Professional Documents
Culture Documents
501-12 - FPV Instrument Panel and Console
501-12 - FPV Instrument Panel and Console
FPV00006 2006.0 FPV GT/GT-P, Pursuit, Super Pursuit, F6 Typhoon and F6 Tornado
501-12-1 Instrument Panel and Console 501-12-1
GENERAL INFORMATION
FPV GT, GT-P, and Pursuit Ute instrument panel and
console are basically unchanged from other BF
Falcon models apart from unique instrument cluster
graphics, exclusive trim items, a dash mounted starter
button and dash mounted oil pressure and oil
temperature gauges. FPV F6 Tornado and F6
Typhoon instrument panel and console are basically
unchanged from other BF Falcon models apart from
unique instrument cluster graphics, exclusive trim
items, a dash mounted starter button and dash
mounted oil pressure and boost gauges. For detailed
service information and procedures, refer BF Falcon
Workshop Manual, Section 501-12.
Instrument Panel
The following additional unique GT,GT-P, F6 Tornado,
F6 Typhoon and Pursuit Ute components are
contained within the instrument panel:
FPV instrument cluster
Start button
Oil temperature, oil pressure and boost gauges
Twin Gauge Housing
NOTE: Gauges are for customer information only.
FPV00006 en 2006.0 FPV GT/GT-P, Pursuit, Super Pursuit, F6 Typhoon and F6 Tornado
501-12-2 Instrument Panel and Console 501-12-2
Symptom Chart
FPV00006 en 2006.0 FPV GT/GT-P, Pursuit, Super Pursuit, F6 Typhoon and F6 Tornado
501-12-3 Instrument Panel and Console 501-12-3
Pinpoint Tests
No
Refer to IC diagnostics.
A4 VOLTAGE CHECK
Disconnect Gauges. Yes
Replace Gauges
Connect multimeter to pin ’3’ Y wire of gauges illumination wiring
connector and measure voltage while varying IC illumination control No
switches. GO to B1
Does the voltage vary?
B2 VOLTAGE CHECK
Disconnect Gauges. Yes
Check (B/G and GR) wires on oil pressure, oil
Set multi meter to measure 12 volts and connect multimeter across temp & boost senders at engine and connector
pins behind Air Cleaner box for voltage reading. If still
For (L) wire of Gauge wiring connectors (3pin) and measure voltage. no voltage replace gauges. If voltage present
check wiring to engine senders. If voltage still
Is 12 volts present? pressent replace sender units
No
Check wire integrity. Check Inst Cluster fuse
10A.
FPV00006 en 2006.0 FPV GT/GT-P, Pursuit, Super Pursuit, F6 Typhoon and F6 Tornado
501-12-4 Instrument Panel and Console 501-12-4
FPV00006 en 2006.0 FPV GT/GT-P, Pursuit, Super Pursuit, F6 Typhoon and F6 Tornado