Professional Documents
Culture Documents
DG 24064
DG 24064
DATAVISION
APPROVAL SHEET
Customer :
Approved by :
Date :
5F, No. 25, Lane, 169, Kang-Ning Street.,His Chin Chen, Taipei Hsien, Taiwan (R.O.C.)
Te l : 8 8 6 - 2 - 2 6 9 5 0 9 5 9 Fax: 886-2-26958620
SPECIFICATIONS FOR LIQUID CRYSTAL DISPLAY MODULE
MODEL NO: DG-24064-2-S2FBLY-H
CONTENTS
1. SCOPE -------------------- 3
3. RELIABILITY -------------------- 9
5. NOTES -------------------- 18
1. SCOPE
This specification covers the engineering requirements for the DG-24064-2-
S2FBLY-H liquid crystal module.
2. PRODUCT SPECIFICATIONS
2.1 General
l 240 × 64 dot matrix LCD
l STN(Gray) , Transflective , Wide temperature type
l 6 o’clock
l Back-light: LED , Yellow-green
l Multiplexing driving : 1/64duty, 1/8bias
Item Characteristic
Contrast K 25 oC -- 3.0 -- --
Frame freq. fF -- -- 64 -- Hz
Viewing θ1 25 oC -- 30 --
deg.
angle* θ2 CR≥1.5 -- 25 --
Response ton -- 130 --
25 oC ms
time toff -- 220 --
Y' ( φ = 180 ο) X ( φ = 90 ο)
φ
X'
LC panel Y ( φ = 0 ο)
( θ = 90 ο)
Z
Light (When transmitted)
*Definition of contrast C
B1 Brightness of selected portion
C= =
B 2 Brightness of unselected portion
(%)
Dark
unselected portion brightness curve
(bias voltage applied)
Brightness
selected portion
brightness curve
Bright
Cmax.
Contrast C
2.0
θ1 θ2 Viewing angle θ
( φ fixed)
Note : Optimum vision with the naked eye and viewing angle θ at Cmax
above are not always the same.
V opr
Voltage
0
(V)
10%
Dark
90%
Brightness 100%
Bright
t on t off
If=660mA,
Forward voltage Vf 3.9 4.1 4.3 V
Yellow Green
If=220A,
*Luminous Intensity IV 120 160 -- cd/m2
Yellow Green
VR=8V,
Reverse Current IR -- -- 6.6 mA
Yellow Green
Reverse Voltage VR 8 V
3. RELIABILITY
3.1 Reliability
Test item Test condition Evaluation and assessment
4. OPERATING INSTRUCTIONS
1 FG Frame ground
8 C/D Code/Data
9 NC No connection
19 FS Font select
20 NC No connection
/WR
LCD Panel
/RD Controller Common
/CE Driver
64 (Dot Matrix 240 x 64 dots)
C/D
/RES LSI
MODEL NO: DG-24064-2-S2FBLY-H
DB0~DB7 S-RAM
80 80 80
FS
T6963C
VCC
01/09/24
Segment Segment Segment
VLCD Crystal
Driver Driver Driver
VSS
FG
Circuit Block Diagram
LEDA
BACKLIGHT
LEDK
DATA VISION
4.2
SPECIFICATIONS FOR LIQUID CRYSTAL DISPLAY MODULE
MODEL NO: DG-24064-2-S2FBLY-H
+5V
VCC
VCC
VCC-VLCD
LCM
VLCD VR VEE
Vss
GND
VCC – VLCD : LCD Driving Voltage
VR : 10K~20K
LEDA(+)
LED Back-light
LEDK(-)
5. NOTES
Safety
l If the LCD panel breaks, be careful not to get the liquid crystal in your
mouth. If the liquid crystal touches your skin or clothes, wash it off
immediately using soap and plenty of water.
Handling
l Avoid static electricity as this can damage the CMOS LSI.
l The LCD panel is plate glass; do not hit or crush it.
l Do not remove the panel or frame from the module.
l The polarizing plate of the display is very fragile; handle it very carefully
Mounting and Design
l Mount the module by using the specified mounting part and holes.
l To protect the module from external pressure, leave a small gap by placing
transparent plates (e.g. acrylic or glass ) on the display surface, frame, and
polarizing plate
l Design the system so that no input signal is given unless the power-supply
voltage is applied.
l Keep the module dry. Avoid condensation, otherwise the transparent
electrodes may break.
Storage
l Store the module in a dark place where the temperature is 25 oC±10 oC and
the humidity below 65% RH.
l Do not store the module near organic solvents or corrosive gases.
l Do not crush, shake, or jolt the module (including accessories).
Cleaning
l Do not wipe the polarizing plate with a dry cloth, as it may scratch the
surface.
l Wipe the module gently with soft cloth soaked with a petroleum benzine.
l Do not use ketonic solvents (ketone and acetoe) or aromatic solvents
(toluene and xylene), as they may damage the polarizing plate.
6. OPERATION PRECAUTIONS
Any changes that need to be made in this specification or any problems arising
from it will be dealt with quickly by discussion between both companies.
A A
DATA VISION
7. LCM Dimension
B B
C C
D D
01/09/24
MODEL NO: DG-24064-2-S2FBLY-H
03 1022406461(LCD) 1
E 02 1702406400(PCB) 1 E
01 1602406403(BEZEL) 1
NO PART NO Q'TY
APPROVED TITLE
DG-24064-02S2FBLY-H
CHECKED
UNLESS OTHERWISE SPECIFIED
SPECIFICATIONS FOR LIQUID CRYSTAL DISPLAY MODULE
19 / 19
ALEX 00
SCALE THIRD ANGLE UNIT DATE FINISHED
PROJECTION MM
90.09.22 LCM-ASSY SHEET 1 OF 1
INCH
10 9 8 7 6 5 4 3 2 1