External Alarm Validation and Rectification

Acceptance Date 8-09-2020

Project Name AOP2020
Site ID 18KKP044
Site Name JLCILIK_RIWUT_KKP_PL
System Key

This page will explain how this validation external alarm implementation in the field
accepted by both party

Review Status
Alarm External alarm (shall be Remarks
Position confirmed with NOC to OK NOT
OK
# monitor the result of
alarm test)

1 Main Power Failure V When 2 or all 3 phase fails in 3 phase scenario

2 Rectifier Module Failure V When rectifier module fails due to module internal failure but NOT due to
main power
3 High Temperature Alarm V High temperature inside the cabinet
4 PLVD Disconnect (RRUs off) V When RRUs (i.e. Non-Priority Loads) are disconnected due to lack of battery
backup after 4 hours, typically PLVD/LVD1 is set to 46V. Then PLVD/LVD1
Reconnect level is set 49.5V or hysteresis is set to 3.5V.
5 Surge Arrester Failure V When any of the 3 Surge arresters fail
6 Load Breaker Trip V When any DC load breaker trips (i.e. telecom equipment power off) or
battery breaker trips
7 Door Open V When door is opened
8 Aviation Light Failure When Aviation light fails
9 Fire Smoke Heat Alarm Only for Indoor Shelter
10 Gensets Working If Applicable
11 Gensets Fails If Applicable
12 ATS Fail If Applicable
13 Low Fuel If Applicable
14
Site ID 18KKP044
Site Name JLCILIK_RIWUT_KKP_PL

Acceptance of Device Alarm Image

 Before After Before After

Main Power Failure Main Power Failure Alarm Main Power Alarm Main Power
Failure Failure

Submit Approver
VENDOR MS NE ACCEPTANCE INDOSAT

RECTI MODUL FAIL RECTI MODUL FAIL Alarm Rectifier Alarm Rectifier
Module failure Module failure

Name : Name : Name :

Date : Date : Date :

TEMPERATURE HIGH TEMPERATURE HIGH Alarm High Alarm High

Temperature Temperature

PLVD Disconnect PLVD Disconnect Alarm PLVD Alarm PLVD Disconnect

Disconnect

ARRESTER FAIL ARRESTER FAIL Alarm Surge Arrester Alarm Surge Arrester
Failure Failure

BATTERY FAIL BATTERY FAIL Alarm Load Breaker Alarm Load Breaker