Professional Documents
Culture Documents
Venturi Tube
Venturi Tube
A Venturi tube is a short pipe with a narrow and restricted inner surface. It is typically used to
calculate fluid flows and as a functional pump. Giovanni Battista Venturi designed a device with
a constricted throat in the centre. As fluid enters the throat, the fluid moving through the tube
accelerates, and the pressure drops. The device is designed based on the effects of narrow and
restricted channels of fluid movement.
Table of Contents
The restricting scenario of the Venturi effect is when fluids reach the choked flow condition,
where the fluid velocity reaches the regional speed of sound. When fluid systems are in a choked
flow state, a further reduction in the downstream pressure region will not pave the way for a
boost in velocity unless the fluids are compressed.
The rate of mass flow for a compressible fluid increases with rising upstream pressure. It
increases the liquid’s density through a constriction (even though the velocity remains constant).
These are the fundamentals of a de Laval nozzle operation. Rising source temperature increases
the sonic velocity. This allows for increasing mass flow speed. It is only relevant if the area of
the nozzle is also enlarged to adjust for the resulting fall in density.
What is a Venturi Tube?
A Venturi tube is a tubular setup for calculating the flow of fluids. The fluid moves through a
pipe of inconsistent diameter. To reduce excessive drag, Venturi tubes usually have one entry
cone of thirty degrees and five degrees exit cone.
Typically, Venturi tubes are used in conditions where the permanent loss of pressure is not
tolerable and where the highest accuracy is required in the case of heavily viscous liquids.
A pressure reduction, accompanied by a rise in the flow velocity, is the basis of the laws of fluid
dynamics. In 1738, Daniel Bernoulli derived the relationship between velocity, pressure and
other properties of a fluid. Fundamentally, his theorem is applied in the development of aircraft
wings to generate lift from the airflow over the wing surface.
It is also extensively used in waste treatment processes. It enables solid materials to move
through because of its gradually inclined smooth structure. Thus, it is ideal for the estimation of
dirty fluid.
High-pressure recovery.
It can be fixed in any orientation: inclined, horizontal, and vertical.
Less permanent pressure reduction.
Less cone angle and smooth construction help solid substances to move through it. So it
can be employed for dirty fluids.
High discharge coefficient.
It is much more accurate than the flow nozzle and orifice.
Disadvantages