Professional Documents
Culture Documents
How To Make CDS - Detailed and Quick Version
How To Make CDS - Detailed and Quick Version
How To Make CDS - Detailed and Quick Version
1 2 3
Push the shot glass to one side Pour distilled water into the Use a 5ml syringe to measure
of the Mason jar. Mason jar. Ensure that the water Sodium Chlorite (NaClO₂) and
level is a ¼” (6mm) below the Hydrochloric Acid (HCl).
shot glass brim.
4 5 6
Created by JC 10/23/21
2
If desired, syringe plunger can be Fill syringe with 5 ml of Sodium Fill syringe with 5 ml of
removed to simplify filling. Note, Chlorite. Release Sodium Hydrochloric Acid. Release
4% HCl is a weak solution. Hands Chlorite into shot glass. Make Hydrochloric Acid into shot glass.
can be washed when done. sure it only enters the shot glass. Make sure it only enters the shot
glass.
7 8 9
The Sodium Chlorite will begin to Close the Mason jar lid to Ensure that the Mason jar lid is
react with Hydrochloric Acid to prevent Chlorine Dioxide gas locked.
create Chlorine Dioxide. from escaping.
10 11 12
Chlorine Dioxide gas will begin to Place the Mason jar in a cabinet. Make sure the temperature is
buildup within the Mason jar and well above 51.8° F (11° C). Higher
infuse into distilled water. temperature will increase gas off
and decrease infusion time.
13 14 15
Created by JC 10/23/21
3
Wait 12 to 24 hours for Chlorine Remove Mason from cabinet. Make sure the Mason jar is
Dioxide to infuse into distilled Ensure the working area is clean unlocked outdoors or in a well
water. and clear before placing Mason ventilated area.
jar on table.
16 17 18
Warning, high concentrations of Remove shot glass with content. Close and lock Mason jar to
Chlorine Dioxide gas have built avoid losing Chlorine Dioxide
up within Mason jar. Stand back gas.
when opening.
19 20 21
The contents in shot glass can If desired, pour shot glass Dilute spray bottle contents with
either be disposed of or used as contents into spray bottle. water. Can be used to disinfect
a disinfectant (i.e. Spray bottle floors, countertops, bathrooms,
with water). etc.
22 23 24
Created by JC 10/23/21
4
Replace spray bottle spray Open lid and place shot glass Ensure that shot glass in placed
handle. into Mason jar again. in the center of Mason jar.
25 26 27
Fill syringe with 5 ml of Sodium Fill syringe with 5 ml of The Sodium Chlorite will begin to
Chlorite. Release Sodium Hydrochloric Acid. Release react with Hydrochloric Acid to
Chlorite into shot glass. Make Hydrochloric Acid into shot glass. create Chlorine Dioxide.
sure it only enters the shot glass. Make sure it only enters the shot
glass.
28 29 30
Close lid and lock Mason jar. Place the Mason jar in a cabinet. Wait 12 to 24 hours for Chlorine
Chlorine Dioxide gas off and Dioxide to infuse into distilled
infuse into distilled water. water.
31 32 33
Created by JC 10/23/21
5
34 35 36
Place test strip in diluted The solution should be 300 ppm Store CDS inside a refrigerator.
solution for 2 seconds then wait when diluted with 9 ml of Note, temperatures greater than
10 seconds for final results. distilled water. This means final 51.8°F (11°C) will cause the
Compare color to bottle label. concentration is 3,000 ppm. Chlorine Dioxide to gas off.
37 38 39
Created by JC 10/23/21
6
Next, add distilled water The Mason jar should be placed in a dark
inside the glass Mason place (i.e cabinet) for at least 12 hours.
jar. Ensure that no Make sure ambient temperature is
distilled water enters greater than 51.8° F (11° C). Keep out of
the shot glass. Sodium Chlorite (MMS) reach of children.
and Hydrochloric Acid
Make sure the water Chlorine Dioxide gas
(HCl) reaction will create
level is a ¼” (6mm) begins to saturate the
Chlorine Dioxide gas.
below the shot glass. distilled water.
4 5 6 7
After 12 hours, the distilled Open the bottle and remove the shot glass Reinsert the shot glass with the Repeat step 3 again.
water inside the Mason jar containing the excess solution. Avoid same mixture described in step 2.
should have a yellow/amber inhaling the gases that come out of the
The idea is to repeat steps 2
color. Mason jar.
and 3 in order to reach a
Chlorine Dioxide
CDS with 1,500 ppm of Store the excess solution in another bottle
concentration of 3,000 ppm.
Chlorine Dioxide must (i.e spray bottle). This excess solution can
repeat the process to be used as a disinfectant to clean surfaces.
After 12 hours, CDS will
reach 3,000 ppm. obtain an optimum quality
ready to be used.
Created by JC 10/23/21
7
1 2 3
Created by JC 10/23/21