Professional Documents
Culture Documents
Giant Water Heater I IM028En Res Elect Ecopeak
Giant Water Heater I IM028En Res Elect Ecopeak
DANGER
If the information in these instructions is not followed
AVERTISSEMENT
exactly, a fire or explosion may result causing property
damage, personal injury, or death.
IMPORTANT
READ THESE INSTRUCTIONS CAREFULLY BEFORE BEGINNING THE INSTALLATION. PROPER INSTALLATION
WILL PROVIDE SAFE AND EFFICIENT SERVICE, AND AVOID NEEDLESS EXPENSE NOT COVERED BY
THE WARRANTY. READ THE PRODUCT WARRANTY CONTAINED IN THE OWNER’S MANUAL AND
REMEMBER TO FILL OUT AND RETURN TO THE MANUFACTURER ALL RELEVANT WARRANTY CARDS
AND CERTIFICATES. SHOULD YOU HAVE ANY QUESTIONS, PLEASE CONTACT YOUR LOCAL DEALER OR
REFER TO THE GETTING SERVICE FOR YOUR WATER HEATER SECTION OF THE OWNER’S MANUAL.
SAVE THIS MANUAL FOR FUTURE REFERENCES. ISO 9001
ENREGISTRÉ
For your records, write the model and serial number here:
® R
Model #_________________________________________ ISO 9001
REGISTRED
Serial #_________________________________________ C US
54000035
© 2017 Giant Factories Inc. Printed in Canada GI-IM028En-0517
Electrical Connections
Diagram
WARNING Red
L1 Line voltage
G according to
This water heater uses an external electrical source for L2 rating plate
Black
DANGER
power. It must be electrically grounded in accordance
with all local codes or, in the absence of local codes,
CSA C22.1 Canadian Electrical Code, in Canada, and/
AVERTISSEMENT
or the National Electrical Code, ANSI/NFPA 70, in the
United States. Failure to properly ground this water
heater can result in property damage, personal injury,
or death.
Black
Blue
Red
element wattage and voltage and make sure that the power
supply wiring and the fusing or circuit breaker are the cor-
Yellow
rect size for this water heater (see Table). Verify that all of
the wire connections on the element and thermostat have
been installed correctly, are secure, and that none of the
wires are grounded, have split, or are broken (see diagram).
If any of the original wiring needs replacing, use only
14AWG-type, or greater wire that is approved for 221˚F Top
(105˚C). element
To hook up the water heater to the power supply, connect
the power supply wiring to the red and black wires
attached to the top thermostat. NEVER CONNECT THE
Black
POWER SUPPLY DIRECTLY ONTO THE THERMOSTAT.
WARNING
Red
Table
Black
Lower
element
2
16 Middle element 14 17
17 Middle thermostat 8 18
18 Upper element
19
19 Combination upper thermostat and 9
high limit reset control
20
20 Hot water outlet
21
Bottom entry models
21 Hot water manual shut-off valve
22
22 Union 12 11 10
Installation
21 22
21 5 4
22 5 3
4 2 1 ID No. Desc
3 2
ID No. Description 1 Num
Num. Description 1 Chec
1 Check valve, water meter or 20 1
pres
1 pressure
Compteur d’eau ou
reducing clapet ou
valve
soupape de réduction de pression 20 2 Cold
2 Cold water manual shut-off valve 2
2 Robinet d’arrêt d’eau froide manuel 3 Unio
3 Union 3
3 Raccord 4 Cold
4 Vacuum breaker 4
4 Brise vide 5 Temp
5 Temperature & pressure-relief valve 19 5
6 Expa
65 Expansion
Soupape de tanksûreté de température et pression 19
6 Réservoir d’expansion 7 Over
7 Overflow tube 6
6 8 Dip-t
87 Drain
Tuyau pand’évacuation 18 7
9 Drain
8 Bassin
9 Free-flowing de rétention
floor drain 18 6 8
10 Free
109 Cold
Drain de plancher
water inlet 9
17 11 Lowe
1110 Lower
Entréeelement
d’eau froide 10
17 12 Drain
1211 Drain
Élément
valve du bas 11
13 Elem
1312 Element
Robinetand de vidange
thermostat access doors 12
16 7 14 Lowe
1413 Lower
Portesthermostat
d’accès aux éléments et thermostats 13
7 15 Mag
1514 Magnesium
Thermostatanodedu bas 15 16 16 Midd
1615 Middle
Anodeelement
de magnésium 13 14
14 15 17 Midd
1716 Middle
Élément thermostat
du milieu 13 8 15
14 18 Uppe
1817 Upper element
Thermostat du milieu 16
8 19 Com
1918 Combination
Élément du haut upper thermostat and 9 high
17
high limit reset control
19 Thermostat du haut 20 Hot
18w
20 Hot water
avec outlet secondaire
interrupteur 9
21 Hot
19w
2120 Hot water
Sortie manual
d’eau shut-off valve
chaude
12 11 10 22 Unio
22 Union
21 Robinet d’arrêt d’eau chaude manuel 20
22 Raccord 12 11 10 21
22
21 22 5 4
3 2 1 Num. Desc
Num. Description
1 Com
1 Compteur d’eau ou clapet ou soup
soupape de réduction de pression 20
Replacement 2 Rob
2 Robinet d’arrêt partsd’eau froide manuel
3 Rac
3 Raccord
4 Entr
4 Brise vide
5 Sou
ID5 No.Soupape de sûreté de température et pression
Description 19 et pr
61 Réservoir d’expansion
Combination upper thermostat and 6 Rés
high limit
7 Tuyau reset control
d’évacuation 7 Tuya
82 Bassin
Upperdeelement
rétention 15 6
18 8 Tuya
93 Drain
Middle thermostat
de plancher 9 Bass
104 Entrée
Middle element
d’eau froide 10 Drai
115 Élément
Lower thermostat
du bas 17
11 Élém
126 Robinet
Lower de vidange
element 12 Rob
137 Portes d’accèsbrackets
Thermostat aux éléments et thermostats 13 Port
148 Thermostat du bas 16 1 7
Machine bolts therm
159 Anode de magnésium
Element and thermostat access doors 14 Ther
15 7 11
16
10 Élément du milieu
Thermostat gaskets 13 10 15 Ano
17 14
11 Thermostat du milieu
Patented Twist Lock flanges 16 Élém
2 8
18
12 Élément du haut
Drain valve 17 Ther
3
19
13 Thermostat
Inlet nippledu haut 18 Élém
avec interrupteur secondaire 9
7 11 19 Ther
14 Magnesium anode 10
20 Sortie d’eau chaude 14 avec
15 Outlet nipple
21 Robinet d’arrêt d’eau chaude manuel 20 Sort
4
22 Raccord 12 11 10 21 Rob
5 12 22 Rac
9 8
7 11
10
6 13
ID No. Description
1 Combination upper thermostat and
I.D. D
Num. high limit reset control
Description
2 Upper element 15 1 U
1 Thermostat du haut
3 Middle thermostat secondaire
3 2 T
avec interrupteur
15 3 U
13 Element and thermostat access doors
7 14 Lower thermostat
15 Magnesium anode 13 16
8
16 Middle element
15
17 Middle Thermostat
8 18 Upper Element
14
9
Top entry models 19 Combination upper thermostat and
high limit reset control
9
5
17
If screw-in type elements 16
1
2
3 17
Si éléments de type vissés 16
15
I.D. Description 1
2
1 Upper thermostat with reset 43 10
2 Thermostat
Num. Description brackets 15