Professional Documents
Culture Documents
Kenwood SW-200
Kenwood SW-200
Powered
Subwoofer
Owner’s
Manual
Introduction Unpack the subwoofer carefully, and Be sure to get enough speaker wire
examine it for shipping damage. If it or an RCA-type cable that’s long
Congratulations! The Kenwood is damaged or fails to operate, notify enough to allow you to move the
SW-200 Powered Subwoofer will your Kenwood dealer immediately. subwoofer around while you find
bring a new level of bass to your If it was shipped to you directly, the right location for it.
stereo system. Installing the sub- notify the shipping company without
woofer isn’t difficult, but please read delay. Only the person or company
and follow all of the instructions on who originally received the speaker Before you get started
these pages to get maximum perfor- can file a claim against the carrier for
mance from your SW-200. shipping damage. A few notes of caution about setting
up and using your new subwoofer:
If you’re installing this subwoofer as Keep the original carton and packing
part of the Kenwood KSS-200 or materials in case you need to trans- • Before you connect the
KSS-500 packages, or if you’re port or ship your subwoofer in the subwoofer to your receiver or
connecting other equipment, such future. amplifier, make sure that the
as a receiver, power amplifier or power cords on both units are
pre-amplifier, use this manual in unplugged from the wall outlet
combination with the manuals that What else will you until you’ve finished connecting
came with those components. need? the two
FROM AMPLIFIER
+ R – + L – LINE IN
R 120
+ R – + L –
TO SPEAKERS 50 150
MIN MAX
FROM AMPLIFIER
+ R – + L – LINE IN
R 120
+ R – + L –
TO SPEAKERS 50 150
MIN MAX WARNING: TO REDUCE THE RISK OF FIRE OR ELECTRIC POWER
SHOCK, DO NOT EXPOSE THIS APPLICANCE TO RAIN OR MOISTURE
ON
CAUTION
LISTED
1Z46
P/N WF—50K
AUDIO
EQUIPMENT
120V – 60Hz E158878
ON
CAUTION
AUDIO
EQUIPMENT
120V – 60Hz E158878
L
NOT SUITABLE FOR IN-WALL MOUNTING speaker wires to – Black
Connect one end of an the LEFT and
–
RCA-type shielded RIGHT Front Black
R
SUBWOOFER audio cable to the speaker connectors +
PRE-OUT Red
SUBWOOFER on the receiver or
PRE-OUT connection amplifier
on the receiver or
LINE IN
amplifer Connect the other
end of the cable to Connect the other end of
L FROM AMPLIFIER
either one of the the left and right speaker + R – + L –
LINE IN connections wires to the left and right
R
on the subwoofer FROM AMPLIFIER connec-
tors on the subwoofer
Caution: When connecting the speaker to the amplifier or receiver, be sure to always connect the positive (‘+’) termi-
nals to each other, and the negative (‘-’) terminals to each other. Connecting the wrong terminals together could
damage the amplifier or cause poor sound quality.
2. 3.
More user manuals on ManualsBase.com
Exploring and using Placing the SW-200
the unit
Placing your SW-200 Powered • Once you settle on a location, be PHASE on the SW-200 so it
7 6 5 4
Front Back Subwoofer is very easy. Because the sure to leave yourself some works the best with the front
SW-200 (or any subwoofer) is non- room for minor movements of a (left and right) speakers. Here
directional (it does not send its few inches—this can help fine- are our recommendations:
soundwaves out in a particular tune the sound in the seating
FROM AMPLIFIER
3 direction), where you place it is not area • Set the subwoofer’s LOW
+ R – + L – LINE IN
9 POWER
STANDBY
RED
AUTO
SHUTOFF
ON OFF
L
VOLUME
CONTROL
PHASE
REV NOM
LOW PASS
CROSSOVER
60
Hz
80
100
+ R – +
TO SPEAKERS
L –
R
MIN MAX
50 150
120
ON
suggestions for getting the most out subwoofer away from the TV VOLUME control to the ‘11-
CAUTION
4. 5.
More user manuals on ManualsBase.com
Safety First
Please read these safety instructions 6. To clean, use a clean, dry cloth. will state this), it is not subject to power outlet, and at the point they 5. Each unit has ventilation open-
carefully. They can help prevent To avoid damage, NEVER use these problems. connect to the unit. ings to keep it from overheating. Do
electrical shock, fire, and damage to volatile solvents such as alcohol, NOT cover or block these open-
the unit. paint thinner, gasoline, benzene, etc. 9. Do NOT place the unit on an 4. Each unit is equipped with a ings. Place the unit at least 6 in from
to clean the cabinet. If this is an unstable cart, shelf, stand, tripod, polarized power plug (with one the wall so that it is properly venti-
2. Protect your unit from moisture. electrically-powered unit, unplug it bracket, or table. if you mount the blade wider than the other) that lated.
Safety Symbols Don’t place your unit near water— before cleaning. unit, follow the instructions in the only fits one way into an electrical
for example, a bathtub, kitchen sink, manual and, if possible, use a outlet, as a safety feature. If you 6. Before a lightning storm or when
CAUTION
RISK OF ELECTRIC SHOCK
laundry tub, wet basement, or near mounting bracket recommended for cannot fit the plug into your electri- you leave the unit unattended and
DO NOT OPEN
a swimming pool. the unit. If you place the unit on a cal outlet, try turning the plug over. unused for long periods of time,
moveable cart, use caution when If it still doesn’t fit, you may need to unplug it from the wall outlet and
We’ve placed these safety symbols 3. Keep your unit out of extreme moving the cart to avoid overturn- have an electrician replace your any antenna or cable. This can
on the back of electrically-powered hot and cold. Your unit may not ing it. outlet with a new one that is UL- prevent damage to the unit from
units to alert you to the danger of work properly if it is used at approved. lightning and power-line surges.
electrical shock. Do NOT remove extremely low or freezing tempera- Additional safeguards for elec-
the cover or back of the unit, tures. Don’t place your unit near trically-powered units
because there are operating radiators, heat registers, stoves, or Specifications:
electrical parts inside that can cause other heat sources. 7. Do NOT attempt to service this 1. If you see smoke or smell
Type Subwoofer system with
electrical shock. If the unit needs unit. You should take the unit to anything unusual near your unit, turn
built-in amplifier
servicing, take it to qualified service qualified service personnel for repair off the entire system immediately,
Amplifier
personnel—do NOT try to open when: and unplug it from the wall. Then
Power handling 50 watts RMS into 4 ohms, from
the unit and service it yourself. contact your Kenwood dealer or
20 Hz to 200 Hz, with no more
• Objects have fallen or liquids nearest service center.
than 0.04% total harmonic distor-
have been spilled into the unit
Safety Precautions tion
2. Only connect the unit to a
Phase switching Normal, Reverse
• The unit has been exposed to power supply that matches that
Input sensitivity and input impedance
For all units moisture described in the technical specifica-
RCA-type jack 50 mV (10 k-ohms)
4. Don’t put objects or liquids into tions in the back of the manual that
Push-type terminals 1.0 V (4.7 k-ohms)
1. Dispose of the packaging materi- the unit! NEVER permit children to • The unit doesn’t appear to oper- came with it. If you are not sure of
Supply voltage AC 110 V ~ 120 V
als properly. After you take the unit put anything into the unit. ate normally or exhibits a marked the type of power supply in your
Rated power consumption 60 watts
out of its shipping bag, dispose of change in performance home, ask your Kenwood dealer or
the bag, keeping it out of the reach 5. NEVER try to open the unit or your local power company for help. Speaker
of children and animals. Be aware take it apart. • The unit has been dropped or To avoid the possibility of fire or Enclosure Vented
that the bag could cause suffocation. the case has been damaged electrical shock, do NOT overload Speaker units 8 in (200 mm) cone-type
the electrical outlet or any extension Nominal impedance 4 ohms
8. To prevent distortion (and in cords. Width 13 in (330 mm)
some cases, discoloration of TV Height 13 in (330 mm)
pictures), keep the unit away from 3. Place the power supply cords in Depth 13 in (330 mm) with grille
sources of magnetic fields, such at such a way that they will not be Net weight 25 lbs
TVs, radios, motorized toys, or walked on or pinched by items Supplied accessories Feet (4)
magnetized objects. If the unit is placed against them. Never pull or
magnetically-shielded (the manual stretch power cords, and use special Since Kenwood follows a policy of continuous advancement in devel-
care with the cords at the plugs, in a opment, these specifications may change without notice.
6. 7.
More user manuals on ManualsBase.com
KENWOOD USA CORPORATION
PO Box 22745 Printed on recycled paper using
Long Beach, California 90801-5745 10% post-consumer waste.