate the speed and accuracy of your return,
please enclose $10.00 for shipping and handling of Cuisinart will be responsible for the cost of the
the product. repair, replacement, and shipping and handling for
such products under warranty.
Please pay by check or money order (California
residents need only supply proof of purchase and BEFORE RETURNING YOUR CUISINART
should call 1-800-726-0190 for shipping PRODUCT
instructions). If you are experiencing problems with your
NOTE: For added protection and secure handling Cuisinart® product, we suggest that you call our
of any Cuisinart® product that is being returned, we Cuisinart® Service Center at 1-800-726-0190
recommend you use a traceable, insured delivery before returning the product serviced. If servicing is
service. Cuisinart cannot be held responsible for in- needed, a representative can confirm whether the
transit damage or for packages that are not product is under warranty and direct you to the
delivered to us. Lost and/or damaged products are nearest service location.
not covered under warranty. Please be sure to Important: If the nonconforming product is to be
include your return address, daytime phone serviced by someone other than Cuisinart’s
number, description of the product defect, product Authorized Service Center, please remind the
model number (located on bottom of product), servicer to call our Consumer Service Center at
original date of purchase, and any other 1-800-726-0190 to ensure that the problem is
information pertinent to the product’s return. properly diagnosed, the product serviced with
Your Cuisinart® Brew Central 14-Cup the correct parts, and the product is still under
Programmable Coffeemaker has been warranty.
manufactured to the strictest specifications and
has been designed for use with the authorized
accessories and replacement parts.
10
NOTES
11
Coffeemakers Food Toasters Blenders Cookware Ice Cream
Processors Makers
Cuisinart offers an extensive assortment of top quality products to make life in the
kitchen easier than ever. Try some of our other countertop appliances and
cookware, and Savor the Good Life . ®
www.cuisinart.com
©2008 Cuisinart
Cuisinart® is a registered
trademark of Cuisinart
08CU325
IB-8519
12