Professional Documents
Culture Documents
Grinnel Fig 577
Grinnel Fig 577
www.grinnell.com
Contacts
and draining the system. Failure to do • ANSI: listing, and approval information, contact
your GRINNELL Representative.
so may result in serious personal injury, Carbon Steel oval neck track head
property damage, and/or impaired de- bolts are heat-treated and conform
vice performance. to the physical properties of ASTM
A 183 Grade 2 and SAE J429 Grade
It is the designer’s responsibility to se- 5 with a minimum tensile strength of
lect products suitable for the intended 110,000 psi.
service and to ensure that pressure
ratings and performance data are not Carbon Steel heavy hex nuts con-
exceeded. Material and gasket selec- form to the physical properties of
tion should be verified to be compat- ASTM A 183 Grade 2 and SAE J995
ible for the specific application. Always Grade 5. Bolts and nuts are zinc-
read and understand the installation electroplated conforming to ASTM
B 633. Gaskets
instructions.
• Grade “E” EPDM,
The GRINNELL Figure 577 Grooved Stainless Steel Bolts and Nuts are Green color code,
Lightweight Rigid Coupling described available upon request. -30°F to 230°F (-34°C to 110°C)
herein must be installed and maintained • Metric: • Tri-Seal Grade “E” EPDM,
in compliance with this document, as Carbon steel oval neck track head Green color code,
well as with the applicable standards of bolts (Gold color coded) are heat- -30°F to 230°F (-34°C to 110°C)
the Approval agency, in addition to the treated and conform to the physical
standards of any other authorities hav- properties of ASTM F 568 M with Recommended for use in vacuum
ing jurisdiction. Failure to do so may re- a minimum tensile strength of 760 systems
sult in serious personal injury or impair MPa. • Grade “L” Silicone,
the performance of these devices. Red gasket,
Carbon Steel heavy hex nuts con-
The owner is responsible for maintain- form to the physical properties of -30°F to 350°F (-34°C to 177°C)
ing their mechanical system and devic- ASTM A 563 M Class 9. Bolts and • Grade “T” Nitrile,
es in proper operating condition. The nuts are zinc-electroplated conform- Orange color code,
installing contractor or device manu- ing to ASTM B 633. -20°F to 180°F (-29°C to 82°C)
facturer should be contacted with any
questions. • Grade “O” Fluoroelastomer,
Blue color code,
20°F to 300°F (-7°C to 149°C)
For proper gasket selection, refer to
Technical Data Sheet TFP1895.
B C
FIGURE 577
GROOVED LIGHTWEIGHT
A RIGID COUPLING
1-1/4” - 8” (DN32 TO DN200)
TABLE 1
GRINNELL FIGURE 577 GROOVED LIGHTWEIGHT RIGID COUPLING
— DIMENSIONS —
G135
Page 3 of 4