Professional Documents
Culture Documents
Volvo C70!06!2006wiring Diagram
Volvo C70!06!2006wiring Diagram
Volvo C70!06!2006wiring Diagram
VOLVO
2006
This is the cut pages sample. Download all 243 page(s) at: ManualPlace.com
Vehicles with SRS (Airbag)/SIPS bag/
IC (Inflatable Curtain)
Warning!
Extra caution must be exercised when working on vehicles equipped with SRS/SIPS bag/IC
in order to avoid:
1. Personal injuries when performing repair work.
2. Damage or malfunction of the SRS/SIPS bag/IC system.
Work involving the SRS/SIPS bag/IC systems or other components in the vehicle that may
affect the SRS/SIPS bag/IC systems must always be performed by an authorized Volvo
workshop.
In case of doubt, consult the SRS and SIPS bag/IC service manual.
General recommendations
• Be especially careful when working on or around SRS, SIPS, and IC components.
• Make sure that no wires are pinched, frayed, or pierced.
• Never install accessories by the sensors.
• Where applicable, work on the steering wheel, steering shaft, or steering gear must be done
in accordance with the methods in the SRS section of VIDA.
• Certain components of the aforementioned systems must be grounded while working. Read
the appropriate sections in VIDA.
• Install no accessories in the areas between the A and B posts, the B and C posts, and the C
and D posts.
Test terminal
Data link connector in the passenger compartment.
Volvo models are sold in versions adapted for different markets. These
adaptations depend on factors such as legal requirements, taxation, and
market demands.
This manual may therefore include illustrations and text that do not apply to
the vehicles in your country.
Group 37 Wiring and fuses Power driver’s seat with memory function, RHD ...... 124
Diagnostics system...................................................... 87 Power passenger seat with memory function, LHD ... 125
12V outlet .................................................................... 88 Power passenger seat with memory function, RHD .. 126
Tow hitch cable harness, 4-pin .................................... 89 Power driver’s seat, LHD ........................................... 127
Tow hitch cable harness, 7-pin .................................... 90 Power driver’s seat, RHD........................................... 128
Tow hitch cable harness, 13-pin ................................. 91 Power passenger seat, LHD ...................................... 129
Power passenger seat, RHD ..................................... 130
Heated seats.............................................................. 131
Group 38 Instruments
Seat belt reminder ....................................................... 92
Driver information module............................................ 93
Group 87 Climate control system
Climate control system, 4-cyl. 1:2 .............................. 132
Climate control system, 5-cyl 1:2 ............................... 134
Group 39 Other Climate control system 5-cyl. 2.4l diesel 1:2.............. 136
Low level audio 1:2 .................................................... 94 Climate control system PTC element ....................... 138
Audio 1:2 ................................................................... 96 Parking heater, auxiliary heater ................................. 139
Cellular phone 1:2 ...................................................... 98 Relay, electric engine heater ..................................... 140
Turn by Turn navigation, low level audio ................. 100 Electric engine heater, FlexiFuel................................ 141
Turn by Turn navigation, Audio ................................ 101
Universal handsfree, low level audio ....................... 102
Handsfree Universal ................................................ 103
Group 88 Internal equipment
Handsfree Max with Adapter ................................... 104 Supplemental Restraint System Module (SRS) 1:2 ... 142
Handsfree Max ........................................................ 105 Auto-dimming rearview mirror .................................. 144
Multimedia & Traffic information .............................. 106
Connectors............................................... 145
Group 43 Transmission
Automatic transmission AW55-51.............................. 107 Branching points .....................................170
Transmission M66 ..................................................... 108
Cable harness routing in vehicle
Group 59 Brake system Engine harness 4-cyl. 1.8 ........................................... 180
Brake control system ................................................. 109 Engine harness 5-cyl. 2.4l........................................... 180
Brake control system & STC...................................... 110 Engine harness 5-cyl. 2.5l Turbo ................................ 181
Brake control system & DSTC ................................... 111 Engine harness 5-cyl. 2.4l diesel ................................ 181
Engine compartment harness, 4-cyl. ..........................182
Group 64 Steering Engine compartment harness, 5-cyl. .........................182
Dashboard harness, LHD ........................................... 183
Electronic power steering .......................................... 112
Dashboard harness, RHD........................................... 183
Floor harness C70 LHD .............................................. 184
Group 83 Doors and openings Floor harness C70 RHD.............................................. 185
Central locking ........................................................... 113 Tunnel harness C70 ...................................................186
Central locking, trunk lid/tailgate................................ 114 Driver’s door harness C70 ..........................................187
Central locking, fuel filler flap..................................... 115 Driver’s door harness, addition C70............................187
Central locking, storage compartment ....................... 116 Passenger door harness C70 .....................................188
Signal receiver, remote-control, central locking......... 117 Passenger door harness, addition C70.......................188
Power windows.......................................................... 118 Harness, rear side panel, right C70 ............................189
Power roof ................................................................. 119 Harness, rear side panel, left C70 .............................. 189
Trunk lid harness, C70................................................190
Group 84 Exterior decorative elements, etc.
Power door mirrors .................................................... 120 Component illustrations ..........................191
Heated door mirrors................................................... 121
Heated rear window................................................... 122 Index 1:2 ....................................................236
Group 85 Interior equipment List of components 1:5 ............................238
Power driver’s seat with memory function, LHD ...... 123
The first part is a type number that describes the This manual contains a section with a list of branch-
type of component in question, e.g. 3/xx. ing points. This list shows all the components that
are connected to each branching point.
The second part of the designation is a serial num-
ber, e.g. x/2. The location of the branching points is shown in the
"Cable harness routing in vehicle" section.
Together, this constitutes a component designation,
e.g. 3/2. C. Connectors
Connectors provide a bridge between two cable har-
At the end of the manual is a list of components, nesses and are described in the "Connectors" sec-
where, with the help of the component designation, tion.
you can read off the name of the component, e.g.,
3/2 = light switch.
D. Electrical distribution
List of type numbers Operation of the fuses and relays is shown in the
"Electrical distribution" section.
The list shows which type of component that respec-
tive type numbers refer to, e.g., 3/x = switch, 6/x =
electric motor, etc.
E. Data communication
Today’s cars contain CAN and MOST networks that
1 Battery transfer information. Connections to these networks
2 Relay are not shown in their entirety in the respective wir-
3 Switch ing diagram. Complete information on CAN and
4 Control module MOST communication is found in the section "Con-
5 Driver information module trol modules".
6 Electric motor
7 Sensor F. Abbreviations
8 Actuator A number of different abbreviations are used in the
9 Heating element manual. These are explained in the section "Abbre-
10 Light viations".
11 Fuse
15 Electrical distribution rail/box G. Component location
16 Audio
17 Service/diagnostics There is a section at the end of the manual in which
18 Contact reel the appearance and location of components is
19 Meter described in numerical order.
20 Ignition component/shunt
27 Optics
31 Ground connection
63 Branching point
64 Connector
List of symbols
A E C F B D
1 1
= Ground connection via
LIN F4 F18 wiring
CAN 2 2
A:6
A:8
4/56
= Ground connection on
LIN
E:22 RD-BU
component/chassis
E:21 RD-YE
2/80
CEM R2 = Screened wire
D:14
D:15
F:16 1
= Junction point
F:14 F79
CAN
2
GN-YE
64/90
10
GN-YE
E:14 LIN
= Twisted cable
C:45
= Electrical connection
GN-BK
MAN
10/48
10/18 A:3 A:2 C:2 C:3 C:1 C:3 C:1 C:4 A:2 A:3
10/17
= CAN communication
2
BACK
BACK
FOG
FOG
TAIL
TAIL
UP
UP
STOP
STOP
TURN
TURN
63/53
= CAN low data signal
10/55
10/48
10/18
C:3 A:3 A:2 C:1 C:2
10/17
(CAN L)
C:4 C:3 A:4 A:1 C:1
TAIL TAIL
STOP
BK
STOP
BK
BK
GND GND2
UP UP
GND2 GND
= MOST communication
C:4 A:4 A:2 C:2
S40 S40
= LIN communication
BK
BK
= Data communication
1 = Connector connected to
component
1/1
12V BK A:1
6/25
50
31/3
1 1
BK M 30 B:1
31/4 31
PF2 PF1
2 2 RD
6/26 B:1
B+ ACM
G
RD
31
RD
L
A:3
15/31
2/82
R10 64/113
GN-BU 6
RD-OG 3
5
F12 1 2
4/46.1
RD-OG ECM
F14
F17 B:17 GN-BU
CAN
F10
I5 T
3
5 B:11
GN-BU
1 2
I5 T AUTO
64/90=
15/31:17 64/90
ONLY I4 ENGINES I5 GN-BU GN-BU
31 9
F13 I4
2/35 64/90=15/31A
1 2 R13 BK-RD
RD-GN 4
5 GY 11
3
GN-YE
7/51:6
2/32 64/90=15/31A
RD-OG R14 1 2 BK-BU
RD-OG
21
5
3
F9 F36 GN-BU
41
F34 GN-BU
12
GN-YE
RD-OG F33 8/84:1
F35
F32 64/90=15/31A
GN-YE 35
5 cyl
63/13
BK-WH
GN-BU
GN-BU
GN-BU
GN-YE GN-YE
40
GN-BU
14
GN-YE
A B 39
C DEF
TP3992202 C70 (06-) 2006 8
Electrical distribution 2:2
Overview
A B C D EF
15/31
64/113
WH-BK 7
2/142 R5 RD 13
WH-BK 3
5
64/90=15/31A
BK BK BK
F24 1 2
63/121 63/120
GN-WH 31/114
RD-OG
2/17
RD-BU R2 1 2 BK-BU
5 OG-BU
16/10
F20 3 16/11
BK-WH
GN-BU
GN-YE
RD-OG
64/111
F26 RD
5
F3 RD-OG
F30
F31
RD
F2
F16 RD-WH
GN-BU
F6 3/1 B:7
64/90=15/31A
RD-WH
30
F23 5
RD 23
F4 50 S B:1 X 15
B:2
B:5
B:3
F18
2/22
GN-WH
RD-GN
GY-BK
R11 1 2 BK-YE 17
YE
5 GN-YE 18
RD-BU
F27 3
A:42
A:15
A:30
A:17
RD-BU 64/90=15/31A
2/34 4/56
R4 E:29
E:20
RD-OG 1 2
E:23 G:18
CEM
5 GN-WH
10/5:1 E:22
3 10/6:1
RD-YE E:21
F29 E:9
2/182 CAN
R9 BK-YE G:9
RD-GN E:30
G:11 LIN
RD-BK 1 2 BK-RD
5 GN-YE
RD-WH F11 6/104:1
3
F8
F7
F1
64/861
F5 RD 1
F21
F28
F22
F19
F35
F36
F29
F19
F35
F36
F29
F19
F35
F36
F29
F19
F35
F36
F29
F43
F37 F42
F65
F64
F86
F43
F37 F42
F65
F64
F86
F43
F37 F42
F65
F64
F86
PF1
PF2
1/1 Battery
No. Fuse function via A
PF1 6/25 Starter motor - 150
6/26 Alternator -
PF2 F1-F14 Fuses in the engine compartment distribution box - 150
F16-F18 Fuses in the engine compartment distribution box -
F20-F21 Fuses in the engine compartment distribution box -
F23-F24 Fuses in the engine compartment distribution box -
F26-F27 Fuses in the engine compartment distribution box -
F29-F31 Fuses in the engine compartment distribution box -
3
1
B
Position Terminal
30
15
50
S
X
Key Out X
4 0 X X
I X X X
II X X X X
8
III X X X X
Relays, general
The diagram indicates two or three different designations for the relay’s position. This
is described below.
R9 R6
R10 R7
R12
R3 R1
R11
R14 R13 R8 R5 R4 R2
R18 R15
TP3992202
This is the cut pages sample. Download all 243 page(s) at:C70 (06-) 2006
ManualPlace.com 20