Professional Documents
Culture Documents
Error and Status Messages Loca
Error and Status Messages Loca
Command failed.
Exit LanSafe and run the application again. If the problem persists, write down the specific tasks you were performing when this error occurred. Contact
Technical Support for more information.
Saving Management Settings with both assigned and unassigned Power Monitors is not allowed. You must assign all Power Monitors to load
segments or move all Power Monitors to Unassigned before saving your settings.
LanSafe does not allow settings in which some Power Monitors are assigned to Unassigned while others are assigned to Load Segments (this condition can
lead to data loss). When a new Power Monitor is added to a UPS Group, its default location in Management Settings is Unassigned and all assigned Power
Monitors revert to Unassigned. This condition does not affect Power Monitor Countdown or System Shutdown durations.
You can prevent this condition from occurring by installing all UPS Group members before configuring Management Settings.
Top ^
Note
Most UPSs support a limited number of the events shown below. Determine the capabilities of your UPS before configuring Event Notification to prevent
unnecessary work.
0. Controller shutdown pending
1. Shutdown in 1 minute
2. Shutdown cancelled
3. Shutting down
4. Controller communications lost
5. Controller communications established
6. Power Monitor loaded
7. Power Monitor unloaded
8. Diagnostic test reminder
9. Communications port unavailable
10. Diagnostic test performed
11. Replace battery reminder
12. Scheduled/Manual shutdown
13. LanSafe software installed
14. UPS communications lost
15. UPS communications established
16. Abnormal operation
17. Abnormal operation resolved
18. Power failure
19. Power failure resolved
20. Low battery
21. Low battery resolved
22. Bypass condition
23. Bypass condition resolved
24. Battery disconnect
25. Battery disconnect resolved
26. Backfeed contact failure
27. Backfeed contact failure resolved
28. Abnormal battery discharge
29. Abnormal battery discharge resolved
30. Battery fuse failure
4 de 7 19/12/2022 09:48 a. m.
Error and Status Messages https://powerquality.eaton.com/Products-services/Power-Management/S...
5 de 7 19/12/2022 09:48 a. m.
Error and Status Messages https://powerquality.eaton.com/Products-services/Power-Management/S...
6 de 7 19/12/2022 09:48 a. m.
Error and Status Messages https://powerquality.eaton.com/Products-services/Power-Management/S...
Top ^
7 de 7 19/12/2022 09:48 a. m.