Professional Documents
Culture Documents
RRU5507 Description 03 (20181130)
RRU5507 Description 03 (20181130)
Issue 03
Date 2018-11-30
and other Huawei trademarks are trademarks of Huawei Technologies Co., Ltd.
All other trademarks and trade names mentioned in this document are the property of their respective
holders.
Notice
The purchased products, services and features are stipulated by the contract made between Huawei and
the customer. All or part of the products, services and features described in this document may not be
within the purchase scope or the usage scope. Unless otherwise specified in the contract, all statements,
information, and recommendations in this document are provided "AS IS" without warranties, guarantees or
representations of any kind, either express or implied.
The information in this document is subject to change without notice. Every effort has been made in the
preparation of this document to ensure accuracy of the contents, but all statements, information, and
recommendations in this document do not constitute a warranty of any kind, express or implied.
Website: http://www.huawei.com
Email: support@huawei.com
Contents
1 Overview......................................................................................................................................... 1
1.1 Appearance ................................................................................................................................................................... 1
1.2 Physical Ports ............................................................................................................................................................... 2
1.3 Software Version ........................................................................................................................................................... 3
1 Overview
The RRU5507 is an outdoor remote radio unit that is powered by a power cabinet. It is the RF
part of a distributed base station and can be installed near the antenna. The RRU5507
performs modulation, demodulation, data processing, and combination and division of
baseband signals and RF signals.
With the software-defined radio (SDR) technology, the RRU5507 can work in multiple modes
through software configuration.
The RRU5507 adopts a 2T4R design.
1.1 Appearance
Figure 1-1 shows the appearance of the RRU5507.
From SRAN12.1 onwards, the RRU5507 (1800 MHz) can work in NB-IoT mode.
2 Technical Specifications
The RRU5507 can work on the 1800 MHz or 2100 MHz frequency band or both at the same time.
2.2 Capacity
Table 2-2 Single-mode capacity
Mode Specifications
GSM+LTE FDD For detailed specifications, see 2.4.3 GL, 1800
MHz/1800 MHz+2100 MHz.
UMTS+LTE FDD For detailed specifications, see 2.4.4 UL, 2100
MHz/1800 MHz+2100 MHz.
GSM+UMTS+LTE FDD For detailed specifications, see 2.4.5 GUL, 1800
MHz+2100 MHz.
LTE FDD+LTE NB-IoT For detailed specifications, see 2.4.6 LM, 1800
MHz/1800 MHz+2100 MHz.
GSM+LTE FDD+LTE NB-IoT For detailed specifications, see 2.4.7 GLM, 1800
MHz/1800 MHz+2100 MHz.
UMTS+LTE FDD+LTE NB-IoT For detailed specifications, see 2.4.8 ULM, 1800
MHz+2100 MHz.
GSM+UMTS+LTE FDD+LTE For detailed specifications, see 2.4.9 GULM, 1800
NB-IoT MHz+2100 MHz.
The GSM receiver sensitivity, as recommended in 3GPP TS 51.021, is measured at the antenna
connector assuming that the channel rate reaches 13 kbit/s and the bit error rate (BER) is lower than
or equal to 2%.
The UMTS receiver sensitivity, as recommended in 3GPP TS 25.104, is measured at the antenna
connector assuming that the channel rate reaches 12.2 kbit/s and the BER is lower than or equal to
0.1%.
The LTE FDD receiver sensitivity, as recommended in 3GPP TS 36.104, is measured under a 5 MHz
bandwidth based on the FRC A1-3 in Annex A.1 (QPSK, R = 1/3, 25 RBs) standard.
The LTE NB-IoT receiver sensitivity, as recommended in 3GPP TS 36.104, is measured under a 200
KHz bandwidth and a 15 KHz subcarrier spacing based on the FRC A14-1 in Annex A.14 (π/2
BPSK, R = 1/3, 1 RB) standard.
Number of LTE FDD Output Power per LTE Bandwidth per LTE
Carriers FDD Carrier (W) Carrier (MHz)
Table 2-7 Typical output power of the RRU5507 (1800 MHz LTE FDD+2100 MHz LTE FDD)
Table 2-9 Typical output power of the RRU5507 (1800 MHz GL MSR+2100 MHz LTE FDD)
Table 2-11 Typical output power of the RRU5507 (2100 MHz UL MSR+1800 MHz LTE FDD)
2100 MHz 2100 MHz 2100 MHz 2100 MHz 1800 1800 Bandw
Number Output Number Output MHz MHz idth
of UMTS Power per of LTE Power per Number Output per
Carriers UMTS FDD LTE FDD of LTE Power LTE
Carrier Carriers Carrier FDD per LTE Carrier
(W) (W) Carriers FDD (MHz)
Carrier
(W)
Table 2-12 Typical output power of the RRU5507 (2100 MHz UMTS+1800 MHz LTE FDD)
2100 MHz 2100 MHz 1800 MHz 1800 MHz 1800 MHz
Number of Output Power Number of Output Power Bandwidth
UMTS per UMTS LTE FDD per LTE FDD per LTE
Carriers Carrier (W) Carriers Carrier (W) Carrier (MHz)
Table 2-14 Typical output power of the RRU5507 (1800 MHz GL MSR+2100 MHz UL MSR)
The typical power consumption of an RRU is measured when the ambient temperature is 25°C and the
RRU is 50% loaded. The actual power consumption has a 10% deviation from this value.
Item Specifications
Input power –48 V DC; voltage range: –36 V DC to –57
V DC
DC RRUs can use external power modules (such as AC/DC power modules, OPM15M, and OPM50M)
to support AC scenarios. For details about the external power modules, see user guides of the
corresponding models.
Item Specifications
Number of CPRI ports 2
CPRI data rate (Gbit/s) 1.25, 2.5, 4.9, or 9.8
CPRI topology Star, chain, or dual-star
Cascading level CPRI MUX:
Multimode (excluding GU): 4
Maximum distance from a BBU (km) LTE FDD or multimode (including LTE
FDD, but excluding NB-IoT):
Configured with an LBBPc or LBBPd1:
20
Configured with an LBBPd2, UBBPd3,
UBBPd4, UBBPd5, UBBPd6, or
UBBPe: 40
Configured with an LBBPd3:
− Number of cells ≤ 3: 40
− Number of cells ≥ 4: 20
Multimode (including NB-IoT): 20
Item Specifications
Operating temperature –40°C to +50°C (with solar radiation)
–40°C to +55°C (without solar radiation)
Relative humidity 5% RH to 100% RH
Absolute humidity 1 g/m3 to 30 g/m3
Atmospheric pressure 70 kPa to 106 kPa
Operating environment The RRU complies with the following
standards:
3GPP TS 45.005
3GPP TS 25.141
3GPP TS 36.141
3GPP TS 37.141
ETSI EN 300019-1-4 V2.1.2 (2003-04)
Class 4.1: Non-weather protected locations
Shockproof protection NEBS GR63 zone4
Item Specifications
Ingress protection rating IP65
According to the installation scenario, traffic load, and carrier configuration, the output power of an
RRU temporarily decreases when the RRU reaches a temperature 10°C less than its maximum operating
temperature.