Professional Documents
Culture Documents
TDS Keyrim105
TDS Keyrim105
TDS Keyrim105
Keyrim-105
Specification:
Mixing ratio
100/128
(Keyrim105-A/Keyrim105-B)
Polyol 30±3°C
Processing temperature
Isocyanate 30±3°C
Page | 1/2
Edition 2019-03-03
WINRIM
Keyrim-105
Mechanical Properties
HANDLING PRECAUTIONS
Keyrim105 can cause slight to moderate irritation on direct contact with skin, eyes and mucous membranes,
particularly if contact is prolonged.
Safety goggles and impermeable protective gloves should always be wore if there is a risk of direct exposure
when handling Keyrim105.
Splashes in the eyes should be removed immediately by careful flushing with copious amounts of water. If
irritation persists, medical attention should be obtained.
Splashes on the skin should be wiped off immediately, after which the contaminated areas should be
thoroughly washed with soap and water. A barrier cream should then be applied.
Contaminated clothing should be removed immediately to prevent further skin contact and thoroughly cleaned
before reuse.
This information and our technical advice - whether verbal, in writing or by way of trials - are given in good faith but
without warranty, and this also applies where proprietary rights of third parties are involved. Our advice does not release
you from the obligation to check its validity and to test our products as to their suitability for the intended processes and
uses. The application, use and processing of our products and the products manufactured by you on the basis of our
technical advice are beyond our control and, therefore, entirely your own responsibility. Our products are sold in
accordance with the current version of our General Conditions of Sale and Delivery.
Page | 2/2
Edition 2019-03-03