Download as pdf or txt
Download as pdf or txt
You are on page 1of 152

Installation Manual

Uniflair™ LE
Uniflair™ LE Direct Expansion Cooling Units
990-5754C-001
06MM0320@00B0130
Publication Date: April 2020
Schneider Electric IT Corporation Legal Disclaimer
The information presented in this manual is not warranted by the Schneider Electric IT Corporation to be
authoritative, error free, or complete. This publication is not meant to be a substitute for a detailed operational
and site specific development plan. Therefore, Schneider Electric IT Corporation assumes no liability for
damages, violations of codes, improper installation, system failures, or any other problems that could arise
based on the use of this Publication.
The information contained in this Publication is provided as is and has been prepared solely for the purpose of
evaluating data center design and construction. This Publication has been compiled in good faith by Schneider
Electric IT Corporation. However, no representation is made or warranty given, either express or implied, as to
the completeness or accuracy of the information this Publication contains.
IN NO EVENT SHALL SCHNEIDER ELECTRIC IT CORPORATION, OR ANY PARENT, AFFILIATE OR
SUBSIDIARY COMPANY OF SCHNEIDER ELECTRIC IT CORPORATION OR THEIR RESPECTIVE
OFFICERS, DIRECTORS, OR EMPLOYEES BE LIABLE FOR ANY DIRECT, INDIRECT, CONSEQUENTIAL,
PUNITIVE, SPECIAL, OR INCIDENTAL DAMAGES (INCLUDING, WITHOUT LIMITATION, DAMAGES FOR
LOSS OF BUSINESS, CONTRACT, REVENUE, DATA, INFORMATION, OR BUSINESS INTERRUPTION)
RESULTING FROM, ARISING OUT, OR IN CONNECTION WITH THE USE OF, OR INABILITY TO USE THIS
PUBLICATION OR THE CONTENT, EVEN IF SCHNEIDER ELECTRIC IT CORPORATION HAS BEEN
EXPRESSLY ADVISED OF THE POSSIBILITY OF SUCH DAMAGES. SCHNEIDER ELECTRIC IT
CORPORATION RESERVES THE RIGHT TO MAKE CHANGES OR UPDATES WITH RESPECT TO OR IN
THE CONTENT OF THE PUBLICATION OR THE FORMAT THEREOF AT ANY TIME WITHOUT NOTICE.
Copyright, intellectual, and all other proprietary rights in the content (including but not limited to software, audio,
video, text, and photographs) rests with Schneider Electric IT Corporation or its licensors. All rights in the
content not expressly granted herein are reserved. No rights of any kind are licensed or assigned or shall
otherwise pass to persons accessing this information.
This Publication shall not be for resale in whole or in part.
Table of Contents
Safety................................................................................. 9
Important Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9

Safety Guidelines During Installation . . . . . . . . . . . . . . . . . . . . . . . . . . 10

Electrical Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Refrigeration Safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11

Warning for Lifting and Transportation . . . . . . . . . . . . . . . . . . . . . . . . . 12

Unpacking. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Cooling unit—all models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Fan module—IX*V models . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

Warning for Installation. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14

General Information .........................................................15


Document Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
Cross-reference symbol used in this manual . . . . . . . . . . . . . 15
Abbreviations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15

Receiving and Inspecting the Cooling Unit. . . . . . . . . . . . . . . . . . . . . . 15

Storing the Cooling Unit Before Installation . . . . . . . . . . . . . . . . . . . . . 16

Equipment Disposal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Waste Electrical and Electronic Equipment (WEEE) disposal 16

Equipment Guidelines......................................................17
Working Conditions and Environmental Limits . . . . . . . . . . . . . . . . . . . 17

Compressor Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
LDAV, LDWV, LDEV units . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
IDAV, IDWV, IUAV, IUWV, IDEV, IUEV units . . . . . . . . . . . . . 18
IXAV, IXWV, IXEV units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18

Unit Overview ..................................................................19


Model Nomenclature . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19

Uniflair LE DX Cooling Unit Installation Manual 1


Nameplate Example. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20

Airflow Configurations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Upflow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Downflow . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Under floor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 22

Operating Descriptions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Air-cooled direct expansion units . . . . . . . . . . . . . . . . . . . . . . 23
Water-cooled direct expansion units . . . . . . . . . . . . . . . . . . . . 23
Energy-saving units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 23

Dimensions and Weight ...................................................24


Downflow Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24

Upflow Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25

Under Floor Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26

Service Clearance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27

Component Identification .................................................28


External Components . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Downflow units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Upflow units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Under floor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30

Internal Components—Air-Cooled, Downflow Units . . . . . . . . . . . . . . 31


LDAV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 31
IDAV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 32
IDAV models—dual cooling circuit . . . . . . . . . . . . . . . . . . . . . 33

Internal Components—Air-Cooled, Upflow Units. . . . . . . . . . . . . . . . . 34


IUAV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 34
IUAV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 35

Internal Components—Air-Cooled, Under Floor Units. . . . . . . . . . . . . 36


IXAV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36

Internal Components—Water-Cooled, Downflow Units . . . . . . . . . . . . 37


LDWV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 37
IDWV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 38
IDWV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 39

2 Uniflair LE DX Cooling Unit Installation Manual


Internal Components—Water-Cooled, Upflow Units . . . . . . . . . . . . . . 40
IUWV model—single cooling circuit . . . . . . . . . . . . . . . . . . . . 40
IUWV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 41

Internal Components—Water-Cooled, Under Floor Units . . . . . . . . . . 42


IXWV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42

Internal Components—Energy-Saving, Downflow Units . . . . . . . . . . . 43


LDEV2422A, LDEV2722A . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
IDEV1511A—single cooling circuit . . . . . . . . . . . . . . . . . . . . . 44
IDEV2022A, IDEV2422A, IDEV2922A—dual cooling circuits . 45

Internal Components—Energy-Saving, Upflow Units. . . . . . . . . . . . . . 46


IUEV1511A—single cooling circuit . . . . . . . . . . . . . . . . . . . . . 46
IUEV2022A, IUEV2422A, IUEV2922A—dual cooling circuit . . 47

Internal Components—Energy-Saving, Underfloor Units . . . . . . . . . . . 48


IXEV2311A—single cooling coil . . . . . . . . . . . . . . . . . . . . . . . 48
IXEV2622A, IXEV4022A—dual cooling circuit . . . . . . . . . . . . 49

Refrigeration Circuits—Air-Cooled, Downflow Units. . . . . . . . . . . . . . . 50


LDAV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50

Refrigeration Circuits—Air-Cooled, Downflow Units (IDAV Units) . . . . 51


IDAV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 51
IDAV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 52

Refrigeration Circuits—Air-Cooled, Upflow Units . . . . . . . . . . . . . . . . . 53


IUAV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 53
IUAV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 54

Refrigeration Circuits—Air-Cooled, Underfloor Units . . . . . . . . . . . . . . 55


IXAV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55

Cooling Circuits—Water-Cooled, Downflow Units . . . . . . . . . . . . . . . . 56


LDWV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56
IDWV models—single cooling circuit . . . . . . . . . . . . . . . . . . . 57
IDWV models—dual cooling circuit . . . . . . . . . . . . . . . . . . . . . 58

Cooling Circuits—Water-Cooled, Upflow Units . . . . . . . . . . . . . . . . . . 59


IUWV models—single cooling circuit . . . . . . . . . . . . . . . . . . . 59
IUWV models—dual cooling circuit . . . . . . . . . . . . . . . . . . . . . 60

Cooling Circuits—Water-Cooled, Underfloor Units. . . . . . . . . . . . . . . . 61


IXWV models . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 61

Uniflair LE DX Cooling Unit Installation Manual 3


Cooling Circuits—Energy-Saving, Downflow Units . . . . . . . . . . . . . . . 62
LDEV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 62
IDEV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 63
IDEV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 64

Cooling Circuits—Energy-Saving, Upflow Units . . . . . . . . . . . . . . . . . 65


IUEV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 65
IUEV models—dual cooling circuits . . . . . . . . . . . . . . . . . . . . 66

Cooling Circuits—Energy-Saving, Underfloor Units. . . . . . . . . . . . . . . 67


IXEV models—single cooling circuit . . . . . . . . . . . . . . . . . . . . 67
IXEV models—dual cooling circuit . . . . . . . . . . . . . . . . . . . . . 68

Electrical Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Single power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 69
Double power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 70

Connection Access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71

Display Interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Alarm LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 71
Status LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Link-RX/TX (10/100) LED . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Display interface . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
................................................ 72

Installation........................................................................73
Site Preparation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Installation area requirements . . . . . . . . . . . . . . . . . . . . . . . . . 73
Installation types . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 73
Power supply requirements . . . . . . . . . . . . . . . . . . . . . . . . . . 74
Humidifier and drain requirements . . . . . . . . . . . . . . . . . . . . . 74
Floor cutout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75

Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Downflow and upflow units . . . . . . . . . . . . . . . . . . . . . . . . . . . 78
Under floor units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 79

Installation on a Base Frame . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81

Installation on Floor Stand . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82

Under Floor Unit Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83

Removing Front and Internal Panels . . . . . . . . . . . . . . . . . . . . . . . . . . 87


Front panel removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 87
Rear panel removal . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 88
Electrical panel access . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 89

4 Uniflair LE DX Cooling Unit Installation Manual


Unit Connections .............................................................91
Electrical Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Connecting power to the unit . . . . . . . . . . . . . . . . . . . . . . . . . 91
Wiring a single power supply . . . . . . . . . . . . . . . . . . . . . . . . . 92
Wiring a dual power supply . . . . . . . . . . . . . . . . . . . . . . . . . . . 93

Communication Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Interface connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
A-Link connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Network connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Output relays and standby input . . . . . . . . . . . . . . . . . . . . . . . 98
Leak detector—optional . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99
Temperature sensor . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 99

Drain Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 101


Connecting to building drains (without humidifier) . . . . . . . . 101

Pressure Relief Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102

Refrigerant Piping Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102


General guidelines . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 102
Recommended condensers . . . . . . . . . . . . . . . . . . . . . . . . . 103

Piping Sizing—Air-Cooled Units . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104


Discharge line sizing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 104
Connecting the refrigeration circuit to the condenser . . . . . . 105

Water Piping Connections—Water-Cooled Units . . . . . . . . . . . . . . . . 106


Filling the water circuit—water-cooled and energy-saving units 107

Energy-Saving Units. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108


Setup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 108
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 109

Charging the Refrigeration System . . . . . . . . . . . . . . . . . . . . . . . . . . 110


Refrigeration circuits . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
System evacuation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 110

Configurable Input Connections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 111


ID*V1511A, IU*V1511A, IXEV2311A—single power supply . 111
ID*V1511A, IU*V1511A, IXEV2311A—double power supply 112
ID*V1922A, ID*V2022A, IU*V1922A, IU*V2022A—single power supply 113
ID*V1922A, ID*V2022A, IU*V1922A, IU*V2022A—double power supply 114
ID*V2422A, ID*V2922A, IU*V2422A, IU*V2922A, IX*V2322A, IXEV2622A—single power
supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 115
ID*V2422A, ID*V2922A, IU*V2422A, IU*V2922A, IX*V2322A, IXEV2622A—double power

Uniflair LE DX Cooling Unit Installation Manual 5


supply . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 116
ID*V3822A, ID*V4022A, IU*V3822A, IU*V4022A, IX*V4022A—double power supply 117
LD*V2422A, LD*V2522A, LD*V272A2, LD*V3822A—single power supply 118
LD*V2422A, LD*V2522A, LD*V2722A, LD*V3822A—double power supply 119

Accessories....................................................................121
Humidifier. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Supply water . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Drainage line and water supply line connections . . . . . . . . . 123

Condenser . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
OCC external condenser connections . . . . . . . . . . . . . . . . . . 124
Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125

Low Temperature Kit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 126


Component identification . . . . . . . . . . . . . . . . . . . . . . . . . . . 126
Dimensions and weights . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128

Check and Bypass Valves . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129


Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130

Active Flow Controller (AFC) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131


Set DIP switches . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
AFC connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 133
Installing the sensors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134

Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 136
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 137
Installation locations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Wiring options—all units . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 140

24-V Relay for External Smoke/Fire Sensors (RFF) . . . . . . . . . . . . . 141


Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 141
Installation location—all units . . . . . . . . . . . . . . . . . . . . . . . . 141
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142
Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 142

Condensate Drain Pump . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 143


Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 143
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 144
Configuration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145

6 Uniflair LE DX Cooling Unit Installation Manual


Pressostatic Valve . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Inventory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 147

Uniflair LE DX Cooling Unit Installation Manual 7


Safety

Important Safety Information


Read the instructions carefully to become familiar with the equipment before trying to install, operate, service,
or maintain it. The following special messages may appear throughout this manual or on the equipment to warn
of potential hazards or to call attention to information that clarifies or simplifies a procedure.

The addition of this symbol to a Danger or Warning safety label indicates that an electrical hazard
exists which will result in personal injury if the instructions are not followed.

This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all
safety messages that follow this symbol to avoid possible injury or death.

DANGER

DANGER indicates an imminently hazardous situation which, if not avoided, will result in death
or serious injury.

WARNING

WARNING indicates a potentially hazardous situation which, if not avoided, can result in death
or serious injury.

CAUTION

CAUTION indicates a potentially hazardous situation which, if not avoided, can result in minor
or moderate injury.

NOTICE

NOTICE addresses practices not related to physical injury including certain environmental
hazards, potential damage or loss of data.

Uniflair LE DX Cooling Unit Installation Manual 9


Safety Guidelines During Installation

WARNING
VIOLATION OF SAFETY STANDARDS

Removal of or tampering with safety devices is a violation of safety standards and will
void all warranties.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

WARNING
PERSONAL PROTECTIVE EQUIPMENT REQUIRED

During installation authorized personnel must wear approved personal protective


equipment (PPE).

Failure to follow these instructions can result in death, serious injury, or equipment
damage.

Safety Symbols on Units

High voltage

Sharp edges

Moving parts

Carefully read this manual before performing any maintenance or work on the units. Installation, maintenance,
and usage must meet all work safety standards. The operator responsible for the mentioned services must
possess expert knowledge of the devices. Schneider Electric refuses all responsibility for damage resulting
from the failure to follow safety standards.

Schneider Electric will only consider itself responsible for the safety, reliability, and performance of the unit if the
following are applicable:

• Maintenance and servicing activities have to be carried out only by by qualified personnel.

• The appliance shall be installed in accordance with applicable industry guidelines and national and local
codes and regulations.

• Devices are used in conformity with the appropriate instructions.

10 Uniflair LE DX Cooling Unit Installation Manual


Electrical Safety
Read and adhere to the following important safety considerations when working with this cooling unit.

DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

• Apply appropriate personal protective equipment (PPE) and follow safe electrical work
practices.
• This equipment must be installed and serviced by qualified personnel only.
• Turn off all power supplying this equipment before working on or inside the equipment.
• Always use a properly rated voltage sensing device to confirm power is off.
• Replace all devices, doors, and covers before turning on power to this equipment.
• If the power supply cord is damaged, it must be replaced by an equivalent cord or
assembly available from the manufacturer or its service agent.

Failure to follow these instructions will result in death or serious injury.

DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

Turn off all power supplying this equipment before working on the equipment. All electrical
work must be performed by qualified personnel. Practice Lockout/Tagout procedures. Do
not wear jewelry when working with electrical equipment.

Failure to follow these instructions will result in death or serious injury.

Refrigeration Safety
Read and adhere to the following important safety considerations when working with the refrigeration system of
this unit.

WARNING
CERTIFIED PERSONNEL ONLY

Charging and maintaining the refrigeration circuit must only be performed by certified
personnel.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

CAUTION
HAZARD OF HIGH PRESSURE REFRIGERANT OR EQUIPMENT DAMAGE

• Use R410A refrigerant only.


• Contents are under pressure: use caution when releasing pressure in the system or
re-filling.

Failure to follow these instructions can result in injury or equipment damage.

Uniflair LE DX Cooling Unit Installation Manual 11


Warning for Lifting and Transportation
Lifting and transporting the units must be carried out by qualified personnel as described in this manual.

CAUTION
DAMAGE TO EQUIPMENT OR PERSONNEL

• The equipment is heavy and can easily be tipped. For safety purposes, adequate
personnel must be present when moving this equipment.
• The load must always be solidly anchored to the bearing element of the lifting equipment
and means of transport.
• No one should be near the suspended load, nor in the working area of the crane, forklift,
truck, or any other lifting equipment or means of transport.

Failure to follow these instructions can result in moderate injury or equipment


damage.

Use all relevant safety standards to prevent any possible damage to people or objects.

The cooling unit packaged in a wooden crate or anchored to a pallet and covered with transparent film. The
recommended tools for moving and installing the equipment include the following:

FORKLIFT PALLET JACK

12 Uniflair LE DX Cooling Unit Installation Manual


Unpacking
Cooling unit—all models

NOTE: Your packaging may differ based on options selected.

na3674b

Uniflair LE DX Cooling Unit Installation Manual 13


Fan module—IX*V models

NOTE: Your packaging may differ based on options selected.


na6346a

Warning for Installation


All electrical and mechanical installations must be carried out by qualified personnel only. Qualified personnel
must use appropriate equipment when checking the grounding of devices. Installation locations should be
secure and limited to site authorized personnel or trained service technicians.

WARNING
HAZARD FROM MOVING PARTS

Keep hands, clothing, and jewelry away from moving parts. Check the equipment for
foreign objects before closing the doors and starting the equipment.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

Intended Use

The cooling units provide air conditioning within the limits and methods described in this manual. The air
conditioners must be used exclusively indoors. No modifications may be made to the units or their parts without
explicit written consent from Schneider Electric. Any mechanical or electrical modification voids factory
warranty.

14 Uniflair LE DX Cooling Unit Installation Manual


General Information

Document Overview
Uniflair™ LE Direct Expansion cooling units are precision air conditioners used to control environments for
telecom rooms, Internet hubs, and data processing centers.

This manual describes the cooling units with 400-V/ 3-phase/ 50-Hz power supply. It supplies general
information, safety instructions, unit transportation, installation information, and necessary information on how
to install the units.

The descriptions and illustrations in this manual are owned by Schneider Electric. Schneider Electric reserves
the right to make any alterations it sees fit in order to improve the product without having to update this
document.

The illustrations in this manual are examples only and may differ from your environment. All component
locations depend on model type and configuration.

Cross-reference symbol used in this manual

See another section of this document or another document for more information on this subject.

Abbreviations

EXV or EEV—Electronic expansion valve

I*AV—Air-cooled units with variable-speed compressors

I*WV—Water-cooled units with variable-speed compressors

I*EV—Energy-saving units with variable-speed compressors

LDAV—Air-cooled units with fixed-speed compressors

LDWV—Water-cooled units with fixed-speed compressors

LDEV—Energy-saving units with fixed-speed compressors

*U = Upflow; D = Downflow; X = Under floor

Receiving and Inspecting the Cooling Unit


The cooling unit is packaged in a wooden crate or anchored to a pallet and covered with transparent film.

Upon delivery, check to make sure the unit is intact and immediately notify the carrier in writing of any damage
that can be attributed to careless or improper transportation. Check for any damage on the area upon which the
display interface is mounted.

In case of shipping damage, do not operate the cooling unit. Keep all packaging used by the shipping company
for inspection and contact Schneider Electric Corporation.

Uniflair LE DX Cooling Unit Installation Manual 15


Storing the Cooling Unit Before Installation
NOTICE
WEATHER DAMAGE

Leaving the cooling unit uncovered and exposed to possible damage from the environment will void
the factory warranty.

Failure to follow these instructions can result in equipment damage.

If storing the unit for a period of time, the following procedures must be followed:

• The storage area must be dry (<85% R.H.) and protected against minimum storage temperatures –20°C
(–4°F) and extreme storage temperatures 50°C (122°F).

• The unit should remain in its original packaging if stored for long periods of time.

Equipment Disposal
Waste Electrical and Electronic Equipment (WEEE) disposal

Schneider Electric products comply with international directives on the Restriction of


Hazardous Substances (RoHS) in electronic and electrical equipment and the disposal of
Waste Electrical and Electronic Equipment (WEEE). Dispose of any waste electronic or
electrical equipment with the appropriate recycling center. Contact Schneider Electric for
assistance.

16 Uniflair LE DX Cooling Unit Installation Manual


Equipment Guidelines

Working Conditions and Environmental Limits


Limit Working Conditions
Power supply 400V/3N~/50Hz - TN
Refrigerant type R410A
Voltage input tolerance* ±10%
Frequency input tolerance—continuously ±0.5 Hz
Frequency input tolerance—short time ±1 Hz
Temperature: 18.0°C to 40.0°C (64.4°F to 104.0°F)
Room conditions (temperature/humidity)
Relative humidity: 30% to 70% and humidity ratio: 5 to 12 gr/kg
–15.0°C to 50.0°C (5.0°F to 122.0°F)
External condenser conditions (temperature) Low ambient temperature version: –40.0°C to 40.0°C (5.0°F to
122.0°F)
Maximum inlet dew point 15.0°C (59.0°F)
Maximum installation altitude 3000 m (9842.5 ft)
Storage Conditions
Maximum storage temperature –20.0°C (–6.7°F)
Minimum storage temperature 50.0°C (10.0°F)
Humidity Relative humidity: <85%RH
*In accordance with the Standard Electromagnetic Compatibility (EMC): CEI EN 61000-4-11:2006-02,EN 61000-4-11:2004-08,
IEC 61000-4-11:2004-03)

Compressor Information
LDAV, LDWV, LDEV units
Model LD*V2422A LD*V2522A LD*V2722A LD*V3822A
Supply Voltage 400 V
Compressor
Fixed-speed (on/ Fixed-speed (on/ Fixed-speed (on/ Fixed-speed (on/
Type of Compressors—Circuit 1
off) scroll off) scroll off) scroll off) scroll
Fixed-speed (on/ Fixed-speed (on/ Fixed-speed (on/ Fixed-speed (on/
Type of Compressors—Circuit 2
off) scroll off) scroll off) scroll off) scroll
Number of Refrigerant Circuits 2 2 2 2
Lubricant Oil POE-160SZ POE-160SZ POE-160SZ POE-160SZ
Oil Charge for Fixed-Speed Compressor –
3.3 (0.9) 3.3 (0.9) 3.3 (0.9) 6.7 (1.8)
l (g)
Scroll On/Off Compressor Speed – rps 50 50 50 50
Maximum Compressor Absorbed Power – kW 33.6 33.6 38.0 57.9
Full Load Absorbed Current – A* 56.5 56.5 62.5 93.9
*May be ‘A’ (air-cooled), ‘W’ (water-cooled), or ‘E’ (energy-saving) if the heat rejection version is available for that model.
**Cooling version only

Uniflair LE DX Cooling Unit Installation Manual 17


IDAV, IDWV, IUAV, IUWV, IDEV, IUEV units
ID*V1511A ID*V1922A ID*V2022A ID*V2422A ID*V2922A ID*V3822A
Model
IU*V1511A IU*V1922A IU*V2022A IU*V2422A IU*V2922A IU*V3822A
Supply Voltage 400 V
Fixed-Speed Compressor
Type of Compressors— Fixed-speed Fixed-speed Fixed-speed Fixed-speed Fixed-speed

Circuit 1 (on/off) scroll (on/off) scroll (on/off) scroll (on/off) scroll (on/off) scroll
Number of Refrigerant
– 1 1 1 1 1
Circuits
Lubricant Oil – PVE-FVC32D PVE-FVC32D POE-160SZ POE-160SZ POE-160SZ
Compressor Speed – rps – 2900 2900 2900 2900 2900
Maximum Compressor
– 9.33 9.33 10.64 12.14 18.52
Absorbed Power – kW
Full Load Absorbed
– 19.7 19.7 24.2 27.0 40.6
Current – A**
Variable-Speed Compressor
Type of Compressors— Variable-speed Variable-speed Variable-speed Variable-speed Variable-speed Variable-speed
Circuit 2 scroll scroll scroll scroll scroll scroll
Number of Refrigerant
1 1 1 1 1 1
Circuits
Lubricant Oil POE-160SZ PVE-FVC32D PVE-FVC32D POE-160SZ POE-160SZ POE-160SZ
Compressor Maximum
100 100 100 100 100 100
Speed – rps
Maximum Compressor
15.47 7.79 7.79 11.41 15.47 20.31
Absorbed Power – kW
Full Load Absorbed
27.1 13.5 13.5 27.1 27.1 35.6
Current – A*
*May be ‘A’ (air-cooled), ‘W’ (water-cooled), or ‘E’ (energy-saving) if the heat rejection version is available for that model.
**Cooling version only

IXAV, IXWV, IXEV units


Model IXEV2311A IX*V2322A IX*V2622A IX*V4022A
Supply Voltage 400 V
Fixed-Speed Compressor
Fixed-speed (on/ Fixed-speed (on/ Fixed-speed (on/
Type of Compressors—Circuit 1 –
off) scroll off) scroll off) scroll
Number of Refrigerant Circuits – 1 1 1
Lubricant Oil – POE-160SZ POE-160SZ POE-160SZ
Compressor Speed – rps – 2900 2900 2900
Maximum Compressor Absorbed Power – kW – 10.64 12.14 18.52
Full Load Absorbed Current – A** – 24.2 27.0 40.6
Variable-Speed Compressor
Variable-speed Variable-speed Variable-speed Variable-speed
Type of Compressors—Circuit 2
scroll scroll scroll scroll
Number of Refrigerant Circuits 1 1 1 1
Lubricant Oil POE-160SZ POE-160SZ POE-160SZ POE-160SZ
Compressor Maximum Speed – rps 100 100 100 100
Maximum Compressor Absorbed Power – kW 11.41 11.41 13.01 20.31
Full Load Absorbed Current – A** 27.1 27.1 27.1 35.6
*May be ‘A’ (air-cooled), ‘W’ (water-cooled), or ‘E’ (energy-saving) if the heat rejection version is available for that model.
**Cooling version only

18 Uniflair LE DX Cooling Unit Installation Manual


Unit Overview

Model Nomenclature
I D A V 20 2 2 A
IDENTIFYING PREFIX
L = FIXED-SPEED COMPRESSORS
I = VARIABLE-SPEED COMPRESSORS

AIRFLOW PATTERN
D = DOWNFLOW
U = UPFLOW
X = UNDERFLOOR

HEAT REJECTION TYPE


A = AIR-COOLED
W = WATER-COOLED
E = ENERGY-SAVING

FAN TYPE
V = RADIAL FANS WITH BACKWARD-CURVED BLADES
WITH ELECTRONIC COMMUTATION

NOMINAL COOLING CAPACITY (TONS)

NUMBER OF COMPRESSORS INSTALLED

NUMBER OF REFRIGERATION CIRCUITS

na5893a

POWER SUPPLY VOLTAGE


A = 400 V/3Ph (+N)/50 Hz

Uniflair LE DX Cooling Unit Installation Manual 19


Nameplate Example
The units can be identified by the nameplate, which is located in the electrical panel of the cooling unit. The
model and any eventual accessories that are installed are indicated by an ‘X’ in the corresponding box. The
nameplate contains the following information:

• Model and serial number of the unit

• Power supply type

• Power absorbed by the unit and individual components

• Current absorbed by the unit and individual components

• The set points of the heater over temperature switches, air pressure switches, and refrigerant safety
valve

• Refrigerant type and weight (if factory charged)

• Indication of dry nitrogen charge for field-piped units

IDAV0601A(A) IDAV1321A(A) SERIAL NO.


IDAV0611A(A) IDAV1421A(A)
IDAV1021A(A)

TENS. 400v/3pH+n/50Hz

L
AUX.
Y 24 VO
V
VOLT

COMPRESSOR
FAN
HUMIDIFIER
NO.
2
2
1
TENS (V)
400/3
400/3
400/3
OA (A) [/1]
10.7
4.7
9.1
O N
A (A) [/1]
FLA
14.0
14 0
5.6
LRA (A) [/1] P (kW) [TOT]
98 11.2
5.42
6.29

E
HEATERS STD 3 400/3 7.2 15

L
ENHANCED HEATERS 3 400/3 8.7 18
UNIT (STD HEATERS) (*) 41.7 26.02
UNIT (ENHANCED HEATERS) (*)
UNIT (STD HEATERS+CAP

M
RS+CAP
*)
P max) (*)
S+CAP max) (*)
UNIT (ENH. HEATERS+CAP P 4
46
46.0
41.7+10.5x1pH
46+10.5x1pH
29.02
28.36
31.36

A
0947-2)
947-2) / (*) in operating conditions
lcu=15kA (CEI EN 60947-2) con at 400V
TSR STOP:
OP 310ºC
310 MAN. RESET
TSRA
AP1-2
SAFETY

E
STOP

Y VALVE OPENS
CHARGE::
OPE X
STOP:
STOP:
OP:
AT:
R410A
328ºC
40.5 bar

kg/circ. R22
MAN. RESET
MAN. RESET
45 bar
kg/circ.
na5702a

PRECHARGE:GE DRY NITROGEN N2

20 Uniflair LE DX Cooling Unit Installation Manual


Airflow Configurations
Upflow

Upflow units distribute air through a supply plenum, pre-engineered duct system, or drop ceiling. Return air can
enter the unit via the front or bottom of the unit based on configuration. A base frame is required to allow access
for power, water, and refrigerant connections on non-raised floor installations.

na4934b
FRONT RETURN BOTTOM RETURN FRONT RETURN WITH
WITH TOP SUPPLY WITH TOP SUPPLY FRONT SUPPLY
(PLENUM AND GRILLE)

Downflow

Downflow units are designed to distribute air through a void under a raised access floor or a front supply floor
stand when a raised floor is not available. Return air enters the top of the unit directly from the environment or
through a duct system.

na4933d

TOP RETURN WITH FRONT TOP RETURN WITH BOTTOM


SUPPLY SUPPLY
(BASE FRAME)

Uniflair LE DX Cooling Unit Installation Manual 21


Under floor

Downflow units uniformly distribute large volumes of air into the environment by means of a void under a raised
access floor. The air enters the unit directly from the environment or through a ventilated or false ceiling.

TOP RETURN WITH


TOP RETURN WITH REAR SUPPLY
BOTTOM SUPPLY

na5294a
TOP RETURN WITH TOP RETURN WITH TOP RETURN WITH
FRONT SUPPLY FRONT AND SIDE SUPPLY OPEN SUPPLY

22 Uniflair LE DX Cooling Unit Installation Manual


Operating Descriptions
Air-cooled direct expansion units

Air-cooled DX units extract heat from the room and transfer it to the outside using air-cooled refrigerant heat
exchangers (condensers). The room unit and external condenser form an autonomous sealed circuit once
installed. Each refrigeration circuit must be connected to its remote air-cooled condenser with copper pipe for
the discharge of gas and one for the liquid return.

Water-cooled direct expansion units

In water-cooled DX units, the heat extracted from the room is transferred to water via a stainless steel, brazed
plate heat exchanger within the unit. The cooling water may be fed from the main supply, a cooling tower or a
well (open circuit), or recycled in a closed loop cooled by external coolers.In the latter case, an anti-freeze
mixture of water and ethylene glycol is normally used. The water cooled units have the advantage that the
refrigerant circuits are charged and sealed in the factory. This makes installation extremely simple, eliminating
the need for any site-installed refrigerant piping.

Energy-saving units

Energy-saving units represent an energy-efficient solution in cool or temperate climates. The operating
principle is based on the free-cooling effect available when the outside air temperature is lower than that in the
conditioned space: the lower the outside temperature, the greater the energy saving. The microprocessor
manages the operation of the unit automatically in three different situations:

• In the summer, the unit operates as a normal closed circuit glycol-cooled system.

• As the outside temperature drops, the coolant can be used directly for the free-cooling of the air. In this
case, the coolant is circulated in the coil inside the unit, and both the refrigerant circuit and the glycol
circuit contribute to cooling, thus reducing the energy used by the compressor.

• If the outside temperature drops further to a level where the coolant can dissipate the entire heat load
from the room, the refrigerant circuit is shut down completely and the unit functions as a traditional
chilled-water unit with a modulating valve.

With this technology, energy-saving units provide significant reductions in operating costs and payback periods.

Uniflair LE DX Cooling Unit Installation Manual 23


Dimensions and Weight

Downflow Units
C B

C
B

A
na5941a

Number of Cooling Dimensions – mm (in.) Net Weight* –


Heat Rejection Model
Circuits A B C D kg (lb)
LDAV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 755 (1664.5)
LDAV2522A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 870 (1918.0)
LDAV2722A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 880 (1940.1)
LDAV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1005 (2215.6)
IDAV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 695 (1532.2)
Air-Cooled
IDAV1922A 2 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 740 (1631.4)
IDAV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 715 (1576.3)
IDAV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 770 (1697.6)
IDAV2922A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 870 (1918.0)
IDAV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 985 (2171.6)
LDWV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 795 (1316.2)
LDWV2522A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 905 (1995.2)
LDWV2722A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 910 (2006.2)
LDWV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1035 (2281.8)
IDWV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 710 (1565.3)
Water-Cooled
IDWV1922A 2 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 750 (1653.5)
IDWV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 725 (1598.4)
IDWV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 795 (1316.2)
IDWV2922A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 905 (1995.2)
IDWV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1005 (2215.6)
LDEV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 850 (1873.9)
LDEV2722A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 950 (2094.4)
Energy-Saving IDEV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 740 (1631.4)
IDEV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 775 (1708.6)
IDEV2922A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 945 (2083.4)
*Weight is for a basic unit and includes the plenum.

24 Uniflair LE DX Cooling Unit Installation Manual


Upflow Units
C
B

na5902a A

Number of Cooling Dimensions – mm (in.) Net Weight* –


Heat Rejection Model
Circuits A B C kg (lb)
IUAV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 600 (1322.8)
IUAV1922A 2 1950 (76.8) 1777 (70.0) 900 (35.4) 665 (1466.1)
IUAV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 710 (1565.3)
Air-Cooled
IUAV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 760 (1675.5)
IUAV2922A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 835 (1840.9)
IUAV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 955 (2105.4)
IUWV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 615 (1355.8)
IUWV1922A 2 1950 (76.8) 1777 (70.0) 900 (35.4) 675 (1488.1)
IUWV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 715 (1576.3)
Water-Cooled
IUWV2422A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 780 (1719.6)
IUWV2922A 1 1950 (76.8) 2650 (104.3) 900 (35.4) 785 (1730.6)
IUWV3822A 2 1950 (76.8) 2650 (104.3) 900 (35.4) 865 (1907.0)
IUEV1511A 1 1950 (76.8) 1777 (70.0) 900 (35.4) 650 (1433.0)
Energy-Saving IUEV2022A 2 1950 (76.8) 2082 (82.0) 900 (35.4) 765 (1686.5)
IUEV2922A 1 1950 (76.8) 2650 (104.3) 900 (35.4) 825 (1818.8)
*Weight is for a basic unit.

Uniflair LE DX Cooling Unit Installation Manual 25


Under Floor Units
D
C

D
C

B
na6343a

Number of Cooling Dimensions – mm (in.) Net Weight* –


Heat Rejection Model
Circuits A B C D E kg (lb)
IXAV2322A 2 565 (22.2) 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 780 (1719.6)
Air-Cooled IXAV2622A 2 565 (22.2) 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 765 (1686.5)
IXAV4022A 2 565 (22.2) 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1050 (2314.9)
IXWV2322A 1 565 (22.2) 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 770 (1697.6)
Water-Cooled IXWV2622A 2 565 (22.2) 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 845 (1862.9)
IXWV4022A 2 565 (22.2) 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1010 (2226.7)
IXEV2311A 1 565 (22.2) 1950 (76.8) 1777 (70.0) 900 (35.4) 200 (7.9) 840 (1851.9)
Energy-Saving IXEV2622A 2 565 (22.2) 1950 (76.8) 2082 (82.0) 900 (35.4) 200 (7.9) 880 (1940.1)
IXEV4022A 2 565 (22.2) 1950 (76.8) 2650 (104.3) 900 (35.4) 200 (7.9) 1050 (2314.9)
*Weight is for a basic unit and includes the plenum.

26 Uniflair LE DX Cooling Unit Installation Manual


Service Clearance
To service the cooling unit, 850 mm (33.5 in.) of clearance on the front side is required.

in.)
m (33.5
850 m

na5896d

Uniflair LE DX Cooling Unit Installation Manual 27


Component Identification

External Components
Downflow units

na6263a

Item Description
 Plenum (optional)
 Touch-screen display interface
 Main disconnect switch
 External panels
 Base frame (optional)
 Air deflector (optional)

28 Uniflair LE DX Cooling Unit Installation Manual


Upflow units

na6348a

Item Description
 Damper (optional)
 Touch-screen display interface
 Main disconnect switch
 External panels
 Floor stand (optional)

Uniflair LE DX Cooling Unit Installation Manual 29


Under floor units

na6361a

Item Description
 Motorized damper (optional)
 Filter plenum
 Touch-screen display interface
 Main disconnect
 External panels
 Fan module
 Adjustable leg kit (optional)

30 Uniflair LE DX Cooling Unit Installation Manual


Internal Components—Air-Cooled, Downflow Units
LDAV models

na6172a
NOTE: Model LDAV2422A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Damper (optional)  Electric heaters (optional)
 Filter plenum  On/off compressor (circuit 2)
 Cooling coil  On/off compressor (circuit 1)
 Active Flow Controller (AFC) (optional)  Liquid receiver (circuit 1)
 Check valve (circuit 2)  Sight glass (circuit 1)
 In/out shut-off valve (circuit 2)  In/out shut-off valve (circuit 1)
 Condensate drain pan  Filter drier (circuit 1)
 Electronically commutated (EC) fans  Check valve (circuit 1)
 Liquid receiver (circuit 2)  Humidifier
 Filter drier (circuit 2)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Sight glass (circuit 2)  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 31


IDAV models—single cooling circuit

na6344a

NOTE: Model IDAV1511A is shown. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Refrigerant liquid line connection
 Active Flow Controller (AFC) (optional)  Refrigerant hot gas discharge connection
 Oil separator  In/out shut-off valves
 Variable frequency drive (VFD)  Condensate drain pan
 Filter drier  Electronic expansion valve (EEV)
 Liquid receiver  Check valve
 Electronically commutated (EC) fans  Humidifier
 Electric heaters (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Sight glass  Smoke and fire sensors (optional)
 Liquid line solenoid valve

32 Uniflair LE DX Cooling Unit Installation Manual


IDAV models—dual cooling circuit

na5898a

NOTE: Model IDAV2022A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Liquid receiver
 On/off compressor  Oil separator
 Variable speed compressor  Filter drier
 Filter drier  Humidifier (optional)
 Liquid receiver  Variable frequency drive (VFD)
 Condensate drain pan  Air pressure transducer, air temperature
sensor, and humidity sensor
 Fan  Smoke and fire sensors (optional)
 Electric reheat (optional)

Uniflair LE DX Cooling Unit Installation Manual 33


Internal Components—Air-Cooled, Upflow Units
IUAV models—single cooling circuit

na6349a

NOTE: Model IUAV1511A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Electronically commutated (EC) fans  Filter drier
 Electric heaters (optional)  Condensate pump (optional)
 Active Flow Controller (AFC) (optional)  Condensate drain pan
 Variable frequency drive (VFD)  Air filters
 Oil separator  Humidifier (optional)
 Variable-speed compressor  Air pressure transducer, air temperature
sensor, and humidity sensor (optional)
 Liquid receiver  Smoke and fire sensors (optional)

34 Uniflair LE DX Cooling Unit Installation Manual


IUAV models—dual cooling circuits

na6352a
NOTE: Model IUAV2022A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Electronically commutated (EC) fan  Condensate pump (optional)
 Electric heaters (optional)  Condensate drain pan
 Liquid receiver  Oil separator
 Filter drier  Filter drier
 Variable frequency drive (VFD)  Cooling coil
 Active Flow Controller (AFC) (optional)  Air filters
 On/off compressor  Humidifier (optional)
 Variable-speed compressor  Air pressure transducer, air temperature
sensor, and humidity sensor
 Liquid receiver  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 35


Internal Components—Air-Cooled, Under Floor Units
IXAV models

na6363a

NOTE: Model IXAV2622A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Air filters  Condensate drain pan
 Active Flow Controller (AFC) (optional)  Oil separator
 Filter drier  Filter drier
 Liquid receiver  Cooling coil
 Electronically commutated (EC) fans  Electric heaters (optional)
 On/off compressor  Humidifier (optional)
 Variable-speed compressor  Variable frequency drive (VFD)
 Liquid receiver  Air pressure transducer, air temperature
sensor, and humidity sensor (optional)
 Condensate pump  Smoke and fire sensors (optional)

36 Uniflair LE DX Cooling Unit Installation Manual


Internal Components—Water-Cooled, Downflow Units
LDWV models

na6179a

NOTE: Model LDWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Damper (optional)  Condensate drain pan
 Filter plenum  Liquid receiver (circuit 1)
 Active Flow Controller (AFC) (optional)  Liquid receiver (circuit 2)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 2)
 On/off compressor (circuit 2)  Brazed plate heat exchanger (circuit 1)
 Electric heaters (optional)  Humidifier (optional)
 Electronically commutated (EC) fans  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate pump (optional)  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 37


IDWV models—single cooling circuit

na6517a

NOTE: Model IDWV1511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Filter plenum  Condensate drain pan
 Active Flow Controller (AFC) (optional)  Brazed plate heat exchanger
 Variable frequency drive (VFD)  Cooling coil
 Electric heaters  Humidifier (optional)
 Electronically commutated (EC) fans  Air pressure transducer, air temperature
sensor, and humidity sensor
 Pressostatic valve (optional)  Smoke and fire sensors (optional)
 Condensate pump (optional)

38 Uniflair LE DX Cooling Unit Installation Manual


IDWV models—dual cooling circuits

na6516a
NOTE: Model IDWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Filter plenum  Liquid receiver (circuit 1)
 Active Flow Controller (AFC)  Liquid receiver (circuit 2)
 Variable Frequency Drive (VFD)  Brazed plate heat exchanger (circuit 2)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 1)
 Variable-speed compressor (circuit 2)  Cooling coil
 Electric heaters (optional)  Humidifier (optional)
 Electronically commutated (EC) fans  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate drain pump (optional)  Smoke and fire sensors (optional)
 Condensate pan

Uniflair LE DX Cooling Unit Installation Manual 39


Internal Components—Water-Cooled, Upflow Units
IUWV model—single cooling circuit

na6518a
NOTE: Model IDWV1511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Electronically commutated (EC) fans  Cooling coil
 Electric heaters (optional)  Brazed plate heat exchanger
 Active Floor Controller (AFC) (optional)  Air filters
 Variable frequency drive (VFD)  Humidifier (optional)
 On/off compressor  Smoke and fire sensors (optional)
 Condensate pump (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor

40 Uniflair LE DX Cooling Unit Installation Manual


IUWV models—dual cooling circuits

na6520a
NOTE: Model IUWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Electric heaters (optional)  Brazed plate heat exchanger (circuit 2)
 Electronically commutated (EC) fans  Brazed plate heat exchanger (circuit 1)
 Active Flow Controller (AFC)  Cooling coil
 Variable frequency drive (VFD)  Air filters
 On/off compressor (circuit 1)  Humidifier (optional)
 Variable-speed compressor (circuit 2)  Smoke and fire sensors (optional)
 Condensate drain pan  Air pressure transducer, air temperature
sensor, and humidity sensor

Uniflair LE DX Cooling Unit Installation Manual 41


Internal Components—Water-Cooled, Under Floor Units
IXWV models

na6324a
NOTE: Model IXWV2622A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Filter plenum  Condensate drain pan
 Active Flow Controller (optional)  Brazed plate heat exchanger (circuit 2)
 Variable frequency drive (VFD)  Brazed plate heat exchanger (circuit 1)
 On/off compressor (circuit 1)  Humidifier (optional)
 Variable-speed compressor (circuit 2)  Electric heaters (optional)
 Electronically commutated (EC) fan  Cooling coil
 Condensate pump (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Pressostatic valve (optional)  Smoke and fire sensors (optional)

42 Uniflair LE DX Cooling Unit Installation Manual


Internal Components—Energy-Saving, Downflow Units
LDEV2422A, LDEV2722A

na6731a
NOTE: Model LDEV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Filter plenum  Liquid receiver (circuit 1)
 Active Flow Controller (AFC) (optional)  Liquid receiver (circuit 2)
 On/off compressor (circuit 1)  Cooling coil
 On/off compressor (circuit 2)  Brazed plate heat exchanger (circuit 2)
 Electronically commutated (EC) fans  Brazed plate heat exchanger (circuit 1)
 Electric heaters (optional)  Humidifier (optional)
 Condensate pump (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate drain pan  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 43


IDEV1511A—single cooling circuit

na6732a

NOTE: Your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Cooling coil  Condensate drain pan
 Active Flow Controller (AFC) (optional)  Liquid receiver
 Variable frequency drive (VFD)  Brazed plate heat exchanger
 Variable-speed compressor  Humidifier (optional)
 Electronically commutated (EC) fans  Air pressure transducer, air temperature
sensor, and humidity sensor
 Electric heaters (optional)  Smoke and fire sensors (optional)
 Condensate pump (optional)

44 Uniflair LE DX Cooling Unit Installation Manual


IDEV2022A, IDEV2422A, IDEV2922A—dual cooling circuits

na6733a
NOTE: Model IDEV2022A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Cooling coil  Condensate drain pan
 Active Flow Controller (AFC)  Liquid receiver (circuit 1)
 Variable frequency drive (VFD)  Liquid receiver (circuit 2)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 1)
 Electronically commutated (EC) fans  Brazed plate heat exchanger (circuit 2)
 Variable-speed compressor (circuit 2)  Humidifier (optional)
 Electric heaters (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate pump (optional)  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 45


Internal Components—Energy-Saving, Upflow Units
IUEV1511A—single cooling circuit

na6734a

NOTE: Your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Electronically commutated (EC) fans  Cooling coil
 Electric heaters (optional)  Brazed plate heat exchanger
 Active Flow Controller (AFC) (optional)  Air filters
 Variable frequency drive (VFD)  Humidifier (optional)
 Variable-speed compressor  Smoke and fire sensors (optional)
 Condensate pump (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate drain pan

46 Uniflair LE DX Cooling Unit Installation Manual


IUEV2022A, IUEV2422A, IUEV2922A—dual cooling circuit

na6735a
NOTE: Model IUEV2022A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Electronically commutated (EC) fans  Brazed plate heat exchanger (circuit 2)
 Electric heaters (optional)  Brazed plate heat exchanger (circuit 1)
 Active Flow Controller (AFC)  Cooling coil
 Variable frequency drive (VFD)  Air filters
 On/off compressor (circuit 1)  Humidifier (optional)
 Variable-speed compressor (circuit 2)  Smoke and fire sensors (optional)
 Condensate pump (optional)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate drain pan

Uniflair LE DX Cooling Unit Installation Manual 47


Internal Components—Energy-Saving, Underfloor Units
IXEV2311A—single cooling coil

na6736a

NOTE: Your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Air filters  Condensate drain pan
 Active Flow Controller (AFC) (optional)  Cooling coil
 Humidifier (optional)  Electric heaters (optional)
 Variable-speed compressor  Variable frequency drive (VFD)
 Electronically commutated (EC) fans  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate pump (optional)  Smoke and fire sensors (optional)

48 Uniflair LE DX Cooling Unit Installation Manual


IXEV2622A, IXEV4022A—dual cooling circuit

na6737a
NOTE: Model IXEV2622A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Active Flow Controller (AFC) (optional)  Condensate drain pan
 Variable frequency drive (VFD)  Cooling coil
 On/off compressor (circuit 1)  Humidifier (optional)
 Electronically commutated (EC) fans  Electric heaters (optional)
 Variable-speed compressor (circuit 2)  Air pressure transducer, air temperature
sensor, and humidity sensor
 Condensate pump (optional)  Smoke and fire sensors (optional)

Uniflair LE DX Cooling Unit Installation Manual 49


Refrigeration Circuits—Air-Cooled, Downflow Units
LDAV models

na6173a
NOTE: Model LDAV2422A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  On/off compressor (circuit 2)
 Suction pressure sensor (circuit 2)  On/off compressor (circuit 1)
 Check valve (circuit 2)  Electronic expansion valve (EEV) (circuit 1)
 In/out shut-off valves (circuit 2)  Liquid line solenoid valve (circuit 1)
 Condensate drain pan  Refrigerant charge port (circuit 1)
 Refrigerant hot gas discharge connection  Liquid receiver (circuit 1)
(circuit 2)
 Refrigerant liquid line connection (circuit 2)  Sight glass (circuit 1)
 Pressure port  Refrigerant liquid line connection (circuit 1)
 Electronic expansion valve (EEV) (circuit 2)  Refrigerant hot gas discharge connection
(circuit 1)
 Liquid line solenoid valve (circuit 2)  In/out shut-off valves (circuit 1)
 Refrigerant charge port (circuit 2)  Filter drier (circuit 2)
 Liquid receiver (circuit 2)  Pressure port
 Filter drier (circuit 2)  Check valve (circuit 1)
 Sight glass (circuit 2)  Suction pressure sensor (circuit 2)

50 Uniflair LE DX Cooling Unit Installation Manual


Refrigeration Circuits—Air-Cooled, Downflow Units (IDAV Units)
IDAV models—single cooling circuit

na6345a

NOTE: Model IDAV1511A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Refrigerant hot gas discharge connection
 Variable frequency drive (VFD)  In/out shut-off valves
 Oil separator  Electronic expansion valve (EEV)
 Filter drier  Non-return valve (NRV)
 Liquid receiver  Refrigerant charge port
 Oil return solenoid valve  Variable-speed compressor
 Sight glass  Suction pressure sensor
 Liquid line solenoid valve  Suction temperature sensor
 Refrigerant liquid line connection

Uniflair LE DX Cooling Unit Installation Manual 51


IDAV models—dual cooling circuits

na5899a
NOTE: Model IDAV2422A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Oil return solenoid valve (circuit 2)
 Filter drier (circuit 1)  Electronic expansion valve (EEV) (circuit 2)
 Liquid line solenoid valve (circuit 1)  Liquid line solenoid valve (circuit 2)
 In/out shut-off valves (circuit 1)  Sight glass (circuit 2)
 Refrigerant liquid line connection (circuit 1)  Refrigerant charging port (circuit 2)
 Refrigerant hot gas discharge connection  Refrigerant liquid line connection (circuit 2)
(circuit 1)
 Electronic expansion valve (EEV) (circuit 1)  Refrigerant hot gas discharge connection
(circuit 2)
 Liquid receiver (circuit 1)  In/out shut-off valves (circuit 2)
 Sight glass (circuit 1)  Liquid receiver (circuit 2)
 Refrigerant charging port (circuit 1)  Filter drier (circuit 2)
 Variable speed compressor (circuit 2)  Non-return valve (NRV) (circuit 2)
 On/off compressor (circuit 1)  Variable frequency drive (VFD)
 Oil separator

52 Uniflair LE DX Cooling Unit Installation Manual


Refrigeration Circuits—Air-Cooled, Upflow Units
IUAV models—single cooling circuit

na6350a

NOTE: Model IUAV1511A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Refrigerant hot gas discharge connection
 Variable frequency drive (VFD)  Condensate drain pan
 Oil separator  In/out shut-off valves
 Variable-speed compressor  Liquid line solenoid valve
 Liquid receiver  Electronic expansion valve (EEV)
 Sight glass  Non-return valve (NRV)
 Refrigerant liquid line connection  Suction pressure/temperature sensor

Uniflair LE DX Cooling Unit Installation Manual 53


IUAV models—dual cooling circuits
E

C
B
A
na6415a

NOTE: Model IUAV2022A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Cooling coil  Variable speed compressor (circuit 2)
 Suction pressure sensor (circuit 1)  Liquid line solenoid valve (circuit 2)
 Suction temperature sensor (circuit 1)  Liquid receiver (circuit 1)
 Filter drier (circuit 1)  Oil filter
 Refrigerant charging port (circuit 1)  Sight glass (circuit 2)
 Electronic expansion valve (EEV)  Refrigerant hot gas discharge connection
(circuit 2)
 In/out shut-off valves (circuit 1)  Refrigerant liquid line connection (circuit 2)
 Condensate pan  In/out shut-off valves (circuit 2)
 Refrigerant hot gas discharge connection  Electronic expansion valve (EEV) (circuit 2)
(circuit 1)
 Refrigerant liquid line connection (circuit 1)  Filter drier (circuit 2)
 Liquid receiver (circuit 1)  Oil separator
 Liquid line solenoid valve (circuit 1)  Refrigerant charging port (circuit 2)
 Sight glass (circuit 1)  Non-return valve (NRV) (circuit 2)
 Variable frequency drive (VFD)  Suction pressure sensor (circuit 2)
 On/off compressor (circuit 1)  Suction temperature sensor (circuit 2)

54 Uniflair LE DX Cooling Unit Installation Manual


Refrigeration Circuits—Air-Cooled, Underfloor Units
IXAV models

B
A
na6431a

NOTE: Model IXAV2622A is shown: your model may differ. Some components not shown for easier viewing.
Item Description Item Description
 Suction pressure sensor (circuit 2)  On/off compressor (cooling circuit 1)
 Suction temperature sensor (circuit 2)  Variable speed compressor (circuit 2)
 Cooling coil  Refrigerant charge port (circuit 1)
 Suction pressure sensor (circuit 1)  Liquid receiver (circuit 2)
 Suction temperature sensor (circuit 1)  Sight glass (circuit 2)
 Electronic expansion valve (EEV)  Oil return solenoid valve (circuit 2)
 Check valve (circuit 1)  Refrigerant liquid line connection (circuit 2)
 Refrigerant charge port (circuit 1)  Refrigerant hot gas discharge connection
(refrigeration circuit 2)
 Liquid line solenoid valve (circuit 1)  Condensate drain pan
 In/out shut-off valves (circuit 1)  In/out shut-off valves (circuit 2)
 Refrigerant liquid line connection (circuit 1)  Filter drier (circuit 2)
 Refrigerant hot gas discharge connection  Oil separator
(circuit 1)
 Liquid receiver (circuit 1)  Non-return valve (NRV) (circuit 2)
 Sight glass (circuit 1)  Variable frequency drive
 Filter drier (circuit 1)

Uniflair LE DX Cooling Unit Installation Manual 55


Cooling Circuits—Water-Cooled, Downflow Units
LDWV models
na6180a

NOTE: Model LDWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction pressure sensor (circuit 1)  Filter drier (circuit 1)
 Cooling coil  Water inlet connection
 Suction pressure sensor (circuit 2)  Water outlet connection
 Suction temperature sensor (circuit 2)  Liquid receiver (circuit 2)
 Refrigerant charge port (circuit 2)  Liquid receiver (circuit 1)
 Refrigerant charge port (circuit 1)  Brazed plate heat exchanger (circuit 1)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 2)
 On/off compressor (circuit 2)  Electronic expansion valve (EEV) (circuit 1)
 Sight glass (circuit 2)  Electronic expansion valve (EEV) (circuit 2)
 Filter drier (circuit 2)  Suction temperature sensor (circuit 1)
 Sight glass (circuit 1)

56 Uniflair LE DX Cooling Unit Installation Manual


IDWV models—single cooling circuit

na6523a

NOTE: Model IDWV1511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction temperature sensor  Refrigerant charge port
 Humidifier (optional)  Electronic expansion valve (EXV)
 Cooling coil  Water inlet connection
 Variable-speed compressor  Pressostatic valve (optional)
 Variable frequency drive (VFD)  Water outlet connection
 Filter drier  Condensate drain pan
 Liquid receiver  Brazed plate heat exchanger
 Sight glass  Suction pressure sensor

Uniflair LE DX Cooling Unit Installation Manual 57


IDWV models—dual cooling circuit

na6522a

NOTE: Model IDWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction pressure sensor (circuit 2)  Liquid receiver
 Cooling coil  Water outlet connection
 Suction temperature sensor (circuit 1)  Water inlet connection
 Suction pressure sensor (circuit 1)  Sight glass (circuit 2)
 Condensate drain pan  Refrigerant charge port (circuit 1)
 Variable frequency drive (VFD)  Electronic expansion valve (EXV) (circuit 2)
 On/off compressor (circuit 1)  Electronic expansion valve (EXV) (circuit 1)
 Variable-speed compressor (circuit 2)  Refrigerant charge port (circuit 2)
 Filter drier (circuit 1)  Brazed plate heat exchanger (circuit 1)
 Sight glass (circuit 1)  Brazed plate heat exchanger (circuit 2)
 Filter drier (circuit 2)  Suction temperature sensor (circuit 2)

58 Uniflair LE DX Cooling Unit Installation Manual


Cooling Circuits—Water-Cooled, Upflow Units
IUWV models—single cooling circuit

na6519a

NOTE: Model IDWV1511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Cooling coil  Variable-speed compressor
 Variable frequency drive (VFD)  Water outlet connection
 Sight glass  Water inlet connection
 Condensate pan  Refrigerant charge port
 Filter drier  Brazed plate heat exchanger
 Liquid receiver  Suction temperature sensor
 Electronic expansion valve (EXV)  Suction pressure sensor

Uniflair LE DX Cooling Unit Installation Manual 59


IUWV models—dual cooling circuit

na6521a

NOTE: Model IDWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Pressure regulation valve (optional)  Liquid receiver (circuit 2)
 Cooling coil  Water outlet connection
 Suction temperature sensor (circuit 1)  Water inlet connection
 Suction pressure sensor (circuit 1)  Sight glass (circuit 2)
 Variable frequency drive (VFD)  Electronic expansion valve (EXV) (circuit 1)
 Condensate pan  Electronic expansion valve (EXV) (circuit 2)
 On/off compressor (circuit 1)  Refrigerant charge port (circuit 2)
 Variable-speed compressor (circuit 2)  Brazed plate heat exchanger (circuit 1)
 Refrigerant charge port (circuit 1)  Brazed plate heat exchanger (circuit 2)
 Filter drier (circuit 1)  Suction temperature sensor (circuit 2)
 Sight glass (circuit 1)  Suction pressure sensor (circuit 2)
 Filter drier (circuit 2)

60 Uniflair LE DX Cooling Unit Installation Manual


Cooling Circuits—Water-Cooled, Underfloor Units
IXWV models

na6525a

NOTE: Model IXWV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction temperature sensor (circuit 2)  Liquid receiver (circuit 2)
 Pressure regulation valve (optional)  Water outlet connection
 Suction temperature sensor (circuit 1)  Water inlet connection
 Suction pressure sensor (circuit 1)  Refrigerant charge port (circuit 1)
 Variable frequency drive (VFD)  Electronic expansion valve (EXV) (circuit 1)
 Condensate pan  Electronic expansion valve (EXV) (circuit 2)
 On/off compressor (circuit 1)  Refrigerant charge port (circuit 2)
 Variable-speed compressor (circuit 2)  Brazed plate heat exchanger (circuit 1)
 Filter drier (circuit 1)  Brazed plate heat exchanger (circuit 2)
 Sight glass (circuit 1)  Cooling coil
 Filter drier (circuit 2)  Suction pressure sensor (circuit 2)
 Sight glass (circuit 2)

Uniflair LE DX Cooling Unit Installation Manual 61


Cooling Circuits—Energy-Saving, Downflow Units
LDEV models—dual cooling circuits

T1

2
T1 S
na6832a

NOTE: Model LDEV2422A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction pressure sensor (circuit 2)  Filter drier (circuit 1)
 Liquid receiver (circuit 1)  Liquid receiver (circuit 2)
 Pressure regulation valves  Water outlet connection
 Suction pressure sensor (circuit 1)  Water inlet connection
 Suction temperature sensor (circuit 1)  Sight glass (circuit 1)
 2-way bypass valve (hydraulic circuit)  Sight glass (circuit 2)
 Cooling coil  Electronic expansion valve (EXV) (circuit 1)
 Condensate drain pan  Electronic expansion valve (EXV) (circuit 2)
 2-way choke valve (hydraulic circuit)  Refrigerant charge port (circuit 1)
 2-way free-cooling valve (hydraulic circuit)  Refrigerant charge port (circuit 2)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 1)
 On/off compressor (circuit 2)  Brazed plate heat exchanger (circuit 2)
 Filter drier (circuit 2)  Suction temperature sensor (circuit 2)

62 Uniflair LE DX Cooling Unit Installation Manual


IDEV models—single cooling circuit

T1

T2 S2
na6830a

NOTE: Model IDEV511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Pressure regulation valve  Filter drier
 Cooling coil  Electronic expansion valve (EXV)
 Modulating free-cooling valve (hydraulic 
Water outlet connection
circuit)
 Variable frequency drive (VFD)  Water inlet connection
 Condensate drain pan  Liquid receiver
 2-way choke valve (hydraulic circuit)  Brazed plate heat exchanger
 2-way bypass valve (hydraulic circuit)  Refrigerant charge port
 Variable-speed compressor  Suction temperature sensor
 Sight glass  Suction pressure sensor

Uniflair LE DX Cooling Unit Installation Manual 63


IDEV models—dual cooling circuits

D
na6831a

NOTE: Model IDEV2022A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction temperature sensor (circuit 2)  Sight glass (circuit 1)
 Cooling coil  Filter drier (circuit 1)
 2-way bypass valve (hydraulic circuit)  Water inlet connection?
 2-way choke valve (hydraulic circuit)  Water outlet connection?
 Suction pressure sensor (circuit 1)  Liquid receiver (circuit 1)
 Suction temperature sensor (circuit 1)  Liquid receiver (circuit 2)
 Variable frequency drive (VFD)  Condensate drain pan
 Electronic expansion valve (EXV) (circuit 2)  Electronic expansion valve (EXV) (circuit 1)
 Variable-speed compressor (circuit 2)  Pressure regulation valve
 Sight glass (circuit 2)  Brazed plate heat exchanger (circuit 1)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 2)
 2-way free-cooling valve (hydraulic circuit)  Suction pressure sensor (circuit 2)
 Filter drier (circuit 2)  Refrigerant charge ports

64 Uniflair LE DX Cooling Unit Installation Manual


Cooling Circuits—Energy-Saving, Upflow Units
IUEV models—single cooling circuit

na6833a

NOTE: Model IUEV1511A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Cooling coil  Variable-speed compressor
 2-way bypass valve (hydraulic circuit)  Water outlet connection
 2-way choke valve  Water inlet connection
 Condensate drain pan  Brazed plate heat exchanger
 Variable frequency drive (VFD)  Refrigerant charge port
 Sight glass  Pressure regulation valve
 Liquid receiver  Suction temperature sensor
 Filter drier  Suction pressure sensor
 Electronic expansion valve (EEV)

Uniflair LE DX Cooling Unit Installation Manual 65


IUEV models—dual cooling circuits

E
D
na6834a

NOTE: Model IUEV2022A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Refrigerant charge port (circuit 2)  Variable-speed compressor (circuit 2)
 Electronic expansion valve (EXV) (circuit 2)  Filter drier (circuit 1)
 Electronic expansion valve (EXV) (circuit 1)  Sight glass (circuit 1)
 Refrigerant charge port (circuit 1)  Filter drier (circuit 2)
 Pressure regulation valves  Sight glass (circuit 2)
 2-way bypass valve (hydraulic circuit)  Liquid receiver (circuit 1)
 2-way choke valve (hydraulic circuit)  Water outlet connection?
 Suction pressure sensor (circuit 1)  Water inlet connection?
 Suction temperature sensor (circuit 1)  Liquid receiver (circuit 2)
 Cooling coil  Brazed plate heat exchanger (circuit 2)
 Variable frequency drive (VFD)  Brazed plate heat exchanger (circuit 1)
 Condensate drain pan  Suction temperature sensor (circuit 2)
 2-way free-cooling valve (hydraulic circuit)  Suction pressure sensor (circuit 2)
 On/off compressor (circuit 1)

66 Uniflair LE DX Cooling Unit Installation Manual


Cooling Circuits—Energy-Saving, Underfloor Units
IXEV models—single cooling circuit

T1

T2 S2
na6835a

NOTE: Model IXEV2311A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction pressure sensor  Sight glass
 Suction temperature sensor  Filter drier
 Pressure regulation valve  Electronic expansion valve (EXV)
 Cooling coil  Liquid receiver
 2-way free-cooling valve (hydraulic circuit)  Water outlet connection
 Condensate drain pan  Water inlet connection
 2-way choke valve (hydraulic circuit)  Refrigerant charge port
 2-way bypass valve (hydraulic circuit)  Brazed plate heat exchanger
 Variable-speed compressor  Variable frequency drive (VFD)

Uniflair LE DX Cooling Unit Installation Manual 67


IXEV models—dual cooling circuit

T1

2
T2 S2
na6836a

NOTE: Model IXEV2622A is shown: your model may differ. Some components not shown for easier viewing.

Item Description Item Description


 Suction pressure sensor (circuit 2)  Filter drier (circuit 1)
 Pressure regulation valves  Sight glass (circuit 1)
 Cooling coil  Filter drier (circuit 2)
 Suction pressure sensor (circuit 1)  Sight glass (circuit 2)
 Suction temperature sensor (circuit 1)  Water outlet connection
 2-way bypass valve (hydraulic circuit)  Water inlet connection
 2-way choke valve (hydraulic circuit)  Liquid receiver (circuit 1 and 2)
 Variable frequency drive (VFD)  Electronic expansion valve (EXV) (circuit 1)
 Condensate drain pan  Electronic expansion valve (EXV) (circuit 2)
 2-way free-cooling valve (hydraulic circuit)  Refrigerant charge port (circuit 2)
 On/off compressor (circuit 1)  Brazed plate heat exchanger (circuit 1)
 Variable-speed compressor (circuit 2)  Brazed plate heat exchanger (circuit 2)
 Refrigerant charge port (circuit 1)  Suction temperature sensor (circuit 2)

68 Uniflair LE DX Cooling Unit Installation Manual


Electrical Panel
Single power supply

FC1 FC2 P2 P2 P2

M5
M7

TA1 TA2 TA3

M2
M14

RSF
CPY
TR
M9

M12 M1
M6 M10 M11

P1 P1 P1
M3

M8

P510
P511
P509

P508
P512
P507

SW1
P506 FI2
P513
J5 ME IM8 IM4 IM5 IM6 IM1
P514 18 DIN P505

P504

SW503
F20

P503
RVAF RSR1 RSR2
F9 KLO
PE
SW502

P502
RFF F21 F22
SW501 CU CR1 CR2 CC1
IG
P501
PE
F4
F5

A B C

D TAM
na6388a

NOTE: Image is an example only: your electrical panel may differ.


Item Description Item Description
 Humidifier controller (CPY)  Terminal block
 Transformer (TR)  Ground (PE)
 Condensing unit fuse (FC1, FC2) (optional)  24-V relay for external smoke/fire sensor
(RFF) (optional)
 Phase sequence control relay (RSF)  Condensate drain pump fuse (F9)
 Current transformer (TA1, TA2, TA3) (only  Energy meter power supply fuse (F21, F22)
present if an energy meter is installed) (only present if an energy meter is installed)
 J5 controller (J5–18DIN)  Chilled water valve ON/OFF relay (RVAF)
(Energy-Saving units only)
 Energy meter (ME) (optional)  Compressor oil sensor relay (KLO)
 Energy meter fuse line (F20) (optional)  Humidifier contactor (CU)
 Auxiliary automatic switch (IM8)  Heating contactor 1, 2 (CR1, CR2) (optional)
 Fan motor automatic switch (IM4)  Manual heating safety relay (RSR1) (optional)
 Humidifier automatic switch (IM5)  Automatic heating safety relay (RSR2)
(optional)
 Heating automatic switch (IM6) (optional)  Compressor contactor 1 (CC1)
 Compressor automatic switch (IM1)  Main switch (IG)
 Compressor 2 inverter fuses (FI2)  Humidifier power sensor (TAM)
 Controller fuses (F4, F5)

Uniflair LE DX Cooling Unit Installation Manual 69


Double power supply

FC1 FC2 F31 F32 P2 P2 P2

M5
M7

TA1 TA2 TA3

RPE1

RPE2
RSF
M2
TR
M14

CPY P1 P1 P1
M9

M12 M1
M6 M10 M11

M3

M8

P510

CL1 CL2
P511
P509
F11 F12 FI2
P508
F20
P512
P507

SW1 ME IM8 IM4 IM5 IM6 IM1


P506
P513
J5
P514 18 DIN P505

P504

SW503

SEL RS1 RS2 RVAF RSR1 RSR2


P503
PE F21 CT1 KLO
SW502 RFF F9 F22 CT2
CU CR1 CR2
IG
P502

PE
SW501

P501
CC1
F4

{
F5
A B D
C E F G H J K
na5946a

L TAM

NOTE: Image is an example only: your electrical panel may differ.


Item Description Item Description
 Humidifier controller (CPY)  Controller fuses (F4, F5)
 Transformer (TR)  Terminal block
 Condensing unit fuse (FC1, FC2) (optional)  Ground (PE)
 Monitoring relay fuse (F31, F32)  24-V relay for external smoke/fire sensor
(RFF) (optional)
 Monitoring relay (RPE, RPE2)  Condensate drain pump fuse (F9)
 Phase sequence control relay (RSF)  Energy meter power supply fuse (F21, F22)
(only present if an energy meter is installed)
 Current transformer (TA1, TA2, TA3)  Supply line selector “A/B” (SEL)
(optional)
(only present if an energy meter is installed)
 J5 controller (J5–18DIN)  Timer 1/2 (CT1, CT2)
 Energy meter (ME)  Supply line selector relay “A/B” (RS1, RS2)
 Energy meter fuse line (F20)  Chilled water valve ON/OFF relay (RVAF)
(Energy-Saving units only)
 Automatic transfer switch fuse (F11, F12)  Compressor 2 oil sensor relay (KLO)
 Auxiliary automatic switch (IM8)  Humidifier contactor (CU)
 Fan motor automatic switch (IM4)  Heating contactor 1, 2 (CR1, CR2)
 Humidifier automatic switch (IM5)  Manual heating safety relay (RSR1) (optional)
 Heating automatic switch (IM6) (optional)  Automatic heating safety relay (RSR2)
(optional)
 Compressor automatic switch (IM1)  Compressor contactor 1, 2 (CC1)
 Compressor 2 inverter fuses (F!2  Main switch (IG)
 Line contactor ‘A’, ‘B’ (CL1, CL2)  Humidifier power sensor (TAM)
Connection Access

See installation drawings included with the cooling unit for connection access locations.

Display Interface

Display
Reset 10/100

Micro
SD
Service
Port

USB
Console

na4820a
Item Description Function

 LCD display 7-inch touch-screen color display.

 Power LED The display is powered when the LED is illuminated.

 Check Log LED When this LED is illuminated, a new entry has been made to the
event log.

 Alarm LED When illuminated, the system has an active alarm.

 Status LED Displays current network management card status.

 Display Reset button Resets the display microprocessor. This has no effect on the air
conditioner controller.

 Link-RX/TX (10/100) LED Displays current network link status.

 Micro SD card slot Memory card expansion slot.

 Service port USB-B port used only by service personnel.

 USB-A port Supports firmware upgrades and data extraction.

 Serial Configuration port Connects the display to a local computer to configure initial network
settings or access the command line interface (CLI).

Alarm LED

This LED indicates active alarms on the display.

Condition Description
Off No Alarms
Solid yellow Warning Alarm
Solid red Critical Alarm

Uniflair LE DX Cooling Unit Installation Manual 71


Status LED

This LED indicates the status of the display.


Condition Description
One of the following situations exist:
• The display is not receiving input power.
Off • The display is not operating properly. It may need to be
repaired or replaced. Contact Schneider Electric
Customer Support.
Solid green The display has valid TCP/IP settings.
A hardware malfunction has been detected in the display.
Solid orange
Contact Schneider Electric Customer Support.
Flashing green The display does not have valid TCP/IP settings.
Flashing orange The display is making BOOTP requests.
If the LED is flashing slowly, the display is making DHCP
Alternately flashing green
requests.
and orange
If the LED is flashing rapidly, the display is starting up.

Link-RX/TX (10/100) LED

This LED indicates the network status of the display.


Condition Description
One or more of the following situations exist:
• The display is not receiving input power.
• The cable or device that connects the cooling unit to the
Off network is disconnected or not functioning properly.
• The display itself is not operating properly. It may need
to be repaired or replaced. Contact Schneider Electric
Customer Support
The display is connected to a network operating at 10
Solid green
megabits per second (Mbps).
The display is connected to a network operating at 100
Solid orange
Mbps.
Flashing green The display is receiving or transmitting at 10 Mbps.
Flashing orange The display is receiving data packets at 100 Mbps.

Display interface

The display interface main screen displays the system state information.

• Time, date (if the clock card is inserted), and number of the unit in the LAN network

• Room temperature and the percentage of humidity (if the temperature and humidity sensor is installed)

• Information regarding unit status

72 Uniflair LE DX Cooling Unit Installation Manual


Installation
Site Preparation
NOTICE
WATER DAMAGE

Installing the unit on an uneven surface may result in overflow spilling from the
condensate tray.

Failure to follow these instructions can result in equipment damage.

Installation area requirements


The installation area must follow these requirements:

• Front of the unit must have a minimum of 850 mm (33.5 in.) of clearance for service.
• A cold water distribution connection must be available if a humidifier is installed.
• Air intake and discharge connections must not be blocked.
• Installation must be on a flat, level surface.
• A fresh air supply must be available if the fresh air filter is installed.
• Connection for the power supply must be available.
• Connection for an external condensate pump must be available.
• Connection for gas discharge must be available.
• One or more drain connections must be available near the unit.
Installation types
Downflow units are intended for installation on raised access flooring using an appropriate base frame—or in
non-raised floor environments, on a provided discharge floor stand supplied by Schneider Electric.

NOTE: Upflow units with air intake through the rear or front can also be installed on floors that are not raised
(these systems require a base frame or floor stand).

Underfloor units are intended for installation with the fan module under the raised access floor with the unit
module above floor on top of the fan module. Base frames can be used with the fan module.

Installation on non-raised flooring: Installation on non-raised flooring without using base frames is only
allowable on upflow models with rear or front air return. For installations without raised floors, a floor stand is
required for routing piping and electrical wiring to the unit.

Installation on raised access flooring: Installation on raised access flooring requires the support of a base
frame beneath the unit. The frame allows installation of the unit before the raised floor is installed, increases
absorption of noise and vibrations, and facilitates connection of pipes and cables. Use a vibration pad under
each leg to reduce vibration.

Base frame installation: Using the base frame, position the unit on the base frame and secure it using the M8
screw inserts found on the base of the unit.

NOTE: Install a flexible seal (field supplied) at least 5 mm (0.2 in.) thick between the raised floor panels and the
base frame, which should also be isolated from the metallic floor structure.

Uniflair LE DX Cooling Unit Installation Manual 73


Power supply requirements
WARNING
ELECTRICAL HAZARD

• Electrical service must conform to local and national electrical codes and regulations.
• The equipment must be grounded.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

Review the electrical rating label on the equipment to determine the maximum possible current draw of the
equipment.

Humidifier and drain requirements


If a humidifier is installed, the unit requires a potable cold water supply. Condensate must be removed by a
gravity drain using proper P-traps, or by an optional condensate pump.

See “Supply water” on page 122 for humidifier supply water requirements and limitations.

74 Uniflair LE DX Cooling Unit Installation Manual


Floor cutout

Downflow units: A section of floor under the cooling unit is required to be removed for installation on a raised
floor.

B
na5580b

Dimensions – mm (in.)
Heat Rejection Model
A B
IDAV1511A 1680 (66.1) 806 (31.7)
IDAV1922A 1680 (66.1) 806 (31.7)
IDAV2022A 1986 (78.2) 806 (31.7)
IDAV2422A 1986 (78.2) 806 (31.7)
IDAV2922A 2554 (100.6) 806 (31.7)
Air-Cooled
IDAV3822A 2554 (100.6) 806 (31.7)
LDAV2422A 1986 (78.2) 806 (31.7)
LDAV2522A 2554 (100.6) 806 (31.7)
LDAV2722A 2554 (100.6) 806 (31.7)
LDAV3822A 2554 (100.6) 806 (31.7)
IDWV1511A 1680 (66.1) 806 (31.7)
IDWV1922A 1680 (66.1) 806 (31.7)
IDWV2022A 1986 (78.2) 806 (31.7)
IDWV2422A 1986 (78.2) 806 (31.7)
IDWV2922A 2554 (100.6) 806 (31.7)
Water-Cooled
IDWV3822A 2554 (100.6) 806 (31.7)
LDWV2422A 1986 (78.2) 806 (31.7)
LDWV2522A 2554 (100.6) 806 (31.7)
LDWV2722A 2554 (100.6) 806 (31.7)
LDWV3822A 2554 (100.6) 806 (31.7)
IDEV1511A 1680 (66.1) 806 (31.7)
IDEV2022A 1986 (78.2) 806 (31.7)
Energy-Saving IDEV2922A 2554 (100.6) 806 (31.7)
LDEV2422A 1986 (78.2) 806 (31.7)
LDEV2722A 2554 (100.6) 806 (31.7)

Uniflair LE DX Cooling Unit Installation Manual 75


Upflow units: A section of floor under the cooling unit is required to be removed for installation on a raised
floor.

na5580b

Dimensions – mm (in.)
Heat Rejection Model
A B
IUAV1511A 1680 (66.1) 806 (31.7)
IUAV1922A 1680 (66.1) 806 (31.7)
IUAV2022A 1986 (78.2) 806 (31.7)
Air-Cooled
IUAV2422A 1986 (78.2) 806 (31.7)
IUAV2922A 2554 (100.6) 806 (31.7)
IUAV3822A 2554 (100.6) 806 (31.7)
IUWV1511A 1680 (66.1) 806 (31.7)
IUWV1922A 1680 (66.1) 806 (31.7)
IUWV2022A 1986 (78.2) 806 (31.7)
Water-Cooled
IUWV2422A 1986 (78.2) 806 (31.7)
IUWV2922A 2554 (100.6) 806 (31.7)
IUWV3822A 2554 (100.6) 806 (31.7)
IUEV1511A 1680 (66.1) 806 (31.7)
Energy-Saving IUEV2022A 1986 (78.2) 806 (31.7)
IUEV2922A 2554 (100.6) 806 (31.7)

76 Uniflair LE DX Cooling Unit Installation Manual


Under floor units: A section of floor under the cooling unit is required to be removed for installation on a raised
floor.

na5580a

Dimensions – mm (in.)
Heat Rejection Model Airflow
A B
IXAV2322A Under floor 1735 (68.3) 857 (33.7)
Air-Cooled IXAV2622A Under floor 2040 (80.3) 857 (33.7)
IXAV4022A Under floor 2608 (102.3) 857 (33.7)
IXWV2322A Under floor 1735 (68.3) 857 (33.7)
Water-Cooled IXWV2622A Under floor 2040 (80.3) 857 (33.7)
IXWV4022A Under floor 2608 (102.3) 857 (33.7)
IXEV2311A Under floor 1735 (68.3) 857 (33.7)
Energy-Saving IXEV2622A Under floor 2040 (80.3) 857 (33.7)
IXEV4022A Under floor 2608 (102.3) 857 (33.7)

Uniflair LE DX Cooling Unit Installation Manual 77


Inventory
Downflow and upflow units
na6837a

Item Description Item Description


 Cooling unit  Leak sensor (optional) (field installed)
 Low temperature kit (optional for air-cooled  Condensate drain pump (optional) (field
units only) (field installed) installed) (See “Condensate Drain Pump” on
(See “Low Temperature Kit” on page 126.) page 143.)
 Check/by-pass valves (optional for air-cooled  Base frame (optional) (field installed)
units only) (field installed)
(See “Check and Bypass Valves” on
page 129.)
 Smoke/fire sensors (optional) (field installed)  Plenum (optional) (factory installed)
(See “Fire and Smoke Sensors” on page 135.)
 Pressostatic valve (optional for water-cooled  Floor stand (optional) (field installed)
units only) (field installed)
(See “Pressostatic Valve” on page 146.)
 Documentation

78 Uniflair LE DX Cooling Unit Installation Manual


Under floor units

na6838a

Item Description Qty. Item Description Qty.


 Cooling unit 1  Fan module 1
 Low temperature kit (optional for —  Grommet* 5
air-cooled units only) (field installed)
(See “Low Temperature Kit” on
page 126.)
 Check/by-pass valves (optional for —  M8x30 hex screw* Varies
air-cooled units only) (field installed)|
(See “Check and Bypass Valves” on
page 129.)
 Smoke/fire sensors (optional) (field —  Washer* 12
installed)
(See “Fire and Smoke Sensors” on
page 135.)
 Pressostatic valve (optional for water- —  Polyurethane tape—10 m* —
cooled units only) (field installed)
(See “Pressostatic Valve” on
page 146.)
 Documentation —  Filter plenum (factory installed) 1
 Leak sensor (optional) (field installed) —  Adjustable leg kit (optional) —
*Located in the ship-loose kit.

Uniflair LE DX Cooling Unit Installation Manual 79


Item Description Qty. Item Description Qty.
 Condensate drain pump (optional) (field —
installed) (See “Condensate Drain
Pump” on page 143.)
*Located in the ship-loose kit.

80 Uniflair LE DX Cooling Unit Installation Manual


Installation on a Base Frame
WARNING
TIPPING HAZARD

The equipment is heavy and can easily be tipped. For safety purposes, adequate
personnel must be present when moving this equipment.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

1. Install the base frame.


NOTE: Install a field-supplied, 5-mm thick (minimum), flexible, rubber seal between the cooling unit and
the edge of the raised floor.
2. Secure the cooling unit to the base frame with M8 screws from the ship-loose kit.
na6229b

Item Description
 Cooling unit
 Flexible seal
 Raised floor
 Base frame

Uniflair LE DX Cooling Unit Installation Manual 81


Installation on Floor Stand
WARNING
TIPPING HAZARD

The equipment is heavy and can easily be tipped. For safety purposes, adequate
personnel must be present when moving this equipment.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

NOTE: Floor stand installations can be performed in non-raised and raised floor environments.

1. Install the floor stand.


NOTE: Install a field-supplied, 5-mm thick (minimum), flexible, rubber seal between the cooling unit and
the floor stand.
2. Secure the cooling unit to the floor stand with M8 screws from the ship-loose kit.
na4720c

NOTE: 200-mm floor stands are installed above floor. 500-mm floor stands can be installed above or below the
floor.

Item Description
 Cooling unit
 Flexible seal
 M8 screws
 Floor stand
 Raised floor

82 Uniflair LE DX Cooling Unit Installation Manual


Under Floor Unit Installation
WARNING
TIPPING HAZARD

The equipment is heavy and can easily be tipped. For safety purposes, adequate
personnel must be present when moving this equipment.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

1. Using a forklift or pallet jack, move the fan module to the installation location.
2. Remove the fan module from the pallet.

See “Unpacking” on page 13.

3. Remove the grill panel and use ten M6 fasteners to attach the brackets on each corner.
NOTE: M6 fasteners are field supplied.
NOTE: Image is an example only; your fan module may differ.
na5780a

Uniflair LE DX Cooling Unit Installation Manual 83


4. Adjust the feet by turning the middle nut and hold in place with the bottom nut.
NOTE: Adjustable leg kit is sold separately but shipped with fan module if ordered.
5. Depending on the height of the floor stand, do one of the following:
a. If the floor stand height is equal to or less than 200 mm, hold the bolt in place with the top nut to
prevent it from extending past the top of the floor stand.
TOP NUT

MIDDLE NUT
na5265a

BOTTOM NUT

SELF-TAPPING SCREWS

b. If the floor stand height exceeds 200 mm, attach the included brackets to the floor stands and the
bottom of the module with four screws and two nuts.

SCREWS

SCREWS
na5715a

NUT

NUT

SELF-TAPPING SCREWS

84 Uniflair LE DX Cooling Unit Installation Manual


6. Rubber plates can be attached to the floor stand flange using three self-tapping screws.
NOTE: The customer can decide whether to use the rubber plates beneath the floor stand flange.
7. Using a forklift or pallet jack, move the cooling unit to the installation location.

na5171a
8. Lift the cooling unit on top of the fan module.
NOTE: Install a field-supplied, 5-mm thick (minimum), flexible, rubber seal between the cooling unit and
the edge of the raised floor.
na6229c

9. Attach the cooling unit to the fan module with the M8x30 hex screws and washers.

Uniflair LE DX Cooling Unit Installation Manual 85


10.Make the power and communication connections between the fan module and the cooling unit.
na6540b

POWER CONNECTION COMMUNICATION


CONNECTION
Removing Front and Internal Panels

WARNING
ELECTRCIAL HAZARD

Before servicing, disconnect the power supply.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

CAUTION
HEAVY EQUIPMENT

The panels are heavy. Use extreme caution when moving.

Failure to follow these instructions can result in serious injury or equipment


damage.

Front panel removal


1. Firmly hold the panel at the top and pull straight out.
2. Lift and incline the panel outwards until it is completely removed.

na5221a

Uniflair LE DX Cooling Unit Installation Manual 87


Rear panel removal
WARNING
MOVING PARTS HAZARD

Do not remove rear panels if the equipment is operating.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

1. Turn the main switch to OFF.


2. Remove the plugs securing the panel.
3. Slowly pull the panel away from the unit until removed.

na6267a

88 Uniflair LE DX Cooling Unit Installation Manual


Electrical panel access
WARNING
ELECTRCIAL HAZARD

Before servicing, disconnect the power supply.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

NOTE: Disconnect the display interface from the J5 controller to avoid cable strain.

1. Turn the main switch to OFF.


2. Remove the front panel.
3. Remove the screws securing the internal panel and pull the panel away from the unit.

INTERNAL
PANEL

ELECTRICAL
PANEL

na6268a

FRONT PANEL

Uniflair LE DX Cooling Unit Installation Manual 89


90 Uniflair LE DX Cooling Unit Installation Manual
Unit Connections

Electrical Connections

DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

• Apply appropriate personal protective equipment (PPE) and follow safe electrical work
practices.
• This equipment must be installed and serviced by qualified personnel only.
• Turn off all power supplying this equipment before working on or inside the equipment.
• Always use a properly rated voltage sensing device to confirm power is off.
• Replace all devices, doors, and covers before turning on power to this equipment.
• If the power supply cord is damaged, it must be replaced by an equivalent cord or
assembly available from the manufacturer or its service agent.

Failure to follow these instructions will result in death or serious injury.

WARNING
ELECTRICAL HAZARD

• Electrical service must conform to local and national electrical codes and regulations.
• The equipment must be grounded.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

CAUTION
HAZARD FROM SHARP EDGES

Many metal parts have sharp edges. Be careful and wear protective gloves and clothing
when working around and inside the equipment.

Failure to follow these instructions can result in serious injury.

Connecting power to the unit


1. Check that the unit is grounded.
2. Ensure that the facility voltage and frequency correspond to those of the unit (see the nameplate).
3. Ensure the main switch is in the OFF position.
4. Access the electrical panel.

See “Electrical panel access” on page 89.

Uniflair LE DX Cooling Unit Installation Manual 91


Wiring a single power supply
1. Route the power supply cable through the electrical panel to the terminal block.
2. Connect the power cable to the terminal block using the diagram provided below.

See the wiring diagrams provided with the unit.

R1 S1 T1 N1 PE

IG 1

0 PE
na5948b

L1 L2 L3 N PE
{
LINE 1

POWER SUPPLY CABLE

92 Uniflair LE DX Cooling Unit Installation Manual


Wiring a dual power supply
1. Route the power supply cable through the electrical panel to the terminal block.
2. Connect the power cable to the terminal block using the diagram provided below.

See the wiring diagrams provided with the unit.

N10 R10 S10 T10 R20 S20 T20 N20 PE

IG 0
PE PE
na5948a

N L1 L2 L3 L10 L20 L30 N0 PE PE


{
{ LINE 1

POWER SUPPLY CABLE


LINE 2

Uniflair LE DX Cooling Unit Installation Manual 93


Communication Connections
Interface connection

24V 24V
J9 J10 J11 J12 J13 J14 J15 J16 J17 J18 J19
100-240V

– + 24V 12V 0V NC COM NO NC COM NO NC COM NO

2 1 1 2 4 3 2 1
3 4
– Link

(1)

RS485
(2)

(3)

FIELDBUS TX TX MODBUS NETWORK


RS485 (2) RS485 (3)
CAN RS485 (1) 2W/4W D0- D1+ 0V 2W/4W D0- D1+ 0V

RX RX 1 2 3 4
CANH CANL 0V D0- D1+ 0V D0- D1+ 0V D0- D1+ 0V

J1 J2 J3 RS485 J4 CAN J5 J6 J7 J8
M

na6256a

Item Description Item Description


 USB device port  Touch screen display connection
 USB host port  Modbus connection
 Serial port  Modbus configuration switches
 A-Link ports  Fieldbus Modbus connection
 Reset button  Fieldbus Modbus configuration switches
 Output relay 4/standby input  Fieldbus CANbus configuration switches
 Output relay 1–3  Fieldbus CANbus connection
 Universal sensor ports  Processor status LED
 Network connection

94 Uniflair LE DX Cooling Unit Installation Manual


A-Link connections
NOTE: All input and output connections should be wired as Class 2 circuits.

The A-Link bus connection allows a maximum group of sixteen Uniflair LE DX cooling units to communicate
with each other.

To enable the cooling units to function as a group, link them together using a standard pin-out CAT-5 cable with
RJ-45 connectors. The A-Link bus must be terminated at the first and last unit installed in the group. An A-Link
terminator is supplied with each unit.

CAUTION
CAT 5 PINOUT

Devices connected on the A-Link ports should use a standard pin-out (1-1, 2-2, 3-3, 4-4,
5-5, 6-6, 7-7, 8-8) CAT5 cable only.

Failure to follow these instructions can result in equipment damage.

NOTE: The maximum wire length for the entire group must not exceed 500 m (1640 ft).

Active Flow Controllers (AFC): If AFC units are installed in the cooling group in a HACS or CACS
environment, they are connected to the A-Link bus as shown. If the cooling group is in an underfloor
environment, the AFC units are connected through the J5 port on the controller.

See the Active Flow Controller Installation Manual for more information.

Uniflair LE DX Cooling Unit Installation Manual 95


FIRST COOLING UNIT SECOND COOLING UNIT LAST COOLING UNIT

IF NO AFC IS
PRESENT, RJ-45
TERMINATOR
GOES HERE

RJ-45
TERMINATOR

A-LINK
CABLE AFC AFC
(OPTIONAL) (OPTIONAL)

na6259a

96 Uniflair LE DX Cooling Unit Installation Manual


Network connection

FIRST COOLING UNIT SECOND COOLING UNIT LAST COOLING UNIT

na6273a
LAN CABLE
(10/100 BASE-T)
SWITCH/HUB

Uniflair LE DX Cooling Unit Installation Manual 97


Output relays and standby input

na6274a
Item Name Description
 Output relay 1 N.O. Normally Open contact
 Output relay 1 COM Common contact
 Output relay 1 N.C. Normally Closed contact
 Output relay 2 N.O. Normally Open contact
 Output relay 2 COM Common contact
 Output relay 2 N.C. Normally Closed contact
 Output relay 3 N.O. Normally Open contact
 Output relay 3 COM Common contact
 Output relay 3 N.C. Normally Closed contact
 Output relay 4 N.O. Normally Open contact
 Output relay 4 COM Common contact
 Output relay 4 N.C. Normally Closed contact
 Ground Ground reference, typically connected to the negative
connection of Standby Input, when using the 12-VDC or
24-VDC power supply.
 12VDC Standby input 12-VDC supply current limited to 20 mA
 24VDC Standby input 24-VDC supply current limited to 20 mA
 Standby Input + Positive connection used for Standby Input
 Standby Input – Negative connection used for Standby Input. Typically
connected to ground.

98 Uniflair LE DX Cooling Unit Installation Manual


Output relays: Four output relays connections are available. These relays can be configured, through the user
interface, to various alarms detecting normal or abnormal conditions.

Output relays are Form C type, having a Normally Open (N.O.), Normally Closed (N.C.), and Common (COM)
contacts.

NOTE: Output relays are rated at 24 VDC, 6 A maximum.

Standby input: Standby input allows the cooling unit to be remotely placed in backup mode. Backup mode is
configured through the user interface and can be set as a normally “active” or “not active” input.

See “Configurable Input Connections” on page 111.

Leak detector—optional
The leak rope detector (NBES0308) connects to a universal sensor port
connection using the supplied cable in the leak detector kit. Route the
leak detector cable through one of the low voltage wiring openings.

NOTE: The total length of the rope leak sensor can be extended up to
24.4 m (80 ft) using a Rope Leak Sensor Extension kit (NBES0309).

See the documentation supplied with the kit for installation information.

Temperature sensor
The remote temperature sensor (AP9335T) monitors the room
temperature surrounding the cooling unit, ensuring the area is
being cooled at the correct temperature.

Location considerations

IMPORTANT: Different locations of the remote temperature sensors can result in different operational behavior
of the cooling unit. The optimal position of the temperature sensors will vary from installation to installation, but
should be located in an active rack air flow stream to allow accurate readings. It is not recommended to place
remote sensors in front of areas with little or no active rack air flow (e.g., in front of blanking panels).

• Servers most likely to have insufficient cooling air or inadequately cooled air due to the recirculation of
hot air from the hot aisle include the following:
• Servers positioned at the top of a rack
• Servers positioned at any height in the last rack at an open end of a row
• Servers positioned behind flow-impairing obstacles such as building elements
• Servers positioned in a bank of high-density racks
• Servers positioned next to racks with Air Removal Units (ARU)
• Servers positioned very far from or very close to the cooling unit

Installation

Uniflair LE DX Cooling Unit Installation Manual 99


NOTE: For proper operation, the temperature sensor must be installed as shown below.

1. Route the rack temperature sensor cable through a


low voltage wiring opening on the top or bottom of
the cooling unit, then through the top or bottom of
the adjacent server enclosure.
2. Using the provided wire clips, secure the TEMPERATURE
temperature sensor cable to the inside of the front SENSOR
door of an adjacent server enclosure.
3. Connect the RJ-45 connector to a universal sensor
port on the controller. See “Interface connection” on
page 94. WIRE CLIP

100 Uniflair LE DX Cooling Unit Installation Manual


Drain Connections
The condensate water drains from the tray through a 25-mm flexible tube installed in the unit.

If the unit is equipped with a humidifier, ensure the humidifier connection is connected to the building drain and
that the pipe is rated for 100°C (212°F).

See “Humidifier” on page 121 for information about connecting to building drains on units with a
humidifier.

Connecting to building drains (without humidifier)

NOTICE
COMPLIANCE REQUIREMENT

The installation must comply with local plumbing codes.

Failure to follow these instructions can result in equipment damage.

2.5 cm PER 2.1 m


(1 in. PER 10 ft)
na4737a

Item Description
 Drain
 Trap
 Minimum slope

1. Connect the unit drainage tube to the building drains using a rubber or plastic tube with a 25-mm
internal diameter.
2. Use a trap on the external drainage tube in order to avoid unpleasant odors and to allow the condensate
pan to drain properly. Consult local building codes for drain requirements.
3. Once the connections have been made, pour water into the condensate drain until the trap inside the
unit is full.

Uniflair LE DX Cooling Unit Installation Manual 101


Pressure Relief Valve
All Uniflair LE DX units have a pressure relief valve located on top of the liquid receiver for refrigerant
discharge. The pressure relief valve allows refrigerant to discharge during a fire or any situation that would
result in the refrigerant system pressure exceeding the pressure rating of the relief valve. The pressure relief
valve must be piped to the outside ambient air. For details, consult local and national codes.

Refrigerant Piping Connections


Air-cooled DX units must be connected to a remote outdoor condenser. Systems with remote outdoor
condensers must have discharge and liquid lines from the equipment to the condenser.

NOTE: Install all refrigerant lines in accordance with applicable industry guidelines as well as local and
national codes and regulations.

General guidelines
NOTICE
CERTIFIED PERSONNEL ONLY

• The laying of the lines and the refrigerant connections must be performed by certified
personnel.

• All lines must be properly supported, insulated, and isolated to avoid premature joint
failures due to system vibrations.

Failure to follow these instructions can result in equipment damage.

NOTICE
EQUIPMENT DAMAGE

Pipes must be protected from the sun and snow.

Failure to follow these instructions can result in equipment damage.

• All refrigerant circuits must connect to the condenser with copper pipes.
• All refrigerant lines/chilled water piping are free from debris.
• All refrigerant lines should be as short and direct as possible.
• All refrigerant pipes are installed with proper supports and approved refrigerant line clamps.
NOTE: Isolate piping from structural surfaces using proper refrigeration/AC vibration clamps.

102 Uniflair LE DX Cooling Unit Installation Manual


Recommended condensers
The following table shows the condenser compatibility for the air-cooled cooling units and the number of
condensers.

LDAV2422A IDAV1922A
Condenser LDAV2722A LDAV3822A IDAV1511A IDAV2422A IDAV2922A IDAV3822A
LDAV2522A IDAV2022A
OCC1701AC 2 2 — 1 2 2 2 —
OCC1701EC
OCC2101AC 2 2 — 1 2 2 2 —
OCC2101EC
OCC2401AC 2 2 2 1 2 2 2 2
OCC2401EC
OCC2601AC 2 2 2 1 2 2 2 2
OCC2601EC
OCC3101AC 2 2 2 1 — 2 2 2
OCC3101EC
OCC3301AC 2 2 2 1 — 2 2 2
OCC3301EC
OCC3901AC — 2 2 1 — — 2 2
OCC3901EC
OCC3502AC 1 1 — — 1 1 1 —
OCC3502EC
OCC4202AC 1 1 — — 1 1 1 —
OCC3502EC
OCC4702AC 1 1 1 — 1 1 1 1
OCC4702EC
OCC5302AC 1 1 1 — 1 1 1 1
OCC5302EC
OCC6202AC 1 1 1 — — 1 1 1
OCC6202EC
OCC6702AC 1 1 1 — — 1 1 1
OCC6702EC
OCC7702AC — 1 1 — — — 1 1
OCC7702EC
OCC1701LT 2 2 — 1 2 2 2 —
OCC2101LT 2 2 — 1 2 2 2 —
OCC2401LT 2 2 — 1 2 2 2 —
OCC2601LT 2 2 — 1 2 2 2 —
OCC3101LT 2 2 — 1 — 2 2 —
OCC3301LT — — 2 1 — — — 2
OCC3901LT — — 2 1 — — — 2

Condenser Refrigerant Connections


OCC2601*
OCC3101*
OCC1701* OCC3301*
OCC2101* OCC3901*
OCC2401* OCC5302*
OCC3502* OCC6202*
OCC4202* OCC6702*
Condenser Model OCC4702* OCC7702*
Ø Inlet Gas – mm 28 35
Ø Outlet Liquid – mm 18 22
* can be AC, EC, or LT if the version is available for the unit.

Uniflair LE DX Cooling Unit Installation Manual 103


Piping Sizing—Air-Cooled Units
Air-cooled DX units must be connected to a remote outdoor condenser. Systems with remote outdoor
condensers must have discharge and liquid lines from the equipment to the condenser.

OCC condensers need to be connected to internal units with a Belden®-type signal cable to be able to manage
fan speed regulation. The following are the recommended signal cables:

• Condenser with AC fans


– ITC Belden—15S7D
– Belden—3107A
• Condenser with EC fans
– ITC Belden—3107A
Discharge line sizing
WARNING
BURN RISK

Discharge lines must be insulated where contact could be made to avoid a contact burn.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

The discharge line must be sized in such a way that proper oil flow is provided at all operating levels of the
compressors. Particular attention should be paid to operation at partial load on units equipped with variable-
speed compressors to provide oil return in all conditions. Even if it would be preferable to have low losses of the
load along the line, an oversized discharge line necessary to reduce the speed of the refrigerant causes a
reduction in the flow of oil. When the unit uses variable-speed drive compressors for the cooling circuit, the
discharge line must allow oil flow at all operating levels.

The pressure drops along the discharge line causes an increase in the condensing temperature and a
decrease in the cooling capacity of the cooling unit. Note that each percentage point of decrease in the cooling
capacity corresponds to a decrease of 1°C (1.8°F) of the maximum operating temperature. The systems are
normally sized such that the loss of load from the discharge line does not cause a decrease in the efficiency of
the cooling unit of more than –3%. The responsibility of establishing the refrigerant line between the condenser
and the external unit lies with the installer. Units can operate with a maximum equivalent length up to 100
meters (328..1 feet) (including a maximum height difference of 30 meters (98.4 feet)) considering the
consequent penalization in performance.

NOTE: When the distance of 50 meters (164.0 feet) equivalent length is exceeded, it is required to contact
Schneider Electric Customer Support.

The oil type is specific for each compressor and is noted in the Uniflair LE DX Installation Manual.

A check and by-pass valve kit for liquid line application can be selected as an option. This option is mandatory
on the condenser outlet when the condenser is installed below unit level or with refrigerant lines longer than 20
meters in order to avoid liquid migration to the condenser during the cold season and the off phase.

To define the optimal refrigerant lines, please refer to UNICALC Piping Sizing Tool.

104 Uniflair LE DX Cooling Unit Installation Manual


1/100
1/100

MAXIMUM
10 M (32.8 FT)

1/100

MAXIMUM
MAXIMUM 30 M (98.4 FT)
5 M (16.4 FT)

MAXIMUM
5 M (16.4 FT)
na3925a

It is required to install a syphon or oil trap every time the piping changes from a horizontal to a vertical position.
It is also required to install a syphon or oil trap every 5 meters (16.4 ft) on the vertical piping section.

Connecting the refrigeration circuit to the condenser


The diameter of the pipes must be selected according to the length of the refrigerant line. Therefore, it is
possible that the internal diameter of the valves supplied by Schneider Electric will not coincide with the
diameter of the pipes.

Uniflair LE DX Cooling Unit Installation Manual 105


Water Piping Connections—Water-Cooled Units
.

NOTICE
DRAINAGE REQUIREMENT

Draining the unit is recommended after prolonged inactivity.

Failure to follow these instructions can result in equipment damage.

For all water connections (except for the condensate drain):

1. Use shutoff valves (not supplied) to isolate the unit from the water circuit. If possible, use full-port ball
valves to minimize the pressure drop.
2. Check that the water pipe sizes and the circulating pump quality are adequate; insufficient water flow
affects unit performance.
3. Check that the water flow directions are verified and connected properly between the unit and building.
NOTE: Ensure that all pipes are free of debris and all system strainers are in place and oriented in the
correct direction.
4. Insulate all water pipes with closed cell insulating material avoiding air gaps (for example: Armaflex™ or
equivalent) to avoid condensation. The insulation must allow accessibility to the valves and three-piece
joints.
5. Check that the water circuits are supplied with a maximum water pressure of 2068 kPa (300 psi). Install
a safety valve with a setpoint of no more than 2068 kPa (300 psi).

na6839a

WATER OUTLET WATER INLET


CONNECTION CONNECTION

106 Uniflair LE DX Cooling Unit Installation Manual


Filling the water circuit—water-cooled and energy-saving units
NOTICE
CHILLED WATER CIRCUIT REQUIREMENT

Filling the chilled water circuit must be done by qualified personnel.

Failure to follow these instructions can result in equipment damage.

NOTE: The water used to fill the chilled water circuit must be filtered with a minimum 20-mesh stainless steel
screen.

1. Before use, disconnect the power supply.


2. Clean the primary circuits before filling the units (a particulate strainer should be installed in the supply
water piping within close proximity to the unit).
3. Check that all unit bleed valves are closed.

BLEED
VALVES
na6637a

NOTE: Model LDAV2422A is shown as an example.


4. Open the isolation valves (field installed).
5. Open the bleed valve and wait for the water to come out.
6. Close the valve once all air is removed.
7. Repeat step 5 and step 6, if necessary, to remove all air.

Uniflair LE DX Cooling Unit Installation Manual 107


Energy-Saving Units
Setup
DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

Turn off all power supplying this equipment before working on the equipment. All electrical
work must be performed by licensed electricians. Practice Lockout/Tagout procedures.
Do not wear jewelry when working with electrical equipment.

Failure to follow these instructions will result in death or serious injury.

Energy-saving units are connected to an outside fluid cooler. If the ambient temperature reaches the
established setpoint, energy saving mode is activated. Whenever the difference between the room temperature
and the ambient temperature is at least a 9°C (16°F), the fluid cooler will operate in winter mode with a 7.2°C
(45°F) setpoint.
na 7

Item Description
 Electrical panel
 Ambient temperature sensor
 Fluid cooler

NOTE: Only use fluid-coolers supported by Schneider-Electric.

NOTE: Use 2 1-mm wires only for electrical connections from the unit to the fluid cooler.

NOTE: Maximum recommended distance to electrical connections from the unit to the fluid cooler is 152.4 m
(500 ft).

NOTE: For cooling applications with multiple units and fluid coolers in a common loop, contact Schneider
Electric Technical Support for the appropriate interconnection wiring diagram.

108 Uniflair LE DX Cooling Unit Installation Manual


Installation
1. Install the outside ambient temperature sensor (stored inside the electrical panel) to an appropriate
location, carefully routing the shielded cable.
NOTE: Maximum distance between the unit and the outdoor sensor is 30.5 m (100 ft).
2. Install water piping to the fluid cooler.
3. Connect the wires from the fluid cooler to the terminal block in the unit.

992 982
0–10 V
990 980

SAS

M5
M7

M2
970

M14
ON/OFF 960 CPY

M9

M12 M1
M6 M10 M11

M3

M8
SIGNAL 52 51
P510
P511
P509

P508
P512
P507

50 23 SW1

P513
J5
P506

P514 18 DIN P505

21 00 P504

SW503

P503

21 00
SW502

P502
SW501

P501

21 00 F4
F5

120 660

na5978c
24 0
24 0
24 0
20 20
20 20

4. Attach the leaving water temperature sensor to the pipe with clamps, and wrap the sensor with
ultraviolet resistant insulation.

See RAL ED for more connection information.

Uniflair LE DX Cooling Unit Installation Manual 109


Charging the Refrigeration System
Refrigeration circuits
WARNING
CERTIFIED PERSONNEL ONLY

Charging and maintaining the refrigeration circuit must only be performed by certified
personnel.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

The refrigeration circuit from the factory is pre-charged with nitrogen. Prior to evacuation, perform the following
pressure test:

1. Perform a gross nitrogen pressure test of 7 bar (100 psig) on the entire piping system.
2. Hold the pressure for one hour and monitor the system for any loss of pressure.
3. If the pressure reading decreases, check the piping for leaks and repair as needed.
4. Repeat the pressure test after any repairs to ensure no leaks remain in the system.
System evacuation
1. After completing the gross pressure test, release the nitrogen from the system to the atmosphere using
the service port at the condenser.
2. Open all manually operated isolation valves to ensure that all parts of the system will be evacuated.
3. Connect a vacuum pump and digital vacuum gauge to the service ports on the system piping. Using a
core removal tool may reduce the time of the evacuation.
4. Create a vacuum within the lines while maintaining the pressure below 10 Pa absolute (0.07 mm Hg)
(500 microns) for about an hour in order to evacuate the air and any humidity.
5. Stop the vacuum pump and wait for a build up period of about 30 minutes and check that the pressure
has not exceeded 200 Pa absolute (500 microns).
6. After completing the system evacuation, immediately charge the system with refrigerant.

110 Uniflair LE DX Cooling Unit Installation Manual


Configurable Input Connections
See unit wiring diagrams for more information.

ID*V1511A, IU*V1511A, IXEV2311A—single power supply


NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving) if the heat rejection type is available for
the model..

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• Condensate pump • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
F4
4A-’T’ 21 21 23

T-H VERSION
RSR1 RSR2
21

51 52 50 R6 R8
TEST1 TEST1 TEST1 TEST1 TEST1
9 6 7 5 8

471

481
27

51

23

50
52

J5-18DIN
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL4(12) IDL6(14)

na5977b
CHGND(3) AC/DC1(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13
P512
0 0 0

970 960 ELECTRICAL PANEL


52 51
P2 P2 P2

50 23
M5
M7

TA1 TA2 TA3


M2
M14

CPY
TR
M9

M12 M1
M6 M10 M11

P1 P1 P1

21 00
M3

M8

P510
P511
P509

21 00 P512

SW1
P508

P507

IM8 IM4 IM5 IM6 FI2

21 00
P506

J5 ME
P513

P514 18 DIN P505

P504

SW503
F20

120 660 P503

SW502
PE
KLO RC2 RSR1 RSR2
P502
RFF
F9 CU CR1 CR2
24 0
SW501

IG
P501
PE
F4
F5

24 0
na5978b

24 0
TAM

24 0
24 0
20 20
20 20

Uniflair LE DX Cooling Unit Installation Manual 111


ID*V1511A, IU*V1511A, IXEV2311A—double power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving).

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• Condensate pump • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
F4
4A-’T’ 21 21 23

T-H VERSION
RSR1 RSR2
21

R15

R15
N10
51 52 50

N10
R6 R8
TEST1 TEST1 TEST1 TEST1 TEST1 R25
9 6 7 5 8

471

481
N20
27

R25
N20
51

23

50
52

J5-18DIN

IDHC2(1)

IDHC1(1)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2)

IDH2(2)

IDH1(2)
IDL4(12) IDL6(14)

na5977a
CHGND(3) AC/DC1(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13 J10 J12
P512
0 0 0

ELECTRICAL PANEL
992 982
991 981 F31 F32 RPE1 RPE2
SAS

M5
M7

M2

TR
M14

970 960 CPY


M9

M12 M1
M6 M10 M11

M3

M8

52 51
P510

CL1 CL2
P511
P509
F11 F12 FI
P508
P512

50 23
P507

SW1
IM8 IM4 IM5 IM6
P506
P513
J5
18 DIN P505

21 00
P514

P504

SW503

SEL RS1 RS2 KLO RC2 RSR1 RSR2


P503
PE

21 00 F9 CT1 CT2
SW502

CU CR1 CR2
IG
P502

PE
SW501

P501

21 00 F4
F5

120 660
na5978a

TAM

24 0
24 0
24 0
20 20
20 20

112 Uniflair LE DX Cooling Unit Installation Manual


ID*V1922A, ID*V2022A, IU*V1922A, IU*V2022A—single power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving).

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• Condensate drain pump (P) • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD

20 20 20

R5
21 21 23

T-H VERSION
RSR1 RSR2
F4 RSF CC2 CC1
2.5A-’T’

51 52 50 R6 R8

143

142
471
121

481
21

51

23

50
52

J5-18DIN
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL2(10) IDL4(12) IDL6(14) IDL6(15) IDL8(16)

na5954b
CHGND(3) AC/DC(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13
P512
0 0 0

ELECTRICAL PANEL

970 960 P2 P2 P2
M5
M7

52 51
TA1 TA2 TA3
M2
M14

CPY
TR
M9

M12 M1
M6 M10 M11

P1 P1 P1
M3

50 23
M8

P510
P511
P509

21 00
P508
P512
P507

SW1
P506 FI2

21 00
P513
J5 ME IM8 IM4 IM5 IM6 IM1
P514 18 DIN P505

P504
F20

21 00
SW503

P503

KLO RSR1 RSR2


PE
SW502

RFF
24 660
P502
SW501 F9 CU CR1 CR2 CC1 CC2
IG
P501
PE
F4
24 0 F5

24 0
24 0 TAM

24 0
24 0
20 20
na5955b

20 20

Uniflair LE DX Cooling Unit Installation Manual 113


ID*V1922A, ID*V2022A, IU*V1922A, IU*V2022A—double power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving).

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• Condensate drain pump (P) • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
21 21 23

T-H VERSION
RSR1 RSR2
F4 RSF CC1 R15
2.5A-’T’

R15
N10
51 52 50

N10
R6 R8
R25

142
471
121

481
21

51

23

50
52

N20

R25
N20
J5-18DIN

IDHC2(1)

IDHC1(1)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL2(10) IDL4(12) IDL6(14) IDL8(16)

IDH2(2)

IDH1(2)

na5954a
CHGND(3) AC/DC(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13 J10 J12
P512
0 0 0

00 00 00

ELECTRICAL PANEL

992 982
F31 F32 RPE1 RPE2

991 981
M5
M7

RSF
M2

TR
M14

CPY

52 51
M9

M12 M1
M6 M10 M11

M3

M8

50 23
P510

CL1 CL2
P511
P509
F11 F12 FI2
P508

21 00
P512
P507

SW1
IM8 IM4 IM5 IM6 IM1
P506
P513
J5

21 00
P514 18 DIN P505

P504

SW503

SEL RS1 RS2 KLO RSR1 RSR2

21 00 PE
P503

RFF
F9 CT1 CT2
SW502

CU CR1 CR2 CC1 CC2


IG
P502

PE
SW501

24 660 P501

F4
F5

24 0
24 0 TAM

24 0
24 0
20 20
20 20
na5955a

114 Uniflair LE DX Cooling Unit Installation Manual


ID*V2422A, ID*V2922A, IU*V2422A, IU*V2922A, IX*V2322A, IXEV2622A—single power
supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving) if the type of heat rejection is available
for that model.

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• ON – OFF remote • ON – OFF remote • ON – OFF remote
• Condensate drain pump (P) • Fire–smoke (SFF) • Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
21 23

T-H VERSION
21

RSR1 RSR2
F4 RSF CC1 R15
2.5A-’T’

R15
N10
51 52 50

N10
R6 R8
R25

142
471
121

481
21

51

23

50
52

N20

R25
N20
J5-18DIN

IDHC2(1)

IDHC1(1)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL2(10) IDL4(12) IDL6(14) IDL8(16)

IDH2(2)

IDH1(2)

na5957a
CHGND(3) AC/DC(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13 J10 J12
P512
0 0 0

00 00 00

Uniflair LE DX Cooling Unit Installation Manual 115


ID*V2422A, ID*V2922A, IU*V2422A, IU*V2922A, IX*V2322A, IXEV2622A—double power
supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving) if the type of heat rejection is available
for that model.

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• ON – OFF remote • ON – OFF remote • ON – OFF remote
• Condensate drain pump (P) • Fire–smoke (SFF) • Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
21 23

T-H VERSION
21

RSR1 RSR2
F4 RSF CC1 R15
2.5A-’T’

R15
N10
51 52 50

N10
R6 R8
R25

142
471
121

481
21

51

23

50
52

N20

R25
N20
J5-18DIN

IDHC2(1)

IDHC1(1)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL2(10) IDL4(12) IDL6(14) IDL8(16)

IDH2(2)

IDH1(2)

na5957a
CHGND(3) AC/DC(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13 J10 J12
P512
0 0 0

00 00 00

ELECTRICAL PANEL
992 982
990 980
F31 F32 P2 P2 P2
960
M5

970
M7

TA1 TA2 TA3


M2
M14

CPY
RPE1

RPE2

TR
M9

M12 M1
M6 M10 M11

P1 P1 P1
52 51
M3

M8

P510
P511

52 51
P509

P508
P512
P507

50
SW1

23 P513

P514
J5
18 DIN
P506

P505
ME IM8 IM4 IM5 IM6 IM1 IM2

50 23
P504

SW503
F20

SEL
P503

RS1 RS2 RSR1 RSR2


PE CT1
SW502

21 00 P502
SW501
RFF
F9
CT2
CU CR1 CR2 CC1 CC2
P501
IG
PE
21 00 F4
F5

21 00
120 660
24 0
24 0
20 20
na6840a

20 20

116 Uniflair LE DX Cooling Unit Installation Manual


ID*V3822A, ID*V4022A, IU*V3822A, IU*V4022A, IX*V4022A—double power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving) if the type of heat rejection is available
for that model.

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• User • User • User
• ON – OFF remote • ON – OFF remote • ON – OFF remote
• Condensate drain pump (P) • Fire–smoke (SFF) • Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
21 23

T-H VERSION
21

RSR1 RSR2
F4 RSF CC1 R15
2.5A-’T’

R15
N10
51 52 50

N10
R6 R8
R25

142
471
121

481
21

51

23

50
52

N20

R25
N20
J5-18DIN

IDHC2(1)

IDHC1(1)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL2(10) IDL4(12) IDL6(14) IDL8(16)

IDH2(2)

IDH1(2)

na5957a
CHGND(3) AC/DC(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13 J10 J12
P512
0 0 0

00 00 00

ELECTRICAL PANEL

992 982
F31 F32 RPE1 RPE2

991 981
M5
M7

RSF
M2

TR
M14

CPY

52 51
M9

M12 M1
M6 M10 M11

M3

M8

50 23
P510

CL1 CL2
P511
P509
F11 F12 FI2
P508
P512

21 00
P507

SW1
IM8 IM4 IM5 IM6 IM1
P506
P513
J5
18 DIN P505

21 00
P514

P504

SW503

SEL RS1 RS2 KLO RC2 RSR1 RSR2


PE
21 00
P503

RFF
F9 CT1 CT2
SW502

CU CR1 CR2
IG
P502

PE
SW501

120
P501

660 F4
F5
CC1

24 0
24 0 TAM

24 0
24 0
20 20
20 20
na5956

Uniflair LE DX Cooling Unit Installation Manual 117


LD*V2422A, LD*V2522A, LD*V272A2, LD*V3822A—single power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving).

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• Condensate drain pump (P) • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
F4
4A-’T’ 21 21 23

T-H VERSION
RSF RSR1 RSR2 CC2 CC1
21

51 52 50 R6 R8
TEST1 TEST1 TEST1 TEST1 TEST1
9 6 7 5 8

121

142
471

481

143
27

51

23

50
52

J5-18DIN
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2) IDL4(12) IDL6(14) IDL7(15) IDL8(16)

na6139a
CHGND(3) AC/DC1(2) GND(5) SD–(1) IDCL1–4(1) IDCL5–8(5)
J9 J3 J13
P512
0 0 0

970 960 ELECTRICAL PANEL


52 51
FC1 FC2 P2 P2 P2

50 23
M5
M7

TA1 TA2 TA3


M2
M14

CPY
TR
M9

M12 M1
M6 M10 M11

P1 P1 P1

21 00
M3

M8

P510
P511
P509

21 00 P512
P508

P507

SW1

21 00
P506
P513
J5 ME IM8 IM4 IM5 IM6 IM1 IM2
P514 18 DIN P505

P504

SW503
F20

24 660 P503

SW502
PE
RSR1 RSR2
P502
RFF
F9 CU CR1 CR2 CC1 CC2
24 0 SW501

P501
IG PE
F4
F5
24 0
24 0
na6141a

TAM

24 0
24 0
20 20
20 20

118 Uniflair LE DX Cooling Unit Installation Manual


LD*V2422A, LD*V2522A, LD*V2722A, LD*V3822A—double power supply
NOTE: * may be A (air-cooled), W (water-cooled), or E (energy-saving).

Digital Configurable Inputs


Terminal Board 51 – 21 Terminal Board 52 – 21 Terminal Board 50 – 23
• Condensate drain pump (P) • Fire–smoke (SFF) • ON – OFF remote
• Tools (ATA–BTA–AUA–BUA)

INPUT DEVICE CONNECTIONS CONTROL BOARD


20 20 20

R5
21 21 23

T-H VERSION
RSR1 RSR2
F4 RSF CC1 CC2 R15
2.5A-’T’

R15
21

N10
51 52 50

N10
R6 R8
R25

142

142
TEST1 TEST1 TEST1 TEST1 TEST1

471

481
9 6 7 5 8
N20

121

R25
51

23

50
52

N20
IDL8(16)
IDL7(15)
J5-18DIN

IDL4(12)

IDL6(14)
IDL2(10)

IDHC2(1)

IDH2(2)

IDHC1(1)

IDH1(2)
AC(6) IDZC(7) IDZ1(1) IDZ2(2) 24V(3) SD+(2)
CHGND(3) AC/DC(2)

na5957a
GND(5) SD–(1)
J9 J3 IDCL1–4(1) IDCL5–8(5) J13 J10 J12
P512
0 0 0

ELECTRICAL PANEL
992 982
F31 F32 RPE1 RPE2
991 981
M5
M7

RSF
M2

TR
M14

970 960 CPY


M9

M12 M1
M6 M10 M11

M3

M8

52 51 P511
P510

P509
F11 F12 FI2 CL1 CL2

50 23
P508
P512
P507

SW1
IM8 IM4 IM5 IM6 IM1
P506

J5
21 00
P513

P514 18 DIN P505

P504

21 00
SW503

SEL RS1 RS2 KLO RSR1 RSR2


P503
PE
RFF
F9 CT1 CT2
SW502

CU CR1 CR2 CC1 CC2


IG
21 00
P502

PE
SW501

P501

F4

24 660 F5

24 0 TAM

24 0
24 0
20 20
na6141b

20 20

Uniflair LE DX Cooling Unit Installation Manual 119


Accessories

Humidifier

na5263a

Item Description
 Steam outlet
 Humidifier cylinder
 Water supply connection
 Water drain connection
 Water supply solenoid valve

Uniflair LE DX Cooling Unit Installation Manual 121


Supply water
The following table provides values for the feed water for medium-high level of conductibility of a humidifier with
immersed electrodes.

Limits
Description Units Minimum Maximum
Hydrogen ion activity pH - 7 8.5
Specific conductibility at 20°C σ R, 20°C μS/cm 350 1250
Total dissolved solids TDS mg/l * *
Residual fixed at 180°C R180 mg/l * *
Total hardness TH mg/l 100** 400
Temporary hardness mg/l 60*** 300
Iron + manganese mg/l Fe + Mn 0 0.2
Chlorides ppm Cl 0 30
Silica mg/l 0 20
Residual chloride mg/l 0 0.2
Calcium sulphate mg/l 0 100
Metallic impurities mg/l 0 0
Solvents, soaps, and lubricants mg/l 0 0

* Values dependent on the specific conductibility; in general: TDS @ 0.93 x s20; R180 @ 0.65 x s20
** Not lower than 200% of the chloride content in mg/l di Cl-
*** Not lower than 300% of the chloride content in mg/l di Cl-

The following table provides values for the feed water for medium-low level of conductibility of a humidifier with
immersed electrodes.

Limits
Description Units Minimum Maximum
Hydrogen ion activity pH - 7 8.5
Specific conductibility at 20°C σ R, 20°C μS/cm 125 350
Total dissolved solids TDS mg/l * *
Residual fixed at 180°C R180 mg/l * *
Total hardness TH mg/l 50** 250
Temporary hardness mg/l 30*** 150
Iron + manganese mg/l Fe + Mn 0 0.2
Chlorides ppm Cl 0 20
Silica mg/l 0 20
Residual chloride mg/l 0 0.2
Calcium sulphate mg/l 0 60
Metallic impurities mg/l 0 0
Solvents, soaps, and lubricants mg/l 0 0

* Values dependent on the specific conductibility; in general: TDS @ 0.93 x s20; R180 @ 0.65 x s20
** Not lower than 200% of the chloride content in mg/l di Cl-
*** Not lower than 300% of the chloride content in mg/l di Cl-

122 Uniflair LE DX Cooling Unit Installation Manual


Drainage line and water supply line connections
WARNING
HOT WATER HAZARD

• Use caution when servicing the humidifier. The water discharged from the humidifier is at
a very high temperature.
• Use a drainage tube designed to withstand temperatures of at least 100°C (212°F).
• Keep the drainage tube away from all electrical cables and refrigerant lines.

Failure to follow these instructions can result in death, serious injury, or


equipment damage.

NOTICE
COMPLIANCE REQUIREMENT

The installation must comply with local plumbing codes.

Failure to follow these instructions can result in equipment damage.

1. Connect the drainage tube of the unit to the collection tray of the humidifier.
2. Connect the humidifier drainage line to the building drains with a rubber or plastic tube that is resistant
to high temperatures (>100°C (212°F)) with an internal diameter of 32 mm (1.26 in.).
3. Connect the unit drainage tube to the building drains using a rubber or plastic tube with a 25-mm (1 in.)
internal diameter.
4. Use a trap on the external drainage tube in order to avoid unpleasant odors and to allow the condensate
pan to drain properly. Consult local building codes for drain requirements.
DRAIN

MINIMUM SLOPE
TRAP
2.5 cm PER 2.1 m
(1 in. PER 10 ft)
na4737b

5. Once the connections have been made, pour water into the condensate collection tray of the cooling
unit and the condensate collection tray of the humidifier until both traps are full.

Uniflair LE DX Cooling Unit Installation Manual 123


Condenser
OCC external condenser connections

All units

The following cables are recommended for the condenser connections:


Cable Color
Unit Type Cable
RS–5 RS+5 RS05
ITC Belden—15S7D or
AC Unit Blue White-Blue White-Orange
Belden—3107A
EC Unit ITC Belden 24S7D Blue White-Blue White-Orange

NOTE: See the wiring diagrams provided with the unit for single-phase condensing unit wiring.
D1+(2)

J5-18DIN
COM3
D0-(1)

J5-18DIN
P502
RS05 (GREEN)
RS-5 (BLACK)

RS05 (WHITE)
RS+5 (RED)

na5950a

RS-5 RS+5 RS05

OCC EC/AC SIGNAL


CONNECTION

EXAMPLE ELECTRICAL PANEL

F31 F32 RPE1 RPE2


SAS

M5
M7

M2

TR
M14

CPY
M9

M12 M1
M6 M10 M11

M3

M8

P510

CL1 CL2
P511
P509
F11 F12 FI
P508
P512
P507

SW1
IM8 IM4 IM5 IM6

OCC EC/AC
P506
P513
J5
P514 18 DIN P505

SIGNAL
P504
PE
U9
N9

SW503

SEL RS1 RS2 KLO RC2 RSR1 RSR2

CONNECTION
P503
PE
F9 CT1 CT2
SW502

CU CR1 CR2
IG
P502

PE
SW501

P501

F4
F5
na5951a

TAM

124 Uniflair LE DX Cooling Unit Installation Manual


Configuration
Dip switches located in the SW1 bank of switches on the condenser controller may need to be set for proper
unit configuration. The final resistor may also need to be set properly according to the number of fan speed
regulators controllers.

AC Fan Number of Controller SW1 Dip Switch Bank Final


Condenser Controllers Number 1 2 3 4 5 6 7 8 Resistor
OCC1701 1 x EMC110 N/A On (J6)
OCC2101 1 x EMC110 N/A On (J6)
OCC2401 1 x EMC110 N/A On (J6)
OCC2601 1 x EMC110 N/A On On (J6)
OCC3101 1 x EMC110 N/A On (J6)
OCC3301 1 x VST310 N/A On (J4)
OCC3901 1 x VST310 N/A On (J4)
OCC3502 1 x EMK210 N/A On (J1)
Off Off Off On Off On On
OCC4202 1 x EMK210 N/A On (J1)
OCC4702 1 x EMK210 N/A Off On (J1)
OCC5302 1 x EMK210 N/A On (J1)
OCC6202 1 x EMK210 N/A On (J1)
1 Off Off (J4)
OCC6702 2 x VST310
2 On On (J4)
1 Off Off (J4)
OCC7702 2 x VST310
2 On On (J4)

PWR
SB1 SW1 CPU RUN

1 2 3 4 5 6 7 8
FAIL

+12V +5V

M1 M2
CN6 CN4 A(+)
CPU RUN
OUT A(-)
TX_0
TX_1 REF
RX_0
RX_1
TK_1
SW1
TK_2

SW1

M1 M2

U V W PE L1 L2 L3
na6617c

J6
MODBUS COMMAND LINE

4 A(+) J6
ON
COM-0
3 B(-) PE L N OFF
ON
2 REF COM-0
1
POWER SUPPLY OFF
COM-0

FINAL RESISTOR

TK U1 U2 PE TK U1 U2 PE TK U1 U2 PE
na6841a

A1 A2 A3

Uniflair LE DX Cooling Unit Installation Manual 125


Low Temperature Kit
There are three low temperature kits available depending on the size of the cooling unit on which the kit is
installed:

• 21KI110CDZ: Low temperature kit 20–35 kW


• 21KI112CDZ: Low temperature kit 35–50 kW
• 21KI114CDZ: Low temperature kit 50–70 kW
The low temperature kits are pre-assembled and shipped together with the condenser.

Component identification

na6443a

Item Description Item Description


 Safety valve  Connection from compressor discharge
(by-pass)
 Check valve  Connection from condenser outlet
 By-pass (relief) valve  Connection to indoor unit
 Flooding valves

126 Uniflair LE DX Cooling Unit Installation Manual


Dimensions and weights

na6444a
B
C

Dimensions – mm (in.)
Version A B C Weight – kg (lb)
21KI110CDZ 550 (21.7) 720 (28.3) 570 (22.4) 32.7 (72.1)
21KI112CDZ 588 (23.1) 720 (28.3) 570 (22.4) 36.2 (79.8)
21KI114CDZ 588 (23.1) 720 (28.3) 570 (22.4) 39.0 (86.0)

Uniflair LE DX Cooling Unit Installation Manual 127


Installation
Make the field connections between the indoor and outdoor units.

Low Temperature Kit Version 21KI110CDZ 21KI112CDZ 21KI114CDZ


Connection from Compressor Discharge (By-Pass) –
mm (ODS) 16 22 28

Connection from Condenser Outlet – mm (ODS) 16 22 22


Connection to Indoor Unit – mm (ODS) 16 22 22

The following shows an example of field-supplied piping routing. Piping and piping supports are field-supplied.

FROM
COMPRESSOR

TO INDOOR UNIT

128 Uniflair LE DX Cooling Unit Installation Manual


Check and Bypass Valves
The check and bypass valves are installed on the condenser outlet connection or the low ambient temperature
kit if present.

Inventory
na6934a

Item Description Qty. Item Description Qty.


 Check valve 1  Pipe—ODS Ø22 mm 1
 By-pass (relief) valve 1  Pipe—ODS Ø22 mm 1
 Adaptor 1  Pipe—ODS Ø22 mm 1
 Joint weld 1  Pipe—ODS Ø16 mm 1
 T-joint 2  Pipe—ODS Ø16 mm 1
 Pipe adaptor— Ø22 mm to Ø16 mm
1
ODS

Uniflair LE DX Cooling Unit Installation Manual 129


Installation
NOTE: The numbers in the installation drawing coincide with the numbers in the component identification
drawing in “Inventory” on page 129.
na6938a

130 Uniflair LE DX Cooling Unit Installation Manual


Active Flow Controller (AFC)
The Active Flow Controller (AFC) maintains air pressure underneath a raised floor to a desired setpoint. The
AFC compensates for air pressure changes in an active and growing data center.

Set DIP switches


NOTICE
ELECTROSTATIC DISCHARGE HAZARD

Wear a wrist strap and ensure you are properly grounded before working on the unit.

Failure to follow these instructions can result in equipment damage.

SWITCH SWITCH
FRONT SENSING PORTS BANK 2 BANK 3
RESET
SWITCH
ON CTS ON CTS ON CTS

1 2 3 4 1 2 3 4 1 2 3 4
na4097a

SWITCH
BANK 1

1 2

na4009a

The following table defines the purpose of each DIP switch.

Uniflair LE DX Cooling Unit Installation Manual 131


Switch Bank 1
Switch 1 2 - - Setting Usage
UP UP - - Unterminated Set to Terminated when the sensor is
Position on one of the two ends of a MODBUS
DOWN DOWN - - Terminated circuit.
Note: “UP” switch position is farthest away from the circuit board.
Note:Both switches must be in the same position (either “up” or “down”).
Switch Bank 2
Switch 1 2 3 4 Setting Usage
Set to Off when cooling unit supply air
Normal differential pressure
Off - - - is on the same side of the aisle as the
reading
front sensing ports.
P Set to On when cooling unit return air
o Reversed differential
On - - - is on the same side of the aisle as the
s pressure reading
front sensing ports.
i
t - Off - - Baud - 9600 If building management system (BMS)
i - On - - Baud - 19200 is used, set to BMS baud rate.
o
n - - Off Off Parity - Even
- - Off On Parity - None If building management system (BMS)
- - On Off Parity - Odd is used, set to BMS parity.
- - On On Reserved
NOTE: The number of stop bits is 1.

Switch Bank 3
Upper 4 Address Bits Lower 4 Address Bits
1 2 3 4 1 2 3 4 Usage
If used in MODBUS slave mode, set to
an address that is otherwise unused
on the modbus circuit.
Bit 7 Bit 6 Bit 5 Bit 4 Bit 3 Bit 2 Bit 1 Bit 0
If used with a non-InRow system, set
the address to all zeroes to act as
MODBUS master (“Off” position).

132 Uniflair LE DX Cooling Unit Installation Manual


AFC connection
NOTE: Kinked, blocked, or damaged tubing will result in incorrect operation of the AFC unit.

1. Push the end of the negative tubing into the port on the rear of the AFC as shown. Be sure the tube is
firmly captured by the port fitting.
2. Push the end of the positive tubing into a port on the side of the AFC, as shown. Be sure the tube is
firmly captured by the port fitting.
3. Insert a plug into the other two ports. Be sure the ports are completely sealed.
NOTE: Failure to properly seat the tube and plug will result in incorrect operation.
NOTE: Leave the 18 m (60 ft) cable wrapped up and secure it in the corner near the power cables.

POSITIVE PLUGS

na6658a
TUBE

NEGATIVE
TUBE
4. Configure the dip switches. To configure the dip switches, see the wiring diagram.

See the unit wiring diagram for information about configuring the dip switches.

5. Route the negative tube to the base of the unit as shown.


na4102a

Uniflair LE DX Cooling Unit Installation Manual 133


Installing the sensors
WARNING
HAZARD TO EQUIPMENT OR PERSONNEL

Verify that the area behind the wall is free of electrical wires or piping before drilling holes
into the wall.

Failure to follow these instructions can result in death, serious injury, or equipment
damage.

1. Locate the mounting point for the positive sensor head on the wall, and route the tubing through the
bottom of the unit and underneath the floor tiles to the mounting point.
NOTE: Do not place the positive pressure sensor head under the raised floor where the airflow velocity
is high. For example, directly beneath the unit. The recommended position for the pressure sensor head
is 3–4 m (10–13 ft) away from the unit.

2. Fasten the mounting clamp to a raised floor post.


3. Ensure that excess tubing is carefully secured. Avoid sharp bends or kinks in the tubing.

SENSOR HEAD
CLAMPS ON RAISED
POST

The above-floor pressure sensor can be installed in the port located at the bottom-right corner of the Uniflair
unit.

1. Using a standard screwdriver, pry off the cover on the sensor port.
2. Route the tubing through the cooling unit, neatly coiling any excess tubing.
3. From inside the unit, attach the sensor head to the port, then fasten the fitting into the port from outside
the unit.
If the unit is not in the room that is to be cooled, the tubing can be installed using the wall mounting bracket
provided with the kit.

1. After determining an appropriate location for the sensor, drill a hole through the wall and mount the
sensor bracket.
2. Tubing can be installed behind the wall and through the hole, then attached to the sensor.
NOTE: Ensure that the wall-mounted sensor is installed away from direct airflow to ensure proper
pressurization detection.

134 Uniflair LE DX Cooling Unit Installation Manual


Fire and Smoke Sensors
DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

Turn off all power supplying this equipment before working on the equipment. All electrical
work must be performed by qualified personnel. Practice Lockout/Tagout procedures. Do
not wear jewelry when working with electrical equipment.

Failure to follow these instructions will result in death or serious injury.

Uniflair LE DX Cooling Unit Installation Manual 135


Inventory

na4633f

Item Description Quantity


 Smoke sensor 1
 Rubber grommet 2
 Phillips screws 4
 Washers 4
 M5 x 10 mm screws 4
 Fire sensor 1
 Metal installation bracket 1

136 Uniflair LE DX Cooling Unit Installation Manual


Installation
1. Remove any necessary unit MOUNTING BRACKET
paneling and/or filters to access
the bracket installation location. RUBBER GROMMETS ACCESSORY BASE
See
2. Secure the bracket to the proper WASHERS/
location with the provided SCREWS
screws.
a. Place rubber grommet
inside bracket holes.
b. Remove the head of the
sensor by gently twisting to
the left to separate the

na4628a
base.
c. Secure the base of the
sensor using the screws
and washers provided.
d. Screw the head of the
accessory back on.
ACCESSORY HEADS

Uniflair LE DX Cooling Unit Installation Manual 137


Installation locations

Downflow and under floor units

NOTE: The appearance of your cooling unit may differ: the illustration is an example.

M5 x 10 MM
SCREWS

na6271a

138 Uniflair LE DX Cooling Unit Installation Manual


Upflow units

NOTE: The appearance of your cooling unit may differ: the illustration is an example.

M5 x 10 MM
SCREWS

na6842a

Uniflair LE DX Cooling Unit Installation Manual 139


Wiring options—all units
SFF SFF

J5-18DIN J14
21
21
GND(1) 24V(6)
21
Q3
Q3
21
4

2
6

FIRE
Q4
3 1 2
Q1 4
1 52

25
3
Q1 4
Q2 4 6 6

Q2 4 6
5
4

5
6

2
SMOKE SMOKE OR FIRE SENSOR

3 1
52

Q4
4 6
52
5
na5959a

SMOKE AND FIRE SENSORS

Configuration
Path: Main > Configuration > Service > Unit
1. Turn on the power to the unit and wait for the touch screen to display.
2. Set Smoke Alarm Present to Yes.

140 Uniflair LE DX Cooling Unit Installation Manual


24-V Relay for External Smoke/Fire Sensors (RFF)

DANGER
HAZARD OF ELECTRIC SHOCK, EXPLOSION, OR ARC FLASH

Turn off all power supplying this equipment before working on the equipment. All electrical
work must be performed by qualified personnel. Practice Lockout/Tagout procedures. Do
not wear jewelry when working with electrical equipment.

Failure to follow these instructions will result in death or serious injury.

Inventory

na4491a
Item Description Quantity
 Relay socket 1
 24-V relay coil 1
 Terminal blocks 2

Installation location—all units


na5980a

INSTALLATION LOCATION

Uniflair LE DX Cooling Unit Installation Manual 141


Installation

See “Configurable Input Connections” on page 111 for terminal block connection information.

1. Identify the installation location in the electrical panel.


2. Attach the relay socket and terminal blocks to the DIN rail.

na4651a

3. Connect the wires to the labeled terminal blocks inside the electrical box designated for smoke-fire.
Wire routing may be needed on some units.

20
RFF 20
na4819a

52
26 52
06

24-V CONNECTION FOR EXTERNAL SYSTEM

4. Connect the customer/external wiring to terminal blocks 026 and 006.


NOTE: This requires an external 24-V signal (DC or AC).
Configuration

Path: Main > Configuration > Service > Unit


1. Turn on the power to the unit and wait for the touch screen to display.
2. Navigate to Main > Configuration > Service > Unit on the display interface.
3. Set Smoke Alarm Present to Yes.

142 Uniflair LE DX Cooling Unit Installation Manual


Condensate Drain Pump
The condensate drain pump is an optional accessory available with all Uniflair LE DX cooling units. The
condensate drain pump will be shipped separately with downflow units (ID*V models) and under floor units
(IX*V models). The pump is shipped with the components outlined in “Inventory” on this page for installation
with under floor units. In upflow units (IU*V models), the pump is shipped alone and has to be installed on site
below the unit (a floor stand is required if a raised floor is not used).

Inventory
na6439a

Item Description Quantity Item Description Quantity


 Condensate pump 1  Rivet 8
 Bottom support bracket 2  Serrated washer 4
 Top support bracket 3  Washer 4
 M6x110 hex screw 4

Uniflair LE DX Cooling Unit Installation Manual 143


Installation
The condensate pump can be installed inside the cooling unit or outside the cooling unit.

1. Attach the top support bracket, pump, and the bottom supply bracket together with the M6x100 hex
screws, serrated washers, and washers.

M6x110 HEX SCREW

SERRATED WASHER
WASHER

TOP SUPPORT
BRACKET

CONDENSATE PUMP

BOTTOM SUPPORT
BRACKET
na6440a

144 Uniflair LE DX Cooling Unit Installation Manual


2. If the condensate pump is installed inside the unit, attach the bottom support bracket to the frame of the
cooling unit with rivets. If the condensate pump is installed outside the unit, the installer has to ensure
proper anchoring of the pump.

na6441a

3. Route tubing from the condensate drain pan to the condensate pump and from the condensate pump to
outside of the unit.
na6442a

Configuration

Path: Main > Configuration > Service > Unit


1. Turn on the power to the unit and wait for the touch screen to display.
2. Navigate to Main > Configuration > Service > Unit on the display interface.
3. Set Cond. Drain Pump to Yes.

Uniflair LE DX Cooling Unit Installation Manual 145


Pressostatic Valve
Inventory

na6935a

Item Description Quantity


 Actuator 1
 Pipe with union 2
 Gasket 2
 2-way valve 1

146 Uniflair LE DX Cooling Unit Installation Manual


Installation
See the sheet included with the kit for detailed instructions for connecting the actuator to the 2-way
valve.

1. Connect the 2-way valve to the pipes with unions and the actuator to the 2-way valve.

GASKET

na6936a
GASKET

Uniflair LE DX Cooling Unit Installation Manual 147


2. Connect the pressostatic valve to the water outlet connection of the unit.

WATER OUTLET

na6933a
3. Wire the valve-side connector as shown below and connect it to the cable from the electrical panel.
FROM
FROM
ELECTRICAL
PRESSOSTATIC
PANEL
VALVE

BLACK WIRE

1
2

RED WIRE ORANGE WIRE


4

3
na6939a

WHITE WIRE

Add AP9520TH sensor info from the HXCV manual here.

148 Uniflair LE DX Cooling Unit Installation Manual


Worldwide Customer Support
Customer support for this or any other product is available at no charge in any of the following ways:
• Visit the Schneider Electric Web site to access documents in the Schneider Electric Knowledge Base
and to submit customer support requests.
– www.schneider-electric.com (Corporate Headquarters)
Connect to localized Schneider Electric Web sites for specific countries, each of which provides
customer support information.
– www.schneider-electric.com/support/
Global support searching Schneider Electric Knowledge Base and using e-support.
• Contact the Schneider Electric Customer Support Center by telephone or e-mail.
– Local, country-specific centers: go to www.schneider-electric.com > Support > Operations
around the world for contact information.

For information on how to obtain local customer support, contact the representative or other distributors
from whom you purchased your product.

As standards, specifications, and designs change from time to time, please ask for confirmation of the information given in this publication.
© 2017–2020 Schneider Electric. All Rights Reserved.
Uniflair and the Schneider Electric logo are trademarks owned by Schneider Electric Industries SAS S.A.S., or its affiliated companies. All other
trademarks are the property of their respective owners.

990-5754C-001
4/2020
06MM0320@00B0130

You might also like