Professional Documents
Culture Documents
PMDG Boeing 737900 Startup Procedure
PMDG Boeing 737900 Startup Procedure
Jonathan Beckett
https://www.youtube.com/c/JonathanBeckett
https://linktr.ee/jonbeckett
This procedure is based on the aircraft being in the default “Cold and Dark” panel state -
which can be configured through the FMC (MENU, PMDG SETUP, START STATE)
Pre-Flight
Overhead (CTRL+6)
FMC (CTRL+3)
● Connect Ground Power (MENU, FS OPTIONS, GROUND SERVICES, CONNECT)
Overhead (CTRL+6)
Page 1 of 5
Microsoft Flight Simulator PMDG Boeing 737-900 Startup Procedure
Overhead (CTRL+7)
Overhead (CTRL+6)
FMC (CTRL+3)
● Prepare flight plan (Route, Departure, Destination, Fuel, Performance Data)
● Check for discontinuities and resolve them
MCP (CTRL+1)
Instrument Panel
● Set Barometric Pressure (shortcut - press B)
Overhead (CTRL+6)
Page 2 of 5
Microsoft Flight Simulator PMDG Boeing 737-900 Startup Procedure
FMC (CTRL+3)
● Disconnect Ground Power (MENU, FS OPTIONS, GROUND SERVICES,
CONNECT)
● Remove Chocks (MENU, FS OPTIONS, GROUND SERVICES, REMOVE CHOCKS)
Overhead (CTRL+6)
Pushback
Plan and perform pushback (if required) - in the real world engine start happens during
pushback.
Page 3 of 5
Microsoft Flight Simulator PMDG Boeing 737-900 Startup Procedure
Engine Start
Overhead (CTRL+6)
Overhead (CTRL+6)
Overhead (CTRL+6)
Page 4 of 5
Microsoft Flight Simulator PMDG Boeing 737-900 Startup Procedure
Taxi
Cockpit (F)
While Taxiing…
Lined up on Runway…
Overhead (CTRL+6)
Eyebrow Panel
● POSITION LIGHTS to STROBE (up)
● LANDING LIGHTS to ON (down)
Take-Off
● After lined up and cleared for takeoff, wheel brakes off, press TOGA
● After positive rate of climb, GEAR LEVER to UP
● When speed approaches flap limit, FLAPS UP
● After gear travelled, GEAR LEVER to OFF
Climb
Page 5 of 5