Professional Documents
Culture Documents
EE417 BEE3073 Final Exam Jan-Apr 2022 Supplementary
EE417 BEE3073 Final Exam Jan-Apr 2022 Supplementary
SUPPLEMENTARY EXAMINATION
INSTRUCTIONS TO CANDIDATES:
FIVE (5) questions set. Attempt All FIVE (5). (100 marks)
This question paper consists of 3 pages, excluding the cover page. Answers to the
questions can be written in the answer booklet. Candidates are not allowed to
bring into the Examination Hall textbooks, lecture notes, files or any
unauthorized materials except writing equipment and scientific calculator.
Electronic dictionaries are strictly prohinited.
This question paper must be submitted along with all used and/or unused rough
papers and/or graph papers (if any). Candidates are NOT allowed to take any
examination materials out of the examination hall.
Warning:
The University Examination Board of UCSI University regards cheating as a most
serious offence and will not hesitate to mete out the appropriate punitive actions
according to the severity of the offence committed, and in accordance with the clauses
stipulated in the Students’ Handbook, up to and including expulsion from UCSI
University.
January-April 2022 Supplementary Examination EE417/BEE3073 Power Electronics
Q1(a) (i) Identify the 4 major types of power electronic converter with the aid of its
general symbol illustration.
(4 marks)
(ii) Briefly distinguish each power electronic function.
(4 marks)
(b) With refers to IRF540 MOSFET datasheet in page 3, where the junction
temperature Tj is 85⁰ C and the ambient temperature Ta is 27⁰ C, determine the
power dissipation of the MOSFET transistor.
(2 marks)
(a) Illustrate the three phase full-wave controller circuit suppling a Y-connected
resistive load.
(5 marks)
(b) Calculate the rms voltage output for the delay firing angle of α = π/4
(5 marks)
(c) Calculate the rms voltage output for the delay firing angle of α = π/2.5
(5 marks)
(d) Calculate the rms voltage output for the delay firing angle of α = π/1.5
(5 marks)
Page 1 of 3
January-April 2022 Supplementary Examination EE417/BEE3073 Power Electronics
(d) Illustrate the basic buck converter topology, and derive it s-domain transfer
function based on it on-state and off-sstate operating principle.
(12 marks)
(b) Illustrate the circuit of single phase inverter topology with LCL filter
connected to the grid.
(5 marks)
(c) Illustrate the feedback control block diagram with equations for the grid
connected inverter.
(5 marks)
Q5 (a) Illustrate the circuit of single phase half-wave, single phase full-wave and
three phase rectifier. Determine each rectification efficiency.
(15 marks)
Page 2 of 3
January-April 2022 Supplementary Examination EE417/BEE3073 Power Electronics
DATASHEET
Page 3 of 3