This document provides a checklist for pre-start, start, taxi, takeoff, climb, cruise, descent, landing, shutdown, and securing procedures for a Cessna Caravan aircraft. The checklist is broken into sections for each phase of flight and includes steps such as setting flight instruments, turning on lights and avionics, adjusting power levers and propeller controls, extending and retracting flaps, turning on de-icing systems, monitoring engine instruments, and securing the aircraft after landing.
This document provides a checklist for pre-start, start, taxi, takeoff, climb, cruise, descent, landing, shutdown, and securing procedures for a Cessna Caravan aircraft. The checklist is broken into sections for each phase of flight and includes steps such as setting flight instruments, turning on lights and avionics, adjusting power levers and propeller controls, extending and retracting flaps, turning on de-icing systems, monitoring engine instruments, and securing the aircraft after landing.
This document provides a checklist for pre-start, start, taxi, takeoff, climb, cruise, descent, landing, shutdown, and securing procedures for a Cessna Caravan aircraft. The checklist is broken into sections for each phase of flight and includes steps such as setting flight instruments, turning on lights and avionics, adjusting power levers and propeller controls, extending and retracting flaps, turning on de-icing systems, monitoring engine instruments, and securing the aircraft after landing.
Battery - On Flt Instruments - Set Fuel Sel - Both Fuel Selectors - On Seat Belts - On Lights - On Oxygen - Off Fuel Boost - Norm GPS/NAV Sw - Set Firewall Shutoff - In Ice Protection - On Fuel Shutoff - In Lights - Set PRE-LANDING Bleed Air Sw - Off Controls - Free Condition Lvr - Off Inertial Sep - Set Propeller - Max Propeller Lvr - Max Trims (3) - Set Flaps - Set Power Lvr - Idle Prop Lvr - Max Ignition - As Req Emer Pwr Lvr - Norm Radios - Set Inertial Sep - Set Transponder - Alt POST-LANDING Electrical Sw - Off Ignition - As Req Lights - Set Condition Lvr - High Flaps - Up CB’s - In Stby Pwr - On Condition Lvr - Low Fuel Boost Sw - On Fuel Selectors - Both Radar - Off Stby Pwr - Off GPS/NAV Sw - Set Transponder - Stby Ignition - Normal Inertial Sep - Set CLIMB Lights - Set POST START Ice Protection - Off Lights - As Req Ignition - Off Starter Sw - Off Ignition - As Req Fuel Boost - Norm Ice Protection - Set SHUTDOWN Avionics - On Power - Set Fuel Boost Sw - Off Inverter - On Flaps - As Req Stdby Pwr - Off Autopilot - Test Avionics Sw - Off Flaps - Set CRUISE Inverter Sw - Off Suction - Chk Bleed Air Sw - Off Engine Instr - Chk Power - Set Propeller Lvr - Fthr Annun Pan - Chk Ice Protection - Set Fuel Cond - Cutoff Volt/Ammeter - Chk Engine Instr - Norm Fuel Selectors - Off Trend Mont - Compl Control Locks - Set SYSTEMS Battery Sw - Off DESCENT Ovrspd Gov - Chk Ice Protection - Set SECURING Icing Sys - Check Pitot/Static Ht - Set Post-Flt - Complete Stdby Pwr - Check Passenger Adv - Brf Plugs - In Autopilot - Check Altimeters - Set Chocks - in Power - Set Control Locks - Set Condition Lvr External Post
Textbook Air Traffic Management and Systems Ii Selected Papers of The 4Th Enri International Workshop 2015 1St Edition Electronic Navigation Research Institute Eds Ebook All Chapter PDF