Professional Documents
Culture Documents
Top Lock Flange Nut, IFI 100/107, Grade F, Zinc Plated: Page 1 of 2 REV-05 Date: March 9, 2016 TPLK - FLG.GRF.Z
Top Lock Flange Nut, IFI 100/107, Grade F, Zinc Plated: Page 1 of 2 REV-05 Date: March 9, 2016 TPLK - FLG.GRF.Z
F H B L K J M R
Flange
Width Across Flange Bearing Flange Wrenching Counter-sink
Size Height Top
Flats Diameter Diameter Thickness Height Diameter
Radius
Max. Min. Max. Max. Min. Min. Min. Max. Max.
#8 .344 .334 .203 .469 - 0.02 0.13 .194 -
#10 .375 .365 .219 .500 - 0.03 0.13 .220 -
1/4 .4385 .428 .300 .560 .484 0.04 0.14 .295 0.01
5/16 .5020 .489 .365 .680 .602 0.05 0.17 .357 0.01
3/8 .5645 .551 .425 .810 .730 0.06 0.20 .420 0.02
7/16 .6895 .675 .495 .930 .846 0.07 0.23 .482 0.02
1/2 .7520 .736 .555 1.070 .982 0.08 0.26 .560 0.02
9/16 .8770 .861 .625 1.190 1.101 0.09 0.29 .622 0.03
5/8 .9395 .922 .690 1.330 1.230 0.10 0.32 .685 0.03
3/4 1.1270 1.088 .825 1.585 1.472 0.11 0.38 .810 0.03
7/8 1.312 1.269 .790 1.750 1.574 0.12 0.41 .945 -
1 1.500 1.450 .900 2.060 1.970 0.12 0.55 1.080 -
Specification Requirements:
• Marking: 3 evenly spaced marks on either chamfered top face, or the top
of the flange face, or if made from bar stock. Also the
Manufacturer ID (this may be one of the 3 grade markings)
• Material Test Reports: The MTR must have documented lot traceability, dimensional
results, full chemical test results and full mechanical test
results to the specification(s) above. In addition, the MTR
shall be in full compliance with Fastenal’s MTR
Requirements.