Professional Documents
Culture Documents
Escavatore - ISTRUZIONI
Escavatore - ISTRUZIONI
Escavatore - ISTRUZIONI
h t t p : / / w w w. c a n o n . c o m / c - p a r k / e n /
Tools
ools Assembly
ssembly tip
Scissors Write the number of each part on the reverse side of the part in pencil
Ruler, set square upon cutting it out, to be sure you can tell which part is which later.
Glue (Wood glue or craft glue recommend) Before gluing, crease the paper along
Exhausted ballpoint pen (out of ink) mountain and valley fold lines. Trace along
Toothpicks (for use in applying glue) the folds with a ruler and an exhausted
Tweezers (useful for handling small parts) ballpoint pen (out of ink) to get a sharper fold.
Pencil Make sure rounded sections are nice and stiff.
Key to symbols
Assemble part 7 and then insert part 8 Insert part 9 to the inside of part 8 Glue part 12 in place to cover
from the bottom and glue it in place. and glue it in place. the hole and glue spot.
When assembling these pieces, be very careful to ensure Take care to glue the components of this piece
the mountain and valley folds are as shown in the illustration. together in the order shown.
Insert the pieces after checking the fit.
Cross section
Cross section
Moving part
Glue flaps a and b in order. Assemble the other side in the same way
(making the left and right sides symmetrical).
e
Insid side
Out
e
tsid
Ou de
Insi
Cross section
Outside Inside
Inside Outside
On parts with no glue tabs, apply glue to the cut surface of the paper
and glue this part to the body of the hydraulic excavator,
concealing the glue tabs.(Refer to the photograph of the completed model.)
Hyd
rau
lic
Exc
ava
tor
Finished!
Last, assemble the nameplate and
display it together with your model.