Professional Documents
Culture Documents
Plumbing Code Coaching
Plumbing Code Coaching
Plumbing Code Coaching
1. Min size of vertical waste pipe by code for sink having 2 inches - trap not
2 inch diameter trap is larger than pipe it
is connected
6. Any joint obtained by joining metal parts not lower Brazed Joint (449
than melting point of parts to be joined degree)
10. A 2" x 4" wood wall stud is: 1 1/2 and 3 1/2"
wide
11. What tube is made of plastic material, colored black Polybutylene Pipe
and cross sectional shape is usually oval? Denoted (PB)
with its Outside diameter
1 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
12. When cleanouts are required by code in piping in- Must be extend-
stalled under a floor slab they: ed outside of the
building
13. According to code ___ joints may be used where Swing or Expain-
neccesary to provide expansion and contraction of sion Joint
the pipe and must be accesible
15. Water pipes exceeding ___ content of 8 shall be pro- Lead Content 8%
hibited on potable piping systems
17. A gas regulator (gas valve) control gas flow to A pilot tube and
burner tube
18. Two designs of water heater tank with regards to Top-fed and Bot-
where the cold water enters are: ton-fed
20. A 2- inch vent pipe is installed to provide air circula- must be in-
tion for a chemical waste system. According to code, stalled indepen-
the vent pipe must be: dently through
roof (no chemical
waste shall inter-
sect vents for oth-
er services)
22. What color code will be painted on Medical gas cop- Yellow markings
per pipe tube to indicate this pipe is medical gas?
23. A single family house connected to public sewer may Fireplace ashes
discharge all but one substance through its drainage (unlawful for any
system except person to de-
posit ashes, cin-
ders and rags
to any public
drainage)
24. Which of the following does not belong to sump Hinged covers
pump system?
26. What is the maximum depth of trench for sub- 2' - 1"
surface drain where the soil has satisfactory absorp-
tion
27. The PRC adopted the plumbing law known as R.A 1378
28. Except for repairs and connections to existing lines Cement mortar
constructed on such joints ___ are prohibited on new joints
construction
30. What is the maximum distance as where supports for at every storey
vertical cast iron pipe are______
3 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
subjected to the Water Code of the Philippines. What
PD is it?
33. For expanding ends of a lead pipe, what tool is to be Turn Pin
used?
34. The recovery rate of a water heater is also referred to Gallons per hour
as: (GPH)
38. What is the most common plumbing fixture wherein Water Closet
back siphonage usually occurs?
40. One important concern when installing an electric Ensuring all de-
water is: vices and controls
can be readily ac-
cessed
42. A saw used to productively cut threadded rod is: Portable Band
Saw
43. Medical gas piping is most often joined by: Silver Braze
4 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
44. The safety method to ignite a torch used for soldering Striker
is a:
46. The most common voltage supply to residential type 240 volts
is:
48. What do you call the sum of the qoutients of individ- Running rume
ual fixtures running full flow
51. What tyoe of surface must plumbing fixtured should Concealed fouling
not have? surfaces
5 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
52. A tankless water heater is: Available in gas
and electric
53. What kind of pipe is remarkably suited to soil, waste, Asbestos pipe
ventilation pipes?
54. According to code, pipe fittings that ___ shall NOT be Have abnormal
used in sanitary drainge plumbing systems: flow obstruc-
tion(no fitting that
obstructs flow
shall be used)
56. According to cide maximum height above the trap for 0.8 nor less than
domestic washer standoipe receptor is 0.45m
57. Minimum size of house sewer that will NOT carry 4"
human excrement installed underground?
58. Type of union installed when using copper pipe to Dielectric Union
connect to a water heater is
62. How many threads per inch does a cleanout having 8 TPI
79mm
63. Contamination
6 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
Which impairs quality of potable water through poi-
soning or spread of illneses
66. A joint made by firmly packing oakum filled with Cast iron, bell and
molten lead to a depth of not less than 1" is used with spigot soil pipe
67. ____ type of water that undergoes process where Purified Water
pollutants were removed of rendered harmless
68. Pipes must be air tight, gas tight and water tight to Connections
achieve good plumbing systems:
73. Regardless of type of water heater, all energy sources Drain the water
must be turned off before attempting to: heater
75. A storm drain is defined as the portion of the storm Surface run-off
drainge that receives ---
7 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
76. Minimumsize of a soil stack 3"
77. Wht will prevent the oassage of odor, gases and ver- P-Trap
min from the common sewer into the drainage system
within the building
78. Which is not considered a material for rainwater ABS (Not for suit-
downspout? able for exterior
chapter 11)
79. All buildings intended for human habitation accord- Have an ade-
ing to code must: quate supply of
potable running
water (Principle 2)
80. Fixture unit equivalents not commonly listed in unit Discharge capaci-
of codes must be based on ty of fixture
81. When a solar water heater panel or collector is locat- a pump is required
ed away from storage tank, ___ the water through the to circulate
system
85. A vent pipe horizontally to avoid to pass through a 6 inches above the
window, according to code the pipe must be floor level rim of
the sink
86. Pipe trench seeper than and parallel to footing must 45 degrees there-
be placed at n angle of pressure from the base of from (chapter 3)
structure
8 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
88. Sleeves shall be provided to protect all piping Concrete and ma-
through___ and __ walls sonry
92. A ____ valve is one way to control flow installed in a Backwater valve
drainage system
93. A branch is any part of piping system other than main stack
riser or---
96. The term liquid waste as defined by the code is dis- Bed Pan wash-
charged into plumbing system except: er (machine spray
that cleans human
waste)
97. The hot water demand of each fixture are added to- Total demand of
gether to arrive at the: the system
98. The code specifies that vertically installed piping Carry the weight
must be secured at sufficiently close intervals to: of the pipe and its
contents
Horizontal piping
shall be supported
to prevent sagging
100. In threadding pipes, you'll use the die carrying part of Stock
threading. What is this called?
101. A schedule 40 plastic pipe has nominal size of 4" that Every 4 ft.
runs horizontal at 20ft. What is the max. distance of
the support?
103. What is the level in a fixture at which water begins to Flood Level
over flow?
104. Two common bit designs for a jackhammer are Chisel and point
105. What is the minimum distacpnce above the floor from 6 inches
relief line from temperature and pressure relief valve
on water heater tank be installed?
106. On some gas water heater, a pilot flame sensing de- Thermocouple
vice known as ___ contribute to water heater's safe
operation
107. What do you call the vertical vent pipe to provide Vent Stack
circulation of air to and from any part of drainage
system
110. Ammonification
10 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
When a ic bacteria converts urea to ammonia, it is
called a
111. Of the following materials, one approved by code to Brass (screws etc)
secure water closet to floor must be
112. Any pipe installed not more than 45 deg within verti- Vertical pipe
cal line
116. Code requires drainage fittings have threads that are Grade - Allows
tapped that allow for grade or pitch
119. ___ be installed in cold water piping near a water Isolation Valve
heater
121. A valve used to control 2 or more opening is a ___ Full way gate
gate valve valve
122.
11 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
According to code, the piping sanitary drainge sys- pipes installed to
tem does not include convey waste from
area drains (rain
water)
130. Gas piping configuration to prevent debris and mois- Drip Leg
ture
131. Code requires all piping installed in corrosive type Protected proper-
material must be ly / approved man-
ner
12 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
135. Water purification is a method that removes one or Boiling
more materials that make the water unsuitable for
drinking use. Which is not a method of purification
138. The ladder required by an inspector so the make a The plumbing con-
final inspection must purchased by tractor or permit
holder
139. Which of the ff fixture may not be directly connected Drinking Fountain
to a drainage system
141. Large commercial gas water heaters use ___ that Differ from
residential styles
142. Zero gauge pressure indicates the system that 14.7 pounds per
square inch (29.9
inches of mercury)
144. Term used to drain two or more dixtures to a single Combination drain
trap
145. Cleanouts on seal of the trap are prohibited on Stall shower traps
13 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
Operates with 480
volts and uses
heating elements
150. Plumbing fixtures shall have smooth, nom absorbent Primciple No. 7
material
151. The label on the exterior of water heater is also known Boiler Plate
as
152. A 4 inch main stack installed parallel to 6 inch waste 4 inch or which is
stack in a 32 storey. What size of yoke vent? smaller
153. The vertical leg of round inlet and outlet fitting shall 104.6
not be less than the connecting pipe nor less than..
155. The common lavatory is permitted by the code side Approved double
by side with common vent provided that it is connect- fitting
ed to
158. What is the pipe carrying potable water from water Building supply
meter to any point of bulding
159. The following must not used in drainage system A straight tee
14 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
Apartment build-
ings with up to 100
dwelling units
161. The difference between incoming hot and outgoing Temperature rise
cold is called
164. Minimu trap diameter than floor drain must have 51mm
165. A tank located above or integral with water closet Flush tank
166. Piping system that receives discharge other than Waste Drainage
those from water closet system
167. If floor draim is used for storing food or cold storage, Indirect waste /
the drain must be connected to a used for those with
food etc
168. Which should not be considered when choosing ma- Materials in so-
terial drainage installation? lution and sus-
pension within the
waste
169. Of the following factors, the one that is NOT required Type of material
for determining size of the drainage pipe
170. What water supply pipe offers excellent resistance to Asbestos cement
destructive elements and electrolyte action or tuber- (no rusting)
culation
15 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
172. Material best suited as strainer in water reservoir Brass
174. Does not constitute part of water supply system Pipe strap
177. A bent does not carry liquid or water borne Dry vent
183. Drain pipes manufactured with toxic components are Gray, orange and
colored brown
187. Two element with non simultaneous water heater Only one element
means is heating at a time
16 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
189. To connect a 3 inch vertical stack to a 4 inch horizon- 4 x 4 x 3 inch com-
tal drainage lime, the acceptable fitting bination
190. Cold water enters the top of water heater is funneled Dip tube
through a
197. What will be the basis in the design of water pip- Minimum pres-
ing system in localities where water is fluctuating all sure available
throughout the day
199. A gas water heater design in which heater is installed Direct vented
within interior walls
200. Minimum plumbing facilities for night club Lavatory 1:75 per-
sons
202. The cover of septic tank shall be at.east __ above the 50.8 mm
back opening
203.
17 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
Water heater may be installed in residential garage 18 inches above
with assembly at least floor
205. A laundry pipe was tilted at an angle about 10 degree The trap is not set
toward the drain, the inspected wouldturn it down level to its water
because seal
207. The boiling point of water is a point a which 212 deg F, water
turns liquid to va-
por
208. After how many days the plumbing permit expire be- 1 year
come null and void
18 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
215. Assume the flow from a pump ejector in a building is 132 or times
66 gpm. This would add a total of __ 2, Pump ejectors
and air condition-
ing
218. Fittings used within drainage system must be having smooth in-
terior water way
221. The vertical vent that is the continuation of the drain Continuos vent
223. The one of the most governances that involves three Air
basic neccesities such as __ , water and food
227. Polyethylene pipes is colored back and is used for 3/4 inch to 2 inch-
cold water and sprinklers. Comes in sizes of es or look ASTM
2239
228. Suppose the date of the code you are using just Work installed be-
become effective today, existing plumbing system as: fore effective date
of the code
19 / 21
Plumbing Code - Coaching
Study online at https://quizlet.com/_br89ld
229. Drainage system is sized by The maximum fix-
ture unit load
230. Some gas water heater use manual ignition pilot use electronic ig-
flame, some nitin devices
235. Bell and spigot cast iron pipe joint between cast iron Molded rubber
pipe what is the approved joint coupling joints
237. Best water heating system for both lav and shower Multi point
240. What is the portio of rainfall that runs on the surface Surface water
of the ground
242. Of the four Master Plumber exam, which is originally Practical problems
slit into 2
246. Why is that its not a good practice to used gatevalve It will fail to close
in law sprinkler tightly
248. No ___ or leeching well shall be installed where the Seepage pit
percolation rate is less than 2.54cm fall into the test
holes in 30 mins
249. The piping and equipment between stret gas main Service Piping
and gas piping system inlet, which is installed by and
is used under the control and maintenance serving
gas supplier, is listed in the code as:
21 / 21