Professional Documents
Culture Documents
Assignment 2
Assignment 2
Assignment 2
10
UNIVERSITI KUALA LUMPUR
MALAYSIAN INSTITUTE OF INDUSTRIAL TECHNOLOGY
INSTRUCTIONS TO CANDIDATES
Learning Outcome:
• CLO4: Design and analyze experimental data using optimization method.
• PLO4: Plan and perform research undertakings professionally, ethically and responsibly.
CONFIDENTIAL
ASSIGMENT 3
JANUARY 2022 SEMESTER
NO NAME ID NUMBER
1 NURULAIN NAZURAH BINTI ROZAINI 57360222007
CONFIDENTIAL
Question 1
Based on Design of Experiment (DOE) technique, below data collected from the experiment
conducted with THREE (3) different variables and TWO (2) level. The response or the
output from the experiment are listed in the below table. By using DOE technique and
Minitab software, analyse the data given in Table 1, 2 and 3 to find all the answers in below
questions.
Run Output
1 550
2 669
3 633
4 642
5 1037
6 749
7 1075
8 729
Largest positive and largest negative factor effect is determined by P-value <0.005. Based on table above,
the largest positive is 306.1 in Term C while largest negative is -153.6 at Term A*C
d) Write down regression model with R square for predicting based on the results of this
experiment.
Based on table above, we can see that A is negative main effect while B and C is positive main
effect plot. C is the most significant since it has steep slope.
For interaction plot, we can see that only A*B show interaction since factor A and B intercept to each other.
For A*C and B*C there is no interaction. But, if we further the experiment, somehow factor A*C will intercept to
each other if Factor A decreasing and Factor C increasing.
f) Determine the parameter level that recommend to use.
From cube plot, we identify that the highest value is 1069.0. From that, we can see that the
plot is at A -1, B 1 and C 1. Based on factor, A -1 is 0.80, B 1 is 200 and C1 325. The most
recommended parameter level is A-1,B 1,C 1 as is show the highest plot value.