Professional Documents
Culture Documents
Test 2 SEM 1 NOV 2022
Test 2 SEM 1 NOV 2022
Test 2 SEM 1 NOV 2022
MANAGEMENT
SEMESTER I 2022
1
DATE: Mon, 26th , Sep, 2022 TIME: 1 2 hours
Instructions:
- This paper consists of two sections A and B. Answer All questions in this paper
- All answers should be written on the answer sheet provided.
- Non-programmable scientific Calculators may be used.
- Mobile phones are NOT allowed in the examination room.
SECTION A:
Answer all questions in this section
5. A train starts from rest and accelerates uniformly, at 1.5 ms−2 until it attains a speed
of 30 ms−1 . Find the time taken (01 mark)
A. 45 seconds
B. 28.5 seconds
C. 1 second
D. 20 seconds
6. A straight line through the origin of a velocity time graph shows that the; (01
mark)
A. Motion is a retardation
B. Velocity is uniform
C. The acceleration is uniform
D. Distance is increasing uniformly
7. The area between a velocity-time graph for a moving body represents; (01 mark)
A. distance
B. acceleration
C. momentum
D. velocity
8. The most suitable instrument for measuring internal diameter of a bicycle spoke is;
(01 mark)
A. meter rule
B. micrometer screw gauge
C. vernier caliper
D. measuring cylinder
10. The most suitable instrument for measuring the length of a football field is? (01
mark)
SECTION B
Answer all questions in this section
11. (a) Distinguish between Uniform velocity and uniform acceleration (02
marks)
(b) Sketch a displacement-time graph for a uniformly accelerated body (01
mark)
(c) State the three (3) equations for uniformly accelerated motion (03 marks)
(d) Define instantaneous speed and average velocity (02 marks)
−2
(e) A cyclist starts from rest and accelerate uniformly at 1ms for 20 seconds.
Then he maintains the maximum speed for 1 minute and finally decelerates
to rest uniformly for 10 seconds.
(f) Draw a velocity-time graph for the body (3 marks)
(g) Calculate the total distance travelled by the cyclist (3 marks)
Page 2
12. (a) Distinguish between fundamental and derived quantities and give two ex-
amples in each (04
marks)
(b) The figure below shows a vernier caliper used to measure the breadth of a
metre rule in cm. write down its readings (02 marks)
(c) The sleeve reading of a micrometer screw gauge is 15.50mm. Its thimble
reading is 0.12mm.
(d) What is its final reading? (02 marks)
(e) Convert the final reading into meters (02 marks)
(f) Distinguish between absolute and relative errors as used in measurement
of physical quantities (01 marks)
. . . END . . .
Page 3