Professional Documents
Culture Documents
Calculationof The RC Pile From Jianhua
Calculationof The RC Pile From Jianhua
Calculation Engineer:
Director:
List of Figures
Figure 1: Column section ......................................................................................................................................4
1. General Information
This report is calculated using SPColumn v6.00 based on American Standard (ACI 318-14)
2. Material Properties
2.1. Concrete
Type Standard
f'c (Concrete Compressive Strength) 35 MPa
Ec (Modulus Elasticity) 27805.6 MPa
fc (Maximum Stress) 29.75 MPa
εu (Ultimate Strain) 0.003 mm/mm
β1 (Beta) 0.796192
2.2. Steel
Type Standard
fy (Tensile Strength, Yield) 420 MPa
Es (Modulus Elasticity) 200000 MPa
εyt (Compression-Controll Stain Limit) 0.0021 mm/mm
3. Section
3.1. Shape and Properties
Type Rectangular
Width 500 mm
Depth 500 mm
Ag (Total Area of Pile) 250000 mm2
Ix (Inersia at x absis) 5.20833e+009 mm4
Iy (Inersia at y absis) 5.20833e+009 mm4
rx 144.338 mm
ry 144.338 mm
Xo 0 mm
Yo 0 mm
3.2. Section Figure
4. Reinforcement
4.1. Bar Set: ASTM 615M
Bar Diameter Area Bar Diameter Area Bar Diameter Area
mm mm2 mm mm2 mm mm2
#10 9.50 71.00 #13 12.70 129.00 #16 15.90 199.00
#19 19.10 284.00 #22 22.20 387.00 #25 25.40 510.00
#29 28.70 645.00 #32 32.30 819.00 #36 35.80 1006.00
#43 43.00 1452.00 #57 57.30 2581.00
4.3. Arrangement
Pattern All sides equal
Bar layout Rectangular
Cover to Transverse bars
Clear cover 40 mm
Bars 16 #25
P ( kN)
12000
(Pmax) (Pmax)
3000 kN 1
150 kNm
-800 800
M (45°) ( k N m)
(Pmin) (Pmin)
-4000
According to the result of diagram Mn-Pn Above, the applied load P=3000 kN and
Moment = 150 kNm still located inside the diagram which is mean that the capacity of pile
on this calculation are propered and accepted to used.