Professional Documents
Culture Documents
Lxe10e A36 A
Lxe10e A36 A
Lxe10e A36 A
・
Optional Functions・
LXE10E-A36
LXE10E-A36A
TR07-04A
Covered Models
Regarding the features, operation and after servicing, please refer to the
service manual(TR02-14).
−1−
−2−
CONTENTS
1. Names of components ……………………………………………………4
2. Transducer ……………………………………………………………………5
目 次
1. ……………………………………………………………………11
2. ……………………………………………………………………12
3. ……………………………………………………13
4. ……………………………………………………………………14
5. ……………………………………………………………………15
6. ……………………………………………………………………16
−3−
1. Names of components
−4−
2. Transducer
2.1 Low pressure transducer (LPT) y Apply the heat shrinkage tube in the
Transducer type NSK-BC010F following position, then shrink it with hot air
of a dryer.
Identification
w Binding band
i Fix the low pressure transducer with the
w Binding band clamp plate, and fix the cable with the binding
band.
q Clamp plate Fix the shrinkage tube end of the cable side
downward for prevention of water entering
r Remove the heat shrinkage tube, and
into the tube.
disconnect the connector from the low
pressure transducer. q Clamp plate
Union joint
Low pressure transducer Flare nut
w Binding band
−5−
3.. Initial setting table into spare controller
MODEL
※7. Optional function
NAME ※8. Basic function mode ※ 9.Optional Condition setting mode ※10. Input Data
setting mode
Note 1
USdA dHu DECOS-3 LOG INT REC SEN OC-SET HP dISP COMP REHEAT FA SEN CHARTLS USdA1/2 H001 H002 H003 H004 H005 H006 D1-- D2-- D3-- D-1- D-2- C/F SET Id SET TIME
LXE10E Dehumi- Data Panel Comp./ Reheat D/H code USdA
USdA Controller Logging Input Hose Temp. Container Controller
dification recorder lighting Unload coil alarm sensor H code D code
sensor setting interval power power indication I.D. set time
control sensor OFF setting setting indication type
-A36
-A36A OFF OFF D 60 ON Single 10 OFF 100 ON OFF ON 2 3 2 2 2 3 3 1 1 1 1 1 C * GMT
↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑ ↑
Spare
blank blank blank blank blank blank blank blank blank blank blank ON 1 3 2 2 2 3 3 1 1 1 1 1 C blank 01/1/1
controller
Notes 1. Comfirm MODEL NAME mentioned in the name plate mounted on the reefer unit.
2. It is possible to input Container I.D. and Controller Time with both the panel operation and the personal computer installed DCCS's software.
3. When inputting the container I.D. by the panel operation, take care not to enter any of the following pairs of alphabet and numeral(i-1),(O-0),(S-5).
4. If you don't input container I.D., it is impossible to download the logger data with the personal computer.
5. If you don't input the controller set time, it starts from 2001.1.1, 0:00.
−6−
4. Refrigerant piping diagram
−7−
−8−
5. Schematic wiring diagram
−9−
6. Stereoscopic wiring diagram
− 10 −
1
− 11 −
− 12 −
3
USdA dHu DECOS-3 LOG INT REC SEN OC-SET HP dISP COMP REHEAT FA SEN CHARTLS USdA1/2 H001 H002 H003 H004 H005 H006 D1-- D2-- D3-- D-1- D-2- C/F SET Id SET TIME
LXE10E
−A36
OFF OFF D 60 ON 10 OFF 100 ON OFF ON 2 3 2 2 2 3 3 1 1 1 1 1 C * GMT
−A36A
←
←
←
←
←
←
←
←
←
←
←
←
←
ON 1 3 2 2 2 3 3 1 1 1 1 1 C 01/1/1
− 13 −
4.
− 14 −
5.
− 15 −
6.
− 16 −
ORDERING INSTRUCTIONS
The parts list contains the parts of the DAIKIN Marine Type Container Refrigeration Units.
Please read the following items before using the list.
1. When ordering the parts, be sure to specify the model No., the name of part and the type
of part. When ordering the parts for which no parts NO. is shown in the PARTS NO.
column, be sure to describe DWG.NO..
2. The list shows the parts only for replacement or repairing at the job site. Certain parts
require a production lead time or are supplied as a set, so please contact with the nearest
DAIKIN PARTS CENTRE.
3. Index symbols;
Meaning of the ranking A,B and C are as follows;
A. The most important spare parts
1. The parts whose malfunction cause fatal damage to the unit.
2. The parts with high risk of malfunction.
3. The parts that are worn out after an extended service period.
B. The important spare parts next to A, but the risk of malfunction is not so high.
C. The parts with low risk of malfunction, but recommendable to stock to cope with
damage during handling of container box and long delivery time, etc.
The parts without A, B and C mark is the parts whose necessity is not so high under
normal operation.
パーツリスト使用上の注意
このパーツリストはダイキン海上コンテナ冷凍装置の部品を集録してあります。パーツリ
スト使用にあたっては、必ず次の注意事項をご一読の上使用していただくようお願いいた
します。
1.部品のご注文の際は機種名、 部品番号、および部品名、
形式を必ずご指定ください。
なお、 部品番号欄が空白になっている部品は、図面番号で指示願います。
2.掲載部品の範囲は、 あくまでも現地にて分解修理できるところまで記載しております。
一部部品につき納期のかかるものおよびセット単位となるものもありますので、お近
くのダイキンパーツセンター又はサービスステーションに相談願います。
3.INDEXの説明
INDEXのA、B、Cの意味は下記の通りです。
A. 最も重要な部品
1. 故障した場合に最も重大な損害を与えると思われる部品
2. 故障の確率が高いと思われる部品
3. 長期の使用で摩耗して使用できなくなる部品
B. 故障発生の確率は高くはないが、Aについで重要な部品
C. 故障発生の確率は低いが、コンテナボックスの運搬中の事故や、部品の納期が長期
になると思われる等の理由で、在庫をお勧めする部品
A,B,Cマークの無い部品は、通常の運転では必要性は高くない部品です。
− 17 −
(TR07-04A)
Denomination of Model Name
L X E E
OPTION NUMBER
機種名について
L X E E
称呼馬力
5:5
10 : 10
凝縮器冷却方式
なし:空水冷兼用形
A :空冷専用形
オプション番号
注)オプション番号の後に R がつく機種は、改造機で、特別な仕様が
加えられていることを意味します。
− 18 −
(TR07-04A)
CONTENTS
目 次
Page
A. Parts related with the unit(outside)………………………………………………………………………20
庫外関連部品
− 19 −
(TR07-04A)
Parts related with the unit(outside)
庫外関連部品
A20
A22
A21
A21
A19
A36
A5 A6
A17
A19
A30
A20
A4 (Refer to 52Page)
E30
A8 A11
A18 E13
A10
E13
A12
A7
A2
A16 A3
A13
A1 A14
A15 (Refer to 53Page)
A35
A31
E55
A32
A34
A33
− 20 −
(TR07-04A)
Parts related with the unit(outside)
庫外関連部品
− 21 −
(TR07-04A)
Parts related with refrigerant piping(outside)
庫外冷媒配管関連部品
HSV B11
B26
Feele
r bulb
DSV B7a
RSV
B7-4 B7-7 B7-3
B13詳細(Detail of B13)
B7-1
B23 B13
B7-5
B12詳細(Detail of B12)
B8-1-1
A B21 B12
B7-2 B7-8
B12 B8-1-2
B8-1-3
A View A-A B8-1-5
B2
B8-1-4
B12
B8
B5
B6-1
SMV B8-1
B3-2
B6 B5-2
B3-2-1 B4-5 B5-1
B4-6 B10
B3-2-2
B3-1 B3-2-3 B3 B3-3
B4-1
B4-2
E26 E22 B9
B4-3
B3-6 B24 LSV
B19 B3-5
B3-4 B4-4 B4-7
B11 B13 B4-7-2
B17 DPR B4
B3-7 B4-7-3
B16 B3-7-2
B3-7-1 B4-7-1
B15 B9-2
B18 B9-1
B25
B1 B9-1-2 B3-7-3
B14 B9-1-1
B9-1-3
− 22 −
(TR07-04A)
Parts related with refrigerant piping(outside)
庫外冷媒配管関連部品
B3-4 A 1241361 Discharge pressure regulating valve 吐出圧力調整弁 3P074558-1 1 1 Refer to Page54
B4-5 B 1787247 Solenoid valve body 電磁弁本体 3P198486-1 VPV-803DQ52 1 1 Refer to Page54
B7-3 A 125649J Electronic expansion valve body ass'y 電子膨張弁本体組立品 2SA50010-2-KU 1 1 Refer to Page54
B7-4 B 1787247 Solenoid valve body 電磁弁本体 3P198486-1 VPV-803DQ52 4 4 Refer to Page54
● When ordering the parts whose No. are not shown in the ● 部品番号欄が空白になっている部品は、図面番号で、指示願います。
PARTS NO. column, be sure to describe DWG. NO..
− 23 −
(TR07-04A)
Parts related with refrigerant piping(outside)
庫外冷媒配管関連部品
B7-6 A 0088738 Nev type solenoid valve body NEV型電磁弁本体 R3305099-1-KI NEV-202DXF 2 2 Refer to Page54
B8-1 A 1254538 Suction modulating valve ass'y 吸入比例弁組立品 2P078385-1 1 1 Refer to Page54
B11 A 098332J Sensor, discharge pipe temperature(DCHS) 吐出管用センサ(DCHS) 3SA48009-10 1 1 Refer to Page56
B12 A 0798321 Sensor, ambient air temperature(AMBS) 外気温度センサ(AMBS) 3PA61769-6 ST9503-6(NIL) 1 1 Refer to Page56
B13 A 098333J Sensor, comp suction pipe temperature(SGS) 圧縮機吸込配管温度用センサ(SGS) 3PA61769-9 ST9503-9(white) 1 1 Refer to Page56
B15 A 1587942 Low pressure transducer(LPT) 低圧圧力センサ(LPT) 3P141601-1 NSK-BD010F-070 1 1 Refer to Page55
B16 A 1587959 High pressure transducer(HPT) 高圧圧力センサ(HPT) 3P141602-1 NSK-BD030F-070 1 1 Refer to Page55
B20 A 138143J Electronic expansion valve coil 電子膨張弁コイル 2P010454-2 1 1 Refer to Page54
● When ordering the parts whose No. are not shown in the ● 部品番号欄が空白になっている部品は、図面番号で、指示願います。
PARTS NO. column, be sure to describe DWG. NO..
− 24 −
(TR07-04A)
Parts related with refrigerant piping(outside)
庫外冷媒配管関連部品
− 25 −
(TR07-04A)
Parts related with the unit(inside)
庫内関連部品
C15 C8 C1-2
C1-1
K1
C2
C37
C7 E57
C9 E57詳細(Detail of E57)
C12
Sealing compound
(KE44RTV or its equivalent)
シール剤
INSIDE
C13 (KE44RTV又は相当品)
E57
C18
OUTSIDE
C34 PUTTY
C19 (Equivalent of NEO-SEAL B-1)
A
パテ
C5 (ネオシールb-1相当品)
C19
C3 C6
C4 C6
A詳細(Detail of A)
<Without recorder>
C35
C28 C31
C30
C23詳細(Detail of C23)
C14
<Without recorder>
C16
C37詳細(Detail of C37)
F72 C21
C24 SS(Green) C25 DSS(Green・Red) E14 E14
C30 C39
B21
C37
− 26 −
(TR07-04A)
Parts related with the unit(inside)
庫内関連部品
− 27 −
(TR07-04A)
Parts related with refrigerant piping(inside)
庫内冷媒配管関連部品
D1
D4
D8
D5 D9
D2
D3-3
D4詳細(Detail of D4)
D3-7
D3-4 E60
D6 D7
D3-5
D3-2
D3-2
D4
E78
D3
D5詳細(Detail of D5)
D3-8
D3-6
D5
D3-9
E63
D3-1
D3-10
− 28 −
(TR07-04A)
Parts related with refrigerant piping(inside)
庫内冷媒配管関連部品
● When ordering the parts whose No. are not shown in the ● 部品番号欄が空白になっている部品は、図面番号で、指示願います。
PARTS NO. column, be sure to describe DWG. NO..
− 29 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
E11
E13
E E
E87
E87 C E86
B詳細(Detail of B) C詳細(Detail of C)
E91
E60
Tie wrap
Wires
E断面(Section of E)
Condenser coil
E83 E82
E79
E83
− 30 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
※(L = XX mm) indicates the length of cushion rubber E35.(Cut to suit pipe size.)
※(L = XX mm)と表記のものは、緩衝ゴム(E35)の長さです。(配管のサイズに合わせて切って使用ください。)
矢視A/B(View A/B)
E16 E16
RSV
E5
E29
B E4
E90 E90 E61 E26
受液機器部詳細
(Receive part detail)
E17
ドライヤー部詳細
(Dryer part detail)
E8 E7/8
E21
(L=60mm) E89
E33 圧力センサー配管部詳細
(Pressure tranducer detail)
E7
E26 E22
E34
E10
E84
E6
− 31 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
E79
E79
E11 E12
E60
EOS
E62 E78
E20
E23
E52
矢視A(VIEW A)
E15
E15
− 32 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
E46 E46
E54
E45
E37 E38
E39
E39
− 33 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
E61
E69
E75
E70
E77
E76
E64
E78
E63
E72
E78
E93
E67
E65
E66
E24
− 34 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
E20 1386992 Tube clamp, double tube heat exch 二重管熱交管止め金 4P103281-56 2 2 Page32
E24 1386985 Tube clamp, double tube heat exch 二重管熱交管止め金 4P103281-51 1 1 Page34
E32 1266889 Cushion rubber, pipe clamp 緩衝ゴム(管止用) 4P064896-1 t1.0 1 1 Page31
E54 1267060 Packing for prevention of air bypass バイパス防止用パッキン 4P011733-1 2 2 Page33
● When ordering the parts whose No. are not shown in the ● 部品番号欄が空白になっている部品は、図面番号で、指示願います。
PARTS NO. column, be sure to describe DWG. NO..
− 35 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
− 36 −
(TR07-04A)
Other parts(Pipe clamp, sealing and insulation material etc.)
その他部品(配管固定具、シール材、防熱材等)
− 37 −
(TR07-04A)
Control box
コントローラボックス
F58
F24 F17
F22
F73
F23
F57 F25
F27
F76
F46
F30
F59 F33
F39
F61
F7-5
F18 F7-4
F7-7
F75
F7-6
F7-3
F16-1
F7
F16-2
F7-1
F7-2
F7-9
F7-8
− 38 −
(TR07-04A)
Control box
コントローラボックス
F67
F41 F6
F3
F28 F35
F32
F3 F38
F74 F50
F31-1
F34 F34-3
F31
F34-2
F34-8
F34-4 F34-8-1
F34-10
F34-1
F34-14
F70-1 F34-7
F34-12 F34-13
F34-9 F34-6
F78
F70-2 F77 F34-5
F77-2 F34-11
F77-1
− 39 −
(TR07-04A)
Control box
コントローラボックス
F23 A 124149J Magnetic contactor(Phase correction contactor) 相順切換電磁接触器(PCC) 3P071508-3 24V RSK-35J 1 1
F34-8 A 1250783 PC board for suction modulating valve プリント基板組立品(吸入制御弁用) 3P065441-1 EC0058 1 1
− 40 −
(TR07-04A)
Control box
コントローラボックス
F48 1739387 Packing for control box front plate パッキン(コントロールボックス前板(左)) 4P172580-1 1 1
− 41 −
(TR07-04A)
Parts related with name plate
銘板関連
− 42 −
(TR07-04A)
Parts related with name plate
銘板関連
G4 1726552 Name plate, Brand name and refrigerant label 意匠銘板および冷媒銘板 3P174603-1 1 1 Refer to Page53
G20 1793817 Electric wiring diagram label 電気配線図銘板 2D055844-1 1 1 Refer to Page52
● When ordering the parts whose No. are not shown in the ● 部品番号欄が空白になっている部品は、図面番号で、指示願います。
PARTS NO. column, be sure to describe DWG. NO..
− 43 −
(TR07-04A)
Parts related with option 1 – USDA
オプション関連部品1 – USDA関連
I9
I1
I3
I4
I3
I4
I3
I4
I3
I4
I6 I5
I7
I8
− 44 −
(TR07-04A)
Parts related with option 1 – USDA
オプション関連部品1 – USDA関連
− 45 −
(TR07-04A)
Parts related with option 2 – MODEM
オプション関連部品2 – モデム
J1
J5
J6
J4
J3
MODEM モデム
Supply by customer
客先支給
− 46 −
(TR07-04A)
Parts related with option 2 – MODEM
オプション関連部品2 – モデム
− 47 −
(TR07-04A)
Parts related with option 3 – Others
オプション関連部品3 – その他
K1
2.Evaporator coil
2.蒸発器コイル組立品
K6
− 48 −
(TR07-04A)
Parts related with option 3 – Others
オプション関連部品3 – その他
− 49 −
(TR07-04A)
List of size for standard pipe clamp
配管固定具サイズ表
1.Resin clamp
1.樹脂バンド
C
H
0
1. (外穴)
D± (OUTER HOLE)
φ
H
1.0
D± (内穴)(外穴)
φ
(INNER HOLE)(OUTER HOLE)
1.0
H
D± (INTERMEDIATE HOLE)
φ
(内穴)(中穴)(外穴)
(INNER HOLE) (OUTER HOLE)
− 50 −
(TR07-04A)
List of size for standard pipe clamp
配管固定具サイズ表
2.Tube clamp
2.管止金
C
D
φ
H
15
2-φ5.5穴
22
L=300
− 51 −
(TR07-04A)
Notes for ordering spare parts
部品発注の際の注意事項
For ordering following spare parts, we recommend that you order the following
packing, gasket, sealing material and name plate together at the same time.
上記のサービス扉やボックスカバーを発注の際には、下記のパッキングを同時に発注
することをおすすめします。
(1)Service door
(1)サービス扉
A4
NO. PARTS NO. DWG NO.
PARTS NAME 部品名称 A5
符号 部品番号 図面番号
A4 1612576 Access panel (FRP) サービス扉組立品 1P006678-5 A6
Cushion material クッション材
A5 1266207 3P033608-1
(access panel) (サービス扉)
Sealing material シール材
A6 1196113 3P001640-2
(access panel) (サービス扉)
− 52 −
(TR07-04A)
Notes for ordering spare parts
部品発注の際の注意事項
(4)Ventilation cover
(4)換気口蓋
A20
NO. PARTS NO. DWG NO.
PARTS NAME 部品名称
符号 部品番号 図面番号
A19 0981060 Ventilation cover 換気口蓋 3P003175-1
Sealing material
A20 1266221 シール材(換気口) 4P016185-1
(access panel)
A19
− 53 −
(TR07-04A)
Notes for ordering spare parts
部品発注の際の注意事項
Refer to the following table for the name, main body, solenoid coil and ass'y of
solenoid valves etc. applied to this model.
この機種に使用されている電磁弁等の名称と本体・コイル・組立品は下記のとおりです。
Common Parts
共通部品
NEV-MOAB507C1
Body/Coil NO. PARTS NO. DWG NO.
NEV-202DXF
VPV-803PQ50
PARTS NAME 部品名称
本体/コイル 符号 部品番号 図面番号
Note 1 :Refer Page 22, 23 and 24 for detail parts of suction modulating valve.
注1 :SMV(吸入比例弁)の詳細部品はP.22、23、24を参照ください。
Note 2 :Difference of solenoid valve No.1266290 and 0955287.
No.1266290 (3P010453-2):Lead wire length 1550mm (TYPE NEV-MOAB518C1)
No.0955287 (3P010453-1):Lead wire length 2000mm (TYPE NEV-MOAB507C1)
注2 :電磁弁No.1266290とNo.0955287の違い。
No.1266290 (3P010453-2):リード線長さ1550mm (型式 NEV-MOAB518C1)
No.0955287 (3P010453-1):リード線長さ2000mm (型式 NEV-MOAB507C1)
− 54 −
(TR07-04A)
Notes for ordering spare parts
部品発注の際の注意事項
Refer to the following table for the pressure transducer applied to this model.
For ordering pressure transducer, we recommend that you order the following best
shrinkable tube together at the same time.
この機種に使用している圧力センサーは下記の通りです。
圧力センサー発注の際は、下記の熱収縮チューブを同時に発注することをおすすめし
ます。
NO. PARTS NO. DWG NO. TYPE REMARKS
PARTS NAME 部品名称
符号 部品番号 図面番号 形式 備考
B16 1587959 High pressure transducer (HPT) 高圧圧力センサ(HPT) 3P141602-1 NSK-BD030F-070
B15 1587942 Low pressure transducer (LPT) 低圧圧力センサ(LPT) 3P141601-1 NSK-BD010F-070
Must be applied
when replacing
E84 1605509 Heat shrinkable tube 熱収縮チューブ 4P151322-1 above sensors.
上記圧力センサー交
換時使用の事。
− 55 −
(TR07-04A)
Notes for ordering spare parts
部品発注の際の注意事項
Refer to the following table for temperature sensors applied to this model.
この機種に使用されている温度センサーは下記の通りです。
7828 ST9703-1
Length
− 56 −
(TR07-04A)
Measuring and adjusting tools
測定調整用工具
For electronic
Emergency coil エマージェンシー expansion
- 1080263 3P017370-1
cap コイルキャップ valve
電子膨張弁用
Suction
E m e r g e n c y エマージェンシー modulating U P SID E
- 1270530 2P078385-2
magnet マグネット valve → OPEN
吸入比例弁用 DO
W N SID E
− 57 −
(TR07-04A)
Measuring and adjusting tools
測定調整用工具
The following parts are connector cables required to exchange information between
the refrigeration unit and personal computer. The table below describes parts required
to apply to Model LXE-C, -D, and -E new model.
下記の部品は冷凍ユニットとパソコンの情報交換に必要なコネクター、ケーブル類で
す。LXE-C型、 D型、及び新機種E型対応に必要な部品を掲載しています。
[TYPE A]タイプA
LXE10C LXE10C
LXE10CA LXE10CA e
LXE10D for MOL MOL用LXE10D q 1.5m
(Receptacle) (レセプタクル)
RS232C (Female) RS232C(メス)
on the controller コントローラー側
[TYPE B]タイプB
e
w 0.3m q 1.5m
LXE10D LXE10D
LXE10E LXE10E
(Receptacle) (レセプタクル)
Water proof type コンテナ冷凍機 r or t
r 2.0m
on the unit ユニットの防水型 t 1.5m
(1)Parts No.
(1)部品番号
NO. PARTS NO. REMARKS
PARTS NAME 部品名称
符号 部品番号 備考
Local supply 接続ケーブル RS232C reverse (cross) type
1 Connection cable (reverse)
市販品 (リバース) RS232Cリバース(クロス)型
2 9993324 Connection cable 接続ケーブル
Local supply Adapter アダプター D-sub 9P, Male-Male
3
市販品 (gender changer) (ジェンダーチェンジャー) Dサブ9ピン、オス-オス
LXE10E-A Standard
4 1087149 Connection cable (3 Pins) 接続ケーブル(3ピン)
LXE10E-A標準
For LXE10E-A14,A15
5 1384509 Connection cable (5 Pins) 接続ケーブル(5ピン)
LXE10E-A14、A15用
− 58 −
(TR07-04A)
Measuring and adjusting tools
測定調整用工具
Daikin RS232C
made Female
ダイキン製 メス
A Red 1
B White 2
2 C 3
4
Black 5
6
7
8
9
Daikin RS232C
made Female
ダイキン製 メス
A Red 赤 1
B 2
C White 白 3
4 4
Black 黒 5
6
7
8
Frame
フレーム
Daikin RS232C
made Female
ダイキン製 メス
A Red 赤 1
B 2
C White 白 3
5 D 4
E Black 黒 5
6
7
8
Frame
フレーム
− 59 −
(TR07-04A)
MEMO
Head Office. Umeda Center Bldg., 4-12, Nakazaki-Nishi 2-chome, Kita-ku, Osaka, 530-8323 Japan.
Tel: 06-6373-4338
Fax: 06-6373-7297
Tokyo Office. JR Shinagawa East Bldg., 10F 18-1, Konan 2-chome, Minato-ku Tokyo, 108-0075 Japan.
Tel: 03-6716-0420
Fax: 03-6716-0230
TR07-04A
(2008.1.00000)NK