Download as pdf or txt
Download as pdf or txt
You are on page 1of 1

Multi-function display 6.

8
Fault code output in display (R) (Fig. 1) played instead of the engine speed, the LED in display
In case of an combustion engine fault a three-digit "O" keeps flashing until the fault has been rectified.
fault code appears in display "R". The fault code is dis- The following table helps to identify the fault codes.

Fault codes in the Fault code in Description of fault code


display EMR2
32 Charge air temperature warning
E01
42 Charge air temperature shut-down
31 Coolant temperature warning
E02
41 Coolant temperature shut-down
E03 36 Fuel temperature warning
E04 4 Overspeed shut-down
30 Oil pressure warning
E05
40 Oil pressure shut-down
34 Coolant level warning
E06
44 Coolant level shut-down
E07 5 Reference input sensor
E08 8 Oil pressure sensor
E09 7 Charge air pressure sensor
E10 10 Charge air temperature sensor
E11 9 Coolant temperature sensor
E12 11 Fuel temperature sensor
E13 6 Reference input sensor 2
E14 68 Error CAN Step 1
E15 93 Stack overflow in program
E16 90 Parameter fault (read EEPROM or checksum error)
78 Cyclic RAM test
80 Power supply (actuator) for control
83 Reference voltage 1 (control)
E17
84 Reference voltage 2 (control)
85 Reference voltage 4 (control)
94 Internal program error
E18 60 Digital output 3 (shut-down solenoid, Pin M2)
E19 62 Digital output 6 (Pin M7)
E20 63 Overcurrent shut-off solenoid
E21 53 Control path difference in actuator
E22 3 Speed sensor
1 Rotary speed sensor 1
E23
2 Rotary speed sensor 2
E24 71 CAN interface (SAE J 1939) communication
E25 67 Error Manual Setp 1
E26 87 Atmospheric pressure (control unit)
E27 86 Internal temperature (control unit)
E28 70 CAN Bus Controller (communication)
E29 50 Feedback (actuator)
E30 77 Cyclic program test (memory)
E31 76 Parameter programming (writing to EEPROM) memory
E32 59 Auto calibration BOSCH-EDC pumps has failed (actuator)
E33 52 Reference feedback (actuator)
E34 35 Rotary speed warning (in thrust operation)
E35 74 Cable breakage, short circuit or severe bus error (communication)

008 910 44 BOMAG 127

You might also like