Professional Documents
Culture Documents
B.Tech (Civil) - 1-CV4009 (2020-21)
B.Tech (Civil) - 1-CV4009 (2020-21)
B.Tech (Civil) - 1-CV4009 (2020-21)
II) The horizontal span of a suspension cable is 50m. The right-hand support B is higher than the left-hand
support A by 10m. The dip of the lowest point C below A is 4m. It carries a uniformly distributed load of
10 kN/m over the entire span. Find i) Maximum tension in the cable and ii) Length of the cable.
II) Two-wheel loads 40 kN and 80 kN with fixed distance 3 m between them and 50 kN load leading,
crosses a beam of span 10 m from left to right. Draw the influence line for shear force and bending
moment at section 3 m from left support and find the maximum value of shear force and bending
moment at this section.
II) Draw SFD and BMD for the frame as shown in figure.
III) Find the forces in members AB, BD, and DE of plane truss loaded as shown in fig.
SECTION - 2
II) A hollow rectangle column having outside dimension 200 mm X 160 mm and inside dimensions 160 mm
X 120 mm. Its length is 6.0 m and both ends are hinged. Find Euler’s load if E= 2 X 105 N/mm2 .
Q 5 A) Draw shear stress distribution diagram for I- section and T- Section. [3]
II) A rolled steel joist of I Section overall depth 450 mm x 150 mm wide has flange and web of 14 mm thick.
If permissible shear stress is limited to 80 N/mm2, Find the value of point load at centre of simply
supported span of 8m.
Q 6 Answer the following in detail. (Any 2) [12]
I) Determine slope and deflection at the free end of a cantilever beam shown in figure by Conjugate beam
method. Take E=200GPa and I = 2 x 108 mm4
II) For a simply supported beam shown in figure Calculate slope at each support by double integration
method. Take E=200GPa and I = 6.5 x 108
mm4
III) For a simply supported beam shown in figure Calculate slope at each support by macaulay’s method.
Take E=200GPa and I = 6.5 x 108 mm4