The document provides instructions for installing components on a micro heater board to produce a 6.3V DC output from a 10-12V AC input. Key steps include installing a voltage regulator, dropping resistor, and filter capacitors to regulate the voltage. Diodes are included and their polarity must be observed. Larger capacitors can be used for higher performance. The heater board will be elevated approximately 25V above ground when using a grounding capacitor.
The document provides instructions for installing components on a micro heater board to produce a 6.3V DC output from a 10-12V AC input. Key steps include installing a voltage regulator, dropping resistor, and filter capacitors to regulate the voltage. Diodes are included and their polarity must be observed. Larger capacitors can be used for higher performance. The heater board will be elevated approximately 25V above ground when using a grounding capacitor.
The document provides instructions for installing components on a micro heater board to produce a 6.3V DC output from a 10-12V AC input. Key steps include installing a voltage regulator, dropping resistor, and filter capacitors to regulate the voltage. Diodes are included and their polarity must be observed. Larger capacitors can be used for higher performance. The heater board will be elevated approximately 25V above ground when using a grounding capacitor.
insulator and heatsink kit micro heater heater board
instruction sheet
install 4.7uf film capacitors install dropping resistor to heatsink.
and fixed voltage resistors (1k and 249 ohm) install 3 amp diodes. using thermal pad or thermal compound. these set the voltage to 6.3v (+/- 5%) note the polarity band use t0-220 mounting kit. on the diode .
you may use TO-220 type
diodes by spreading the leads to fit the diode footprints
6.3VDC OUTPUT
10 TO 12VAC INPUT NOTE :
if grounding the pcb
through a capacitor (.1)
the heater will be el- GROUND PCB THROUGH
evated aprox 25v above .1@200V CAPACITOR ground.
you must take DC mea-
surments from the heat- install capacitors , note polarity. er pcb. or the heater use 2200uf@25v capacitors or 6800uf@25v terminals. for higher performance (16mm radial type) i.e if you take a read- leave blank ing with your multime- optional 10w axial WW dropping resistor install .1@200v film capacitor ter using the chassis in parallel with the caddock resistor. ground .
the reading will say
25v micro heater board mouser cart link : beacause the heater pcb is elevated 25v abouve ground . http://www.mouser.com/ProjectManager/ProjectDetail.aspx?AccessID=faa129a4a7