ARTEX PRODUCTS / ACR ELECTRONICS, INC
DESCRIPTION, OPERATION, INSTALLATION AND MAINTENANCE MANUAL
ME406 (453-6603), ME406HM (453-6604
PROBABLE CAUSE POSSIBLE SOLUTION
Indicates 2 406 MHz transmission problem
Verify the coax cable/antenna is connected
and in good condition
Perform continuity check of center
Open or short condition on antenna output conductor and shield
(oF coax cable Check for a shorted cable
Check for intermittent connection in the
coax cable
Check with a VSWR meter. Check antenna
Antenna or installation faulty for opens, shorts, or a resistive ground
plane connection
Lengthen or shorten antenna coax cable
Impedance presented by antenna length by 4 to 6 inches
Provide ground plane at least 12 inches in
Insufficient ground plane diameter
Upright metal structure obstructing Stay at least 10-12 inches away from
antenna causing re-radiation Upright metal structures
Battery low
Low power output
3A fuse on battery pack circuit board faulty
Verify continuity between antenna ground
ELT local ground not connected plane and ELT local ground connection.
Cannot be repaired in field - Return to
Transmitter module faulty factory for servicing
Indicates 406 or 121.5 MHz output power is low
Check coax cable and connections
Open or short condition on antenna output
or coax cable
Check antenna for proper installation
Lengthen or shorten antenna coax cable
Impedance presented by antenna length by 4 5 inches
Transmitter module faulty Cannot be repaired in field - Return to
(Frequency out of limits) factory for servicing
25-62-30
Page 36 of 73ARTEX PRODUCTS / ACR ELECTRONICS, INC
DESCRIPTION, OPERATION, INSTALLATION AND MAINTENANCE MANUAL
ME406 (453-6603), ME406HM (453-6604
Indicates there is no navigation position data present (long message protocol only)
ELT programmed with a long message
format
Reprogram to short message or ignore
error code. 5 flash code does not indicate a
hard failure and does not affect
airworthiness of unit.
Indicates G-Switch loop between pins 5 and 12 is not present
Jumper open
Verify D-Sub connector jumper is installed
by checking for less than 19 between pins
5 and 12. Repair as necessary.
Jumper missing
Install D-Sub jumper between pins 5 and
12 in D-Sub connector.
Indicates a battery problem
Operating time is >1 hour
Electrical circuits faulty
Replace battery pack
Table 6 ELT Self-Test Error Codes Troubleshooting Guide
25-62-30
Page 37 of 73