Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 12

Part 1: Configure EIGRP

Task 2: Enable the EIGRP routing process.

a. Enable the EIGRP routing process on each router using AS number 1. The configuration for R1 is
shown. R1(config)# router eigrp 1
Task 3: Advertise directly connected networks.

a. Use the show ip route command to display the directly connected networks on each router. How
can you tell the difference between subnet addresses and interface addresses? Subnets are
identified with a “C” and link addresses are identified with an “L”.

b. On each router, configure EIGRP to advertise the specific directly connected subnets. The
configuration for R1 is shown.
Task 4: Configure passive interfaces.

Configure the LAN interfaces to not advertise EIGRP updates. The configuration for R1 is shown
Task 5: Disable automatic summarization.

The topology contains discontiguous networks. Therefore, disable automatic summarization on each
router. The configuration for R1 is shown
Task 6: Save the configurations.

Save as the .pka file with a filename of LABSHEET12-LASTNAMEFN.pka.

Part 2: Verifying EIGRP Routing Task 1: Examine neighbor adjacencies.

a. Which command displays the neighbors discovered by EIGRP? show ip eigrp neighbors

b. b. All three routers should have two neighbors listed. The output for R1 should look similar to the
following:

c. Take a screenshot of their show IP EIGRP neighbor output. Save the screenshot outputs as
LABSHEET12-LASTNAMEFN.pdf
Task 2: Display the EIGRP routing protocol parameters.
a. What command displays the parameters and other information about the current state of any
active IPv4 routing protocol processes configured on the router? SHOW IP PROTOCOLS

b. On R2, enter the command you listed for 2a and answer the following questions:

o How many routers are sharing routing information with R2? 2

o Where is this information located under? ROUTING INFORMATION SOURCES

o What is the maximum hop count? 100

e. Take a screenshot of their show IP route output.


Task 3: Verify end-to-end connectivity PC1, PC2 and PC3 should now be able to ping each other. If
not, troubleshoot your EIGRP configurations
Cleo Packet Tracer - ?\Users\tapre\Downloads\LABSHEET12-VERIASDANPATkICK.pkt
FT Ed* Owns her tools Extensons w Her

Fa Fa0/1 Fa0/2 Fa0/0


0

K1 |CHP 0.0DD
|CHP 0.0DD
K1

K1 |CHP 0.0DD

1841

US PM
12/20/20Z2

You might also like